SAFETY DATA SHEET. Revision Date 07-May-2015 Revision Number Identification. No information available

Transcription

1 SAFETY DATA SHEET Revision Number 1 Product Name Cat No. : Synonyms Recommended Use 1. Identification XLD AGAR BASE R Laboratory chemicals. Uses advised against No Information available Details of the supplier of the safety data sheet Company Remel Santa Fe Drive Lenexa, KS United States Telephone: Fax: Emergency Telephone Number INFOTRAC - 24 Hour Number: Outside of the United States, call 24 Hour Number: (Call Collect) 2. Hazard(s) identification Classification This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR ) Specific target organ toxicity (single exposure) Category 3 Target Organs - Respiratory system. Specific target organ toxicity - (repeated exposure) Category 2 Target Organs - Liver. Label Elements Signal Word Warning Hazard Statements May cause respiratory irritation May cause damage to organs through prolonged or repeated exposure Page 1 / 7

2 Precautionary Statements Prevention Do not breathe dust/fume/gas/mist/vapors/spray Use only outdoors or in a well-ventilated area Response Get medical attention/advice if you feel unwell Inhalation IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing Call a POISON CENTER or doctor/physician if you feel unwell Storage Store in a well-ventilated place. Keep container tightly closed Store locked up Disposal Dispose of contents/container to an approved waste disposal plant Hazards not otherwise classified (HNOC) None identified 3. Composition / information on ingredients Component CAS-No Weight % Sodium chloride Phenol Red Ferric ammonium citrate Sodium carbonate Sodium thiosulfate First-aid measures Eye Contact Skin Contact Inhalation Ingestion Most important symptoms/effects Notes to Physician Suitable Extinguishing Media Unsuitable Extinguishing Media Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Obtain medical attention. Wash off immediately with plenty of water for at least 15 minutes. Get medical attention immediately if symptoms occur. Move to fresh air. Get medical attention immediately if symptoms occur. Clean mouth with water and drink afterwards plenty of water. Get medical attention if symptoms occur. None reasonably foreseeable. Product is a corrosive material. Use of gastric lavage or emesis is contraindicated. Possible perforation of stomach or esophagus should be investigated: Ingestion causes severe swelling, severe damage to the delicate tissue and danger of perforation Treat symptomatically 5. Fire-fighting measures Use water spray, alcohol-resistant foam, dry chemical or carbon dioxide. Page 2 / 7

3 Flash Point Method - Autoignition Temperature Explosion Limits Upper Lower Sensitivity to Mechanical Impact Sensitivity to Static Discharge Specific Hazards Arising from the Chemical Keep product and empty container away from heat and sources of ignition. Hazardous Combustion Products None known Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 3 Flammability 0 Instability 0 Physical hazards W Personal Precautions Environmental Precautions 6. Accidental release measures Ensure adequate ventilation. Use personal protective equipment. Avoid dust formation. Should not be released into the environment. Methods for Containment and Clean Sweep up or vacuum up spillage and collect in suitable container for disposal. Avoid dust Up formation. Handling Storage Exposure Guidelines 7. Handling and storage Wear personal protective equipment. Ensure adequate ventilation. Avoid contact with skin, eyes and clothing. Avoid ingestion and inhalation. Avoid dust formation. Keep containers tightly closed in a dry, cool and well-ventilated place. 8. Exposure controls / personal protection Component ACGIH TLV OSHA PEL NIOSH IDLH Ferric ammonium citrate TWA: 1 mg/m 3 (Vacated) TWA: 1 mg/m 3 TWA: 1 mg/m 3 Component Quebec Mexico OEL (TWA) Ontario TWAEV Ferric ammonium citrate TWA: 1.0 mg/m 3 TWA: 1 mg/m 3 STEL: 2 mg/m 3 TWA: 1 mg/m 3 Legend ACGIH - American Conference of Governmental Industrial Hygienists OSHA - Occupational Safety and Health Administration NIOSH IDLH: The National Institute for Occupational Safety and Health Immediately Dangerous to Life or Health Engineering Measures Ensure adequate ventilation, especially in confined areas. Personal Protective Equipment Eye/face Protection Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard Page 3 / 7

4 EN166. Skin and body protection Respiratory Protection Hygiene Measures Wear appropriate protective gloves and clothing to prevent skin exposure. Follow the OSHA respirator regulations found in 29 CFR or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Handle in accordance with good industrial hygiene and safety practice. 9. Physical and chemical properties Physical State Powder Solid Appearance Odor Odor Threshold ph Melting Point/Range Boiling Point/Range Flash Point Evaporation Rate Flammability (solid,gas) Flammability or explosive limits Upper Lower Vapor Pressure Vapor Density Relative Density Solubility Partition coefficient; n-octanol/water Autoignition Temperature Decomposition Temperature Viscosity 10. Stability and reactivity Reactive Hazard Stability Conditions to Avoid Incompatible Materials Stable under normal conditions. Incompatible products. Excess heat. Avoid dust formation. Strong oxidizing agents Hazardous Decomposition Products None under normal use conditions Hazardous Polymerization Hazardous Reactions Acute Toxicity Hazardous polymerization does not occur. None under normal processing. 11. Toxicological information Component Information Component LD50 Oral LD50 Dermal LC50 Inhalation Sodium chloride 3 g/kg ( Rat ) 10 g/kg ( Rabbit ) 42 g/m 3 ( Rat ) 1 h Sodium carbonate 2800 mg/kg ( Rat ) > 2000 mg/kg (rabbit) 2.3 mg/l 2h (Rat) Sodium thiosulfate 5000 mg/kg ( Rat ) Not listed Not listed Toxicologically Synergistic Products Page 4 / 7

5 Delayed and immediate effects as well as chronic effects from short and long-term exposure Irritation Sensitization Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Component CAS-No IARC NTP ACGIH OSHA Mexico Sodium chloride Not listed Not listed Not listed Not listed Not listed Phenol Red Not listed Not listed Not listed Not listed Not listed Ferric ammonium Not listed Not listed Not listed Not listed Not listed citrate Sodium carbonate Not listed Not listed Not listed Not listed Not listed Sodium thiosulfate Not listed Not listed Not listed Not listed Not listed Mutagenic Effects Reproductive Effects Developmental Effects Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration hazard... Respiratory system Liver Symptoms / effects,both acute and delayed Endocrine Disruptor Information Product is a corrosive material. Use of gastric lavage or emesis is contraindicated. Possible perforation of stomach or esophagus should be investigated: Ingestion causes severe swelling, severe damage to the delicate tissue and danger of perforation Other Adverse Effects Ecotoxicity Do not empty into drains. The toxicological properties have not been fully investigated. 12. Ecological information Component Freshwater Algae Freshwater Fish Microtox Water Flea Sodium chloride Not listed Pimephals prome: LC50: Not listed EC50: 1000 mg/l/48h 7650 mg/l/96h Sodium carbonate 242 mg/l EC50 = 120 h Lepomis macrochirus: LC50: mg/l EC50 = 48 h 300 mg/l/96h Gambusia affinis: LC50: 740 mg/l/96h Sodium thiosulfate Not listed mg/l LC50 96 h Not listed Not listed Persistence and Degradability Bioaccumulation/ Accumulation. Mobility. Component log Pow Sodium thiosulfate Waste Disposal Methods 13. Disposal considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. Chemical waste generators must also consult local, regional, and national hazardous waste regulations to ensure complete and accurate classification. Page 5 / 7

6 DOT TDG IATA IMDG/IMO 14. Transport information 15. Regulatory information All of the components in the product are on the following Inventory lists: X = listed International Inventories Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL Sodium chloride X X X X X X X Phenol Red X X X - - X X Ferric ammonium citrate X X X - X X X Sodium carbonate X X X X X X X Sodium thiosulfate X X X X X X X Legend: X - Listed E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA. F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA. N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is considered to cover the designated polymer made with any free-radical initiator regardless of the amount used. P - Indicates a commenced PMN substance R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA. S - Indicates a substance that is identified in a proposed or final Significant New Use Rule T - Indicates a substance that is the subject of a Section 4 test rule under TSCA. XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial Updating of the TSCA Inventory Data Base Production and Site Reports (40 CFR 710(B). Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater. Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a specified list of low concern reactants that comprises one of the eligibility criteria for the exemption rule. U.S. Federal Regulations TSCA 12(b) SARA 313 SARA 311/312 Hazardous Categorization Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard No No Clean Water Act Component CWA - Hazardous CWA - Reportable CWA - Toxic Pollutants CWA - Priority Pollutants Substances Quantities Ferric ammonium citrate X Clean Air Act OSHA Occupational Safety and Health Administration CERCLA Component Hazardous Substances RQs CERCLA EHS RQs Page 6 / 7

7 Ferric ammonium citrate 1000 lb - California Proposition 65 This product does not contain any Proposition 65 chemicals State Right-to-Know Component Massachusetts New Jersey Pennsylvania Illinois Rhode Island Ferric ammonium citrate X X X - X U.S. Department of Transportation Reportable Quantity (RQ): DOT Marine Pollutant DOT Severe Marine Pollutant N N N U.S. Department of Homeland Security This product does not contain any DHS chemicals. Other International Regulations Mexico - Grade Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR WHMIS Hazard Class E Corrosive material F Dangerously reactive material D2B Toxic materials Prepared By 16. Other information Regulatory Affairs Thermo Fisher Scientific EMSDS.RA@thermofisher.com Revision Date Print Date Revision Summary 07-May May-2015 This document has been updated to comply with the US OSHA HazCom 2012 Standard replacing the current legislation under 29 CFR to align with the Globally Harmonized System of Classification and Labeling of Chemicals (GHS) Disclaimer The information provided on this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of SDS Page 7 / 7