SAFETY DATA SHEET. 1. Identification. 2. Hazard(s) identification. 3. Composition/information on ingredients. Other means of identification None.

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Superseal 355, Superseal 355 Plus, Superseal 631 Other means of identification ne. Recommended use Pavement Sealer Recommended restrictions ne known. Manufacturer/Importer/Supplier/Distributor information Manufacturer: Crafco, Inc. Address: 6165 West Detroit St. Chandler, AZ USA Contact Name: Jim Chehovits Telephone: CHEMTREC: (rth America) (International) 2. Hazard(s) identification Physical hazards t classified. Health hazards Carcinogenicity Environmental hazards t classified. OSHA defined hazards t classified. Category 1A Label elements Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Supplemental information Danger May cause cancer. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Wash hands thoroughly after handling. Wear protective gloves/protective clothing/eye protection/face protection. If exposed or concerned: Get medical advice/attention. Store locked up. Dispose of contents/container in accordance with local/regional/national/international regulations. ne known. t applicable. 3. Composition/information on ingredients Mixtures Chemical name Common name and synonyms CAS number % PITCH, COAL TAR-PETROLEUM QUARTZ TITANIUM DIOXIDE < 1 Composition comments All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. Balance is non-hazardous. 1 / 6

2 4. First-aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed Indication of immediate medical attention and special treatment needed General information 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment/instructions Specific methods General fire hazards 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Move to fresh air. Call a physician if symptoms develop or persist. Wash off with soap and water. Get medical attention if irritation develops and persists. Rinse with water. Get medical attention if irritation develops and persists. Rinse mouth. Get medical attention if symptoms occur. Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. IF exposed or concerned: Get medical advice/attention. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2). Do not use water jet as an extinguisher, as this will spread the fire. During fire, gases hazardous to health may be formed. Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Move containers from fire area if you can do so without risk. Use standard firefighting procedures and consider the hazards of other involved materials. unusual fire or explosion hazards noted. Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Wear appropriate personal protective equipment. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ensure adequate ventilation. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is possible. Cover with plastic sheet to prevent spreading. Absorb in vermiculite, dry sand or earth and place into containers. Prevent entry into waterways, sewer, basements or confined areas. Following product recovery, flush area with water. Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Environmental precautions 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Avoid discharge into drains, water courses or onto the ground. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Avoid prolonged exposure. Provide adequate ventilation. Wear appropriate personal protective equipment. Observe good industrial hygiene practices. Store locked up. Store in original tightly closed container. Store away from incompatible materials (see Section 10 of the SDS). 2 / 6

3 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR ) Components Type Value Form DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC (CAS ) US. NIOSH: Pocket Guide to Chemical Hazards Components Type DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC (CAS ) Biological limit values Appropriate engineering controls PEL 5 mg/m3 Mist. Value Form STEL 10 mg/m3 Mist. TWA 5 mg/m3 Mist. biological exposure limits noted for the ingredient(s). Provide adequate ventilation, including appropriate local extraction, to ensure that the defined occupational exposure limit is not exceeded. Individual protection measures, such as personal protective equipment Eye/face protection Wear safety glasses with side shields (or goggles). Use personal protective equipment as required. Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations 9. Physical and chemical properties Appearance Odor Physical state Form Color Odor threshold Chemical resistant gloves are recommended. If contact with forearms is likely wear gauntlet style gloves. Wear appropriate clothing to prevent any possibility of skin contact. When workers are facing concentrations above the exposure limit they must use appropriate certified respirators. Wear appropriate thermal protective clothing, when necessary. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. Liquid. Liquid. ph 7-9 Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) Dark brown Petroleum 32 F (0 C) 212 F (100 C) > F (> C) Cleveland Open Cup Upper/lower flammability or explosive limits Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Vapor density 3 / 6

4 Relative density Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products 11. Toxicological information Moderately Soluble cp Information on likely routes of exposure Inhalation Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity The product is stable and non-reactive under normal conditions of use, storage and transport. Material is stable under normal conditions. dangerous reaction known under conditions of normal use. Avoid temperatures exceeding the flash point. Contact with incompatible materials. Strong oxidizing agents. hazardous decomposition products are known. Prolonged inhalation may be harmful. adverse effects due to skin contact are expected. Expected to be a low ingestion hazard. t expected to be acutely toxic. Prolonged skin contact may cause temporary irritation. Based on available data, the classification criteria are not met. This product is not expected to cause skin sensitization. data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. May cause cancer. IARC Monographs. Overall Evaluation of Carcinogenicity QUARTZ (CAS ) 1 Carcinogenic to humans. TITANIUM DIOXIDE (CAS ) 2B Possibly carcinogenic to humans. US. National Toxicology Program (NTP) Report on Carcinogens QUARTZ (CAS ) Known To Be Human Carcinogen. US. OSHA Specifically Regulated Substances (29 CFR ) t regulated. Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Chronic effects This product is not expected to cause reproductive or developmental effects. t classified. t classified. Due to partial or complete lack of data the classification is not possible. Prolonged inhalation may be harmful. Prolonged exposure may cause chronic effects. 4 / 6

5 12. Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects 13. Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code Waste from residues / unused products Contaminated packaging 14. Transport information DOT t regulated as dangerous goods. IATA t regulated as dangerous goods. IMDG t regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code 15. Regulatory information US federal regulations The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. data is available on the degradability of this product. data available. t expected to be mobile in soil. other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. Collect and reclaim or dispose in sealed containers at licensed waste disposal site. This material and its container must be disposed of as hazardous waste. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of contents/container in accordance with local/regional/national/international regulations. Dispose in accordance with all applicable regulations. The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied. t applicable. This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR All components are on the U.S. EPA TSCA Inventory List. TSCA Section 12(b) Export tification (40 CFR 707, Subpt. D) t regulated. CERCLA Hazardous Substance List (40 CFR 302.4) t listed. US. OSHA Specifically Regulated Substances (29 CFR ) t regulated. Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Delayed Hazard - Fire Hazard - Pressure Hazard - Reactivity Hazard - SARA 302 Extremely hazardous substance t listed. SARA 311/312 Hazardous chemical 5 / 6

6 SARA 313 (TRI reporting) t regulated. Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List t regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) t regulated. Safe Drinking Water Act (SDWA) US state regulations t regulated. US - California Proposition 65 - CRT: Listed date/carcinogenic substance QUARTZ (CAS ) Listed: October 1, 1988 TITANIUM DIOXIDE (CAS ) Listed: September 2, 2011 US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, , subd. (a)) DISTILLATES (PETROLEUM), HYDROTREATED HEAVY NAPHTHENIC (CAS ) PITCH, COAL TAR-PETROLEUM (CAS ) QUARTZ (CAS ) TITANIUM DIOXIDE (CAS ) International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada China Europe Europe Japan Korea New Zealand Philippines United States & Puerto Rico Domestic Substances List (DSL) n-domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of tified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date Version # 01 NFPA ratings Disclaimer Health: 2 Flammability: 1 Instability: 0 The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. 6 / 6