HORIZON-LOC EXPOSED FASTENER TRIMS
|
|
- Clyde Austin
- 5 years ago
- Views:
Transcription
1 Horizon -Loc Horizon-Loc is available in 6ga AZ50 painted Galvalume and bare Galvalume. Central States uses either the CentralGuard or Kynar 500 /Hylar 5000 paint system on all painted metals. Bare (non-painted) metals from Central States will have an acrylic coating. This acrylic coating helps protect the metal during manufacturing and installation. This clear organic treatment applied over the Galvalume coating is invisible, but provides enhanced performance applicability and retained heat reflectivity. There is no need for oils to be applied during forming. This organice treatment eliminates fingerprinting and foot marking during installation. Central States' 6ga steel is manufactured to meet ASTM A79 specifications for Galvalume and ASTM A65 for galvanized with a minimum yield of 50,000 PSI. Horizon-Loc also has UL8/Class 4 Impact Resistance Rating and UL790 Fire Resistance. A minimum roof slope for the /4" tall Horizon-Loc is :. The minimum pitch will allow for sufficient drainage of water. No load table available. Install Horizon-Loc over a solid decking with 0 lb. felt paper or equivalent. NOTE: Oil canning in the flat area of the panels is common to the industry and does not affect the integrity of the panel. Therefore, oil canning is not a reason for rejection. HORIZON-LOC EXPOSED FASTENER TRIMS HORIZON-LOC EAVE TRIM HLRE0(color) HLRE(color) HLRE4(color) HLRE6(color) HLRE8(color) HLRE04(color) 6 ga. only HORIZON-LOC HIGH SIDE EAVE TRIM 6 4 HLHS0(color) HLHS(color) HLHS4(color) HLHS6(color) HLHS8(color) HLHS04(color) HORIZON-LOC PANEL CAP 8 8 HLPC0(color) HLPC(color) HLPC4(color) HLPC6(color) HLPC8(color) HLPC04(color) HORIZON-LOC ZEE CLOSURE 8 HLZC0(color) 8 Butyl tape needed with this product. HORIZON-LOC START/FINISH TRIM HLSF0(color)
2 HORIZON-LOC EXPOSED FASTENER TRIMS 6 ga. only HORIZON-LOC WIDE VALLEY TRIM HLWVT0(color) HLWVT(color) HLWVT4(color) HLWVT6(color) HLWVT8(color) HLWVT04(color) HORIZON-LOC VALLEY HLVT0(color) HLVT(color) HLVT4(color) HLVT6(color) HLVT8(color) HLVT04(color) HORIZON-LOC RAKE TRIM 4 4 HLRRT0(color) HLRRT(color) HLRRT4(color) HLRRT6(color) HLRRT8(color) HLRRT04(color) HORIZON-LOC J-TRIM 8 8 HLJT0(color) HLJT(color) HLJT4(color) HLJT6(color) HLJT8(color) HLJT04(color) HORIZON-LOC RIDGE CAP 5 HLRH0(color) HLRH(color) HLRH4(color) HLRH6(color) HLRH8(color) HLRH04(color) Recommend 6/ or less. HORIZON-LOC RESIDENTIAL RIDGECAP 8 8 RRCP0(color) RRCP(color) RRCP4(color) RRCP6(color) RRCP8(color) RRCP04(color) HORIZON-LOC HIP CAP 4 4 HIP0(color) HIP(color) HIP4(color) HIP6(color) HIP8(color) HIP04(color)
3 HORIZON-LOC EXPOSED FASTENER TRIMS 6 ga. only HORIZON-LOC DRIP EDGE Not Open 4 HLRDC0(color) HLRDC(color) HLRDC4(color) HLRDC6(color) HLRDC8(color) HLRDC04(color) HORIZON-LOC SIDEWALLTIE-IN 8 HLSW0(color) HLSW(color) HLSW4(color) HLSW6(color) HLSW8(color) HLSW04(color) HORIZON-LOC ENDWALL TIE-IN HLEW0(color) HLEW(color) HLEW4(color) HLEW6(color) HLEW8(color) HLEW04(color) HORIZON-LOC J-TRIM
4 HORIZON-LOC CONCEALED FASTENER TRIMS 6 ga. only HORIZON-LOC DRIP EDGE Not Open 4 HLRDC0(color) HLRDC(color) HLRDC4(color) HLRDC6(color) HLRDC8(color) HLRDC04(color) OPEN HEM RAKE 4 CFRA0(color) CFRA(color) CFRA4(color) CFRA6(color) CFRA8(color) CFRA04(color) Zee & Cleat needed. HORIZON-LOC CLEAT HLCL0(color) 6 OPEN HEM SIDEWALL/ENDWALL 4 CFSI0(color) CFSI(color) CFSI4(color) CFSI6(color) CFSI8(color) CFSI04(color) Zee needed. HORIZON-LOC ZEE CLOSURE HLZC0(color) 8 8 Butyl tape needed.
5 HORIZON-LOC CONCEALED FASTENER TRIMS 6 ga. only OPEN HEM RIDGE CAP CFRC0(color) CFRC(color) CFRC4(color) CFRC6(color) CFRC8(color) CFRC04(color) Specify pitch (recommended 6: or less.) Zee needed. OPEN HEM VALLEY CFVT0(color) OPEN HEM GAMBREL 6 CFGA0(color) CFGA(color) CFGA4(color) CFGA6(color) CFGA8(color) CFGA04(color) Zee needed. OPEN HEM FLAT RIDGE CFFRC0(color) CFFRC(color) CFFRC4(color) CFFRC6(color) CFFRC8(color) CFFRC04(color) Zee needed. OPEN HEM WIDE RIDGE CAP 5 5 CFWRC0(color) CFWRC(color) CFWRC4(color) CFWRC6(color) CFWRC8(color) CFWRC04(color) Specify pitch (recommended 7: or greater.) Zee needed.
6 LOW RIB TRIMS RESIDENTIAL RIDGECAP ga. only RRCP(color) HIP CAP HIP(color) 4 4 VALLEY VT(color) RESIDENTIAL RAKE TRIM 4 4 RRT(color) RESIDENTIAL EAVE TRIM RET(color) 0' GABLE BASE SOFFIT 0 5 GB(color) RESIDENTIAL DRIP EDGE 4 RDC(color) (6/ maximum) o Default is 90 as shown.
7 LOW RIB TRIMS RIDGECAP (RCP) hem WIDE RIDGECAP (RC) 4 4 RCP(color) RC(color) 0'6" Specify pitch MINI CORNER GAMBREL TRIM Lower hem 6 GAUGE ONLY MCRN(color)0 MCRN(color) MCRN(color)4 MCRN(color)6 P ainted Side 5 9 GAUGE LONG TRIM (Available in Michigan City plant only.) MCRN9(color) MCRN9(color)4 MCRN9(color)6 GTL(color) Specify pitch 4
8 SOFFIT TRIMS 9 ga. only F&J ASSEMBLY (SFA & JT) SOFFIT F ADAPTOR 78 SFA J-TRIM JT(color) SOFFIT J-TRIM SJT(color) 8 ALUMINUM SOFFIT Vented (VS) or Solid (SS) VS(color) SS(color) 6 BEADED FASCIA BFT(color) F CHANNEL * 8 FC(color) 8 Michigan City Lowell *Varies by plant location; please call your salesperson to verify availability. Soffit J-Trim Fascia Roof Panel Drip Edge Beaded Fascia Soffit Panel Soffit F Adaptor Wall Panel J-Trim Solid Aluminum Soffit
9 K5 Gutter
10 GUTTERS GUTTER Gutter products not available in Gold, Bare Metal, Hawaiian, or Polar. K5G06(color) 0'6" GUTTER END CAP CORNER BOXES Inside Left Hand Shown Outside CONCEALED FASCIA BRACKET K5GECR(color) K5GECL(color) K5GISQCR K5GOSQCR K5GCFZ Right hand. Left hand. Specify right or left hand. Inside. Outside. Alamo Only. Qty: 00 per box. SPIKES & FERRULES DOWNSPOUT K5GS8 K5GF5 K5GDS0(color) 8" Spike Qty: 50 lbs. per box. 5" Ferrule Qty: 500 per box. 0'0" Qty. 5 per box. DOWNSPOUT STRAP DOWNSPOUT ELBOW 75 K5GSCB(color) K5GEA(color) Qty: 00 per box. Qty: 0 per box. OVAL OUTLET w/ Flange K5GOOFZ Qty: 50 per box.
11 ACCESSORIES PROFILE RIDGE VENT SSRVENT Qty: 00' per package Profile Ridge Vent Ridge Cap Horizon-Loc only Fastener Positioning Adhesive PLPVENT Qty: 00' per package Panel-Loc Plus only PROFILE RIDGE VENT CLIP SSRVENTCLIP Qty: 5 per box Use only flat ridgecap with clips. CLOSURE VENT CLV+ (Panel Loc Plus) ' Available at Jasper, Cedar Hill and Michigan City CLV+M (Panel Loc Plus) (Marco) ' Available at Lowell Item may vary from sample shown. Contact sales rep for more information Closure is /8 tall, may require longer screw for installation. Size Qty: 50 per box Min. qty = closure vent MASTER PIPE FLASHING MPF /4" to 4" MPF /4" to " MPF4 " to 6" MPF6 5" to 9" MPF7 6" to " Maximum Temperature MPF8 7" to " 50 degrees 4SMPF* " to 6" 6SMPF* 5" to 9" 8SMPF* 7" to " Maximum Temperature 0SMPF* " to 6" 500 degrees MASTER PIPE FLASHING WITH ZIPPER MPFZIP* MPFZIP* /" - 4" with zipper 4 /" - 9" with zipper *Not available in all locations. Contact sales rep for lead times. Color # per bag # per box METAL/WOOD SCREWS #0 /4" head (color)mw " All pc /(color)mw /" All pc (color)mw " All pc /(color)mw /" All Except Gold pc (color)mw " All Except Gold pc Per bag or per box quantity only. Minimum quantity bag.
12 ACCESSORIES Color # per bag # per box STITCH SCREWS /4" head 4(color) /4" All Per bag or per box quantity only. Minimum quantity bag. METAL/METAL SCREW# 5/6" head 4(color)MM /4" All (color)MM /4" All (color)mm /" Polar, Brilliant, Stone, Bare, Hunter Per bag or per box quantity only. Minimum quantity bag. LAP SCREWS 5/6" head 78(color)LAP 7/8" All 50 Per bag or per box quantity only. Minimum quantity bag. LOW PROFILE PANCAKE HEAD SCREWS SSRWOOD " Horizon-Loc only BUTYL TAPE Dimensions BT 40' /4" x /6 BTR 40' 7/8" x /6 BT 0 rolls per box BTR 0 rolls per box Min. qty = roll CLOSURES (INSIDE or OUTSIDE) CLOUT Panel Loc outside (no adhesive) ' CLOUT+ Panel Loc Plus outside (no adhesive) ' CLIN Panel Loc inside (no adhesive) ' CLIN+ Panel Loc Plus inside (no adhesive) ' inside CLOUTWGLUE Panel Loc outside (with adhesive) ' CLOUT+GLUE Panel Loc Plus outside (with adhesive) ' CLINWGLUE Panel Loc inside (with adhesive) ' outside CLIN+GLUE Panel Loc Plus inside (with adhesive) ' 00 per box Min. qty = closure
13 ACCESSORIES Dimensions UNIVERSAL POLYFOAM POLY 5' "x /" 0 rolls per box. No glue/adhesive. Width GRAYFLEX Joint Seal Tape GRAYFLEX-6 0' ** Thickness 0 rolls per box. **Expanded size. 6 OUTSIDE CLOSURE WITH GLUE VERSAVENT Ridge Vent Material 6 Color SSRCLOSWGLUEB Black foam Horizon-Loc only VERSA 0 RETRO-EASE Size RETROEASE 00 ft. roll TOUCH UP PAINT Size 4(color)SP.6 oz bottle Available in all colors. with brush 4ZZSP 4.5 oz spray paint Available in backer coat. Color GEOCEL-TRIPOLYMER SEALANT GEO(color) 0.6 oz. tube Clear, gray, white Qty: 4 per box. Min. qty = tube
Hobbs, New Mexico (800) Artesia, New Mexico (575) Carlsbad, New Mexico (575) Lubbock, Texas (866)
Artesia, New Mexico (575) 746-9299 Carlsbad, New Mexico (575) 887-9998 Hobbs, New Mexico (800) -0222 Lubbock, Texas (866) 744-7092 Distributed by: Distributed by: www.steel-depot.com www.steel-depot.com
More informationHorizon-Loc. Product Guide 16" COVERAGE HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES
Horizon-Loc Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES ¾" 1" 4" 16" COVERAGE Copyright 2017, Central States Manufacturing, Inc., All Rights Reserved. D C GUID_PROD_HLOC_170224.4
More informationLight Gauge Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES
Light Gauge Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES The men and women at Central States Manufacturing, Inc. would like to welcome you. OUR MISSION Central States Mfg.,
More informationProduct Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES
5V Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES ½" 24" COVERAGE Copyright 2018, Central States Manufacturing, Inc., All Rights Reserved. D C GUID_PROD_5V_180201 The men
More informationTRIAD CORRUGATED METAL, INC.
TRIAD CORRUGATED METAL, INC. C O M M E R C I A L R E S I D E N T I A L A G R I C U L T U R A L Snap Loc Panel Guide Snap Loc metal panels are a perfect fit for residential, architectural and commercial
More informationTABLE OF CONTENTS PRODUCT CATALOGUE fax OVERVIEW PBR 7.2 LONGSPAN ECONORIB
PRODUCT CATALOGUE www.metroll.us sales@fontana.metroll.com ph. 909.823.7663 fax 909.693.5153 TABLE OF CONTENTS OVERVIEW PBR Product Overview and Color Charts Panel Information and Trim 7.2 LONGSPAN ECONORIB
More informationCentral Texas Metal Roofing Supply Co., Inc 36" SHEET WIDTH 38 ¼ 40 ¼ 38 ¼ 40 ¼ 38 ¼ 40 ¼ 40 ¼ 40 ¼ NET COVERAGE
3 4 " 9" 36" GAUGE PANEL FINISH 26 26 26 26 24 24 24 24 FRONTIER RIB LAP GUARD FRONTIER RIB LAP GUARD FRONTIER RIB LAP GUARD LAP GUARD LAP GUARD GALVALUME GALVALUME SMP SMP GALVALUME GALVALUME KYNAR500
More informationPanel-Loc Plus. Product Guide. Panel-Loc CD 2000 HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES INCLUDES REGIONAL PRODUCTS 36" COVERAGE
Panel-Loc Plus Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES ¾" 9" 36" COVERAGE INCLUDES REGIONAL PRODUCTS Panel-Loc CD 2000 D C GUID_PROD_PLOC_161202.10 The men and women
More information* Other widths available upon request. 24 Gauge Galvalume - Standard Surface. Other gauges and aluminium available upon request.
is a concealed fastener architectural standing seam roof panel. The panels are easily installed over decking, utilizing metal clips. panels are ideally suited for decorative mansard, fascia and roofs.
More informationResidential Pricing Guide
Guide TABLE OF CONTENTS Panels 5V Crimp Slimline 2 4 Accessories Flat Sheets Coils V-Groove Soffit Ridge Caps Roof Jacks Touch-up Paint Insulation Slimline Rib Cover Closure Strips Tube Sealant 6 6 7
More informationM-Loc. Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES 36" COVERAGE
M-Loc Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES 13 /" 36" COVERAGE 6" Copyright 2018, Central States Manufacturing, Inc., All Rights Reserved. D C GUID_PROD_MLOC_180201
More informationCentral Texas Metal Roofing Supply Co., Inc 36" NET COVERAGE SHEET WIDTH 38 ¼ 40 ¼ 38 ¼ 40 ¼ 38 ¼ 40 ¼ 40 ¼ 40 ¼
36" 1 2 " 6" GAUGE PANEL FINISH NET COVERAGE SHEET WIDTH WEIGHT PER SQ. 26 26 26 26 24 24 24 24 TEXAS RIB CHANNEL GUARD TEXAS RIB CHANNEL GUARD TEXAS RIB CHANNEL GUARD CHANNEL GUARD CHANNEL GUARD GALVALUME
More informationCentral Texas Metal Roofing Supply Co., Inc NET COVERAGE SHEET WIDTH
1 2 " 1 24" GAUGE PANEL FINISH NET COVERAGE SHEET WIDTH WEIGHT PER SQ. 26 5 Vee GALVALUME 24 26 3/8 95.00 PRICE PER SQ. PRICE PER LINEAR FOOT PANEL PRICING: 1. Price per Square is based on 26 3/8 sheet
More informationCentral Texas Metal Roofing Supply Co., Inc SHEET WIDTH 38 ¼ 40 ¼ 38 ¼ 40 ¼ 38 ¼ 40 ¼ 38 ¼ 40 ¼ 38 ¼ 40 ¼
GAUGE PANEL FINISH NET COVERAGE 26 26 26 26 U PBU U PBU GALVALUME GALVALUME SMP SMP (NOTE 1) SHEET WIDTH 38 ¼ 40 ¼ 38 ¼ 40 ¼ WEIGHT PER SQ. 95.00 95.00 95.00 95.00 24 24 24 24 24 24 U PBU U PBU U PBU GALVALUME
More information238T and 138T Panel and Accessories Price List 9/29/2017 (price good for shipments through 11/31/2017) Customer Job Date Sales Rep 238T PANEL ITEM #
238T and 138T Panel and Accessories Price List 9/29/2017 (price good for shipments through 11/31/2017) Customer Job Date Sales Rep 238T PANEL ITEM # DESCRIPTION SELLING PRICE UOM 238T 238T Seam Cap 24
More informationS BI COM P ON E NT CA T ALOG
SBI METAL BUILDINGS & COMPONENTS S BI COM P ON E NT CA T ALOG Date: 03 / 16 / 2017 COMMERCIAL PRODUCTS Commercial Panels and Trim Cee, Zee, Eave Struts, Angle, Channel, and Clips Accessories FT 0 1 2 3
More informationM-Loc. Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES D C E MLOCGUIDE COVERAGE
M-Loc Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES 13/ 6 36.00 COVERAGE D C E MLOCGUIDE150115 The men and women at Central States Manufacturing, Inc. would like to welcome
More informationTYPICAL ROOF CONDITION LAYOUT
FIXED POINTS TYPICAL ROOF CONDITION LAYOUT 15 17 9 16 29 12 14 11 3 7 35 20 6 23 30 31 24 13 18 Typical Roof Condition Layout... 1 Low Eave Isometric View - Fixed/ Floating... 2 Low Eave Section - Fixed/
More informationHorizon-Loc. Concealed Fastener Application Guide. Jasper, Alabama Lowell, Arkansas Cedar Hill, Texas
Horizon-Loc TM Concealed Fastener Application Guide Lowell, Arkansas 800-356-2733 Michigan City, Indiana 800-638-2565 Cedar Hill, Texas 800-210-8305 Jasper, Alabama 866-270-6608 www.centralstatesmfg.com
More informationTRIAD CORRUGATED METAL, INC.
TRIAD CORRUGATED METAL, INC. COMMERCIAL RESIDENTIAL AGRICULTURAL MS-216 MS-218 Panel Guide This guide describes the design and performance characteristics of the MS-216 and MS-218 Roof panel system. The
More informationSIDEWALL/ENDWALL STANDING SEAM TRIMS SIDEWALL/ENDWALL CROSS SECTION NTS SIDING OR OTHER WALL CLADDING, TYP LOW PROFILE FASTENER, TYP
CHIMNEY FLASHING CROSS SECTION 1. CHIMNEY FLASHING TRIM IS DESIGNED TO FLASH AROUND CHIMNEYS AND LARGE PENETRATIONS (E.G. SKYLIGHTS). CH1 AND CH7 ARE INTENDED FOR USE WITH MOST EXPOSED FASTENER AND STANDING
More information1.5 mechanical lock ml 150
1.5 mechanical lock ml 150 Strip Width Base Material Thickness Min Tensible Min Yield Coatings Max 16 Steel.0225 to.0336 in 52 - ksi 50 - ski Painted / Galvalume UL CONSTRUCTION NUMBERS: TGKX554 The Mechanical
More informationPIPE. Central Texas Largest Distributor. Structural Steel, Pipe and Metal Building Components
Central Texas Largest Distributor Structural Steel, Pipe and Metal Building Components PIPE Waco Location P.O. Box 154485 913 South Loop Dr. Waco Texas 76705 Local - 254-754-2611 Bryan Location 9401 E.
More informationCorrugated Trim Pamphlet.indd 1
Corrugated Trim Pamphlet.indd 1 5/9/12 4:36 PM FL ATi RON STEEL FLASHING DETAILS 21/2 CORRUGATED 1/2 All specifications are designed to be used with 21/2 Corrugated panels only. MATERIAL SPECIFICATIONS
More informationIMPORTANT NOTICE READ THIS MANUAL COMPLETELY PRIOR TO BEGINNING THE INSTALLATION OF THE WEATHER GUARD PANEL.
IMPORTANT NOTICE READ THIS MANUAL COMPLETELY PRIOR TO BEGINNING THE INSTALLATION OF THE WEATHER GUARD PANEL. IF THERE IS A CONFLICT BETWEEN PROJECT ERECTION DRAWINGS PROVIDED OR APPROVED BY WHIRLWIND BUILDING
More informationClassic Rib Roofing Panels DETAIL MANUAL
Metal Roofing Wholesalers Classic Rib Roofing Panels DETAIL MANUAL www.metalroofingwholesalers.com 1170 Topside Rd Louisville, TN 37777 The Classic Rib Roofing Panel Figure 1 House With Classic Rib Metal
More informationDrexel Metals Inc. DMC 5V 26 Gauge min. Face-Fastening Metal Roof System over Plywood
Drexel Metals Inc. DMC 5V 26 Gauge min. Face-Fastening Metal Roof System over Plywood Section 07411 Metal Roof Panels Part 1 General 1.1 Summary A. This section includes the following: a. Factory-formed
More informationRESIDENTIAL LIGHT GAUGE APPLICATION GUIDE
Our Name Says It All RESIDENTIAL LIGHT GAUGE APPLICATION GUIDE Lebanon, PA 888.339.0059 Bridgton, ME 800.677.2060 Howe, IN 866.562.3782 www.everlastroofing.com Residential Light Gauge Table of Contents
More information1.5 mechanical lock ml 150
1.5 mechanical lock ml 150 Strip Width Base Material Thickness Min Tensible Min Yield Coatings Max 16 Steel.0225 to.0336 in 52 - ksi 50 - ski Painted / Galvalume UL CONSTRUCTION NUMBERS: TGKX554 The Mechanical
More informationSHURLOC 150 STANDARD DETAILS
OVER WOOD DECK STANDARD DETAILS Austin - Headquarters/Sales Office 830 Sagebrush Drive Austin, TX 78758 (512) 452-1515 (800) 428-7412 Fax (512) 833-7499 www.ctmrs.com email: info@ctmrs.com Seguin - Plant/Sales
More information1.5 snap lock sl 150
1.5 snap lock sl 150 Strip Width Base Material Thickness Min Tensible Min Yield Coatings 12.00 to 24 Steel.0128 to.027 in 52 - ksi 50 - ski Painted / Galvalume UL CONSTRUCTION NUMBERS: TGKX301, tgkx342a,
More informationSECTION METAL ROOF AND SOFFIT PANELS
Metal Panel Systems, Inc. 11506 Reading Road Cincinnati, Ohio 45241-2512 Telephone: 800-554-6126 or 513-554-6120 Fax: 513-554-6121 www.metalpanelsystems.com info@metalpanelsystems.com Specifications for
More informationPROLOK EAVE PROLOK ROOFING PANEL ROOFING NAIL
EAVE ROOFING NOTE: ROOF PITCH IS REQUIRED FOR FABRICATION LOW SLOPE ADD SEALER TAPE ROOFING NAIL 2x4 SUB- 2x8 EAVE TRIM 1. Install the eave trim using roofing nails. 2. If sealer tape is being used, install
More information1 Exam Prep Architectural Sheet Metal Manual Tabs and Highlights
1 Exam Prep Architectural Sheet Metal Manual Tabs and Highlights These 1 Exam Prep tabs are based on the 2012 Sheet Metal and Air Conditioning Contractors' National Association, Inc., seventh edition.
More informationMcElroy Metal, Inc. MAX-RIB MATRIX
McElroy Metal, Inc. MATRIX McElroy Content CONTENTS Max-Rib General Information P-1 Max-Rib Panel Pricing P-2 Matrix Panel General Information P-3 Matrix Custom Trim and Accessories P-4 Max-Rib Post Frame
More informationTable of Contents. Notes to Designer/User Map of Typical Roof Conditions...3 Fastener Placement...4 Fastener Selection...5
Table of Contents Section Page Notes to Designer/User...................1-2 Map of Typical Roof Conditions..............3 Fastener Placement........................4 Fastener Selection.........................5
More information2120 SW Poma Drive; Palm City, Florida Phone Fax
2120 SW Poma Drive; Palm City, Florida 34990 772-223-4055 Phone 772-781-7492 Fax www.sunlastmetal.com sales@sunlastmetal.com IMPORTANT NOTICE READ THIS MANUAL COMPLETELY BEFORE BEGINNING INSTALLATION OF
More informationSIDEWALL/ENDWALL EXPOSED FASTENER TRIMS. Details master.dwg 2/15/2017 GULF COAST SUPPLY & MFG., LLC
CHIMNEY FLASHING CROSS SECTION 1. CHIMNEY FLASHING TRIM IS INTENDED TO FLASH AROUND CHIMNEYS AND LARGE PENETRATIONS. OTHER USE MAY BE ACCEPTABLE IF DESIGNER DETERMINES FITNESS OF USE. 3. LARGE PENETRATIONS
More informationLight-Metal Roof Edge, Raised
NAIL WOOD CANT TO BLOCKING 2 ROWS STAGGERED EACH ROW 24 O.C. 1/2 MIN. 10 0 MAX. FASTEN 18 O.C. WITH NEOPRENE GASKETED FASTENERS 3-1/2 MIN. 4 6 JOINT COVER PLATE SET IN TWO BEADS OF SEALANT 4 MIN. SPECIFIED
More information1 1/2" SSR. FABRAL The pursuit of excellence since 1967
1 1/2" SSR Detail Manual and Estimate Guide 16" 1 1 2" PROPER STORAGE When moisture remains in contact with Galvanized panels in the absence of freely circulating air, white, black or dark gray corrosion
More information4572 N Old US 31, Rochester, IN Toll Free: Fax: DETAIL MANUAL. and guide to Ramco Supply products
DETAIL MANUAL and guide to Ramco Supply products Metal Roofing and Siding Panels & Accessories 1 Ramco Supply s RAM Roofing Panels Ramco Supply s RAM panels are a strong, durable, economic, and attractive
More informationCentral Snap. Product Guide. 16" or 18" COVERAGE 1¾" HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES
Central Snap Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES 1¾" 16" or 18" COVERAGE Copyright 2018, Central States Manufacturing, Inc., All Rights Reserved. D C GUID_PROD_CENTRALSNAP_180201.1
More informationWESTERN RIB. Installation, Flashings & Shop Drawing Detail Guide.
WESTERN RIB Installation, Flashings & Shop Drawing Detail Guide 901 W. Watkins Street Phoenix, AZ 85007 Phone: (877) 787-5467 (855) 426-7836 Email: sales@cortenroofing.com sales@metalforroofing.com For
More informationFor Metal Roofing Systems Fascia, Mansards,& Soffits
HIGGINS STEEL ROOFING SERIES 2000 STANDING SEAM DETAIL MANUAL For Metal Roofing Systems Fascia, Mansards,& Soffits Wall Panels/Siding HIGGINS CONSTRUCTION & SUPPLY CO. 3801 U. S. 50 HILLSBORO, OHIO 45133
More informationFABRAL The pursuit of excellence since 1967
1 1/2" SSR Detail Manual and Estimate Guide 16" 1 1 2 " PROPER STORAGE When moisture remains in contact with Galvanized panels in the absence of freely circulating air, white, black, or gray corrosion
More informationIMAGE II. Panel Information. Detail Conditions. Flashing Profiles. Accessory Profiles. Testing Information. Design/Installation Considerations PIM-1
Table of ontents Product Page No. Product Page No. Panel Information Profiles... PIM-2 Panel Overview...PIM-2 Flashing Profiles Eave...PIM-3 Extended Eave...PIM-3 leat...pim-3 Offset leat...pim-3 5K Gutter...PIM-3
More informationCONTOUR CORRUGATED PANEL
CONTOUR CORRUGATED PANEL Table of Contents SECTION PAGE Designer Notes............................................... 1 Panel Net Coverage / Fasteners.................................... 2 ROOF Details
More informationCR# August 20, 2015
SECTION 07 40 00 - METAL ROOF AND WALL PANELS PART 1 - GENERAL 1.1 SUMMARY A. Section includes: 1. Factory-formed and field-assembled, standing-seam metal roof panels. 2. Factory-formed and field-assembled,
More informationR PANEL / PBR PANEL. Installation, Flashings & Shop Drawing Detail Guide.
R PANEL / PBR PANEL Installation, Flashings & Shop Drawing Detail Guide 901 W. Watkins Street Phoenix, AZ 85007 Phone: (877) 787-5467 (855) 426-7836 Email: sales@cortenroofing.com sales@metalforroofing.com
More informationEVERSEAM 20 APPLICATION GUIDE
EVERSEAM 20 APPLICATION GUIDE Panel Overview Our Name Says It All!"#$%#&'()*+,!"#$%#&'(-.( Applications: The EverSeam panel is an architectural panel that is ideal for residential and light commercial
More informationSTILE. Panel Information. Design/Installation Considerations. Flashing Profiles. Detail Conditions. Notes. Accessory Profiles. Testing Information
Table of ontents Product Page No. Product Page No. Panel Information Profile...PST-2 Panel Overview...PST-2 Flashing Profiles Eave...PST- Extended Eave...PST- leat...pst- Stile Starter...PST- Box Gutter...PST-
More information2120 SW Poma Drive; Palm City, Florida Phone Fax
2120 SW Poma Drive; Palm City, Florida 34990 772-223-4055 Phone 772-781-7492 Fax www.sunlastmetal.com sales@sunlastmetal.com IMPORTANT NOTICE READ THIS MANUAL COMPLETELY BEFORE BEGINNING INSTALLATION OF
More informationSTONE COATED METAL ROOF SHINGLE
GUIDE SPECIFICATION Manufacturer: A Fletcher Building Company 1230 Railroad Street Corona, CA 92882 951-272-8180 phone 951-272-4476 facsimile www.decra.com SECTION 07313 [07 31 13] STONE COATED METAL ROOF
More informationSapphire Metal Tile Roofing System
Sapphire Metal Tile Roofing System Sapphire Metal Tile Roofing Benefits of Sapphire Metal Tile - Beauty and function - Tile Beauty, Steel Strength, Lasts a lifetime - Excellent long term investment - Pays
More informationWestern States 7/8 Corrugated
Western States 7/8 Corrugated Installation, Flashings & Shop Drawing Detail Guide Table of Contents Section Page Section Page Notes to Designer / Installers..1 Fastener Placement and Selection.2-3 Key
More informationInstallation Guide. Mission Tile. Distributed by: BEST MATERIALS LLC, Phoenx AZ
RPM ROOFING Installation Guide Mission Tile Distributed by: BEST MATERIALS LLC, Phoenx AZ 602-272-8128 800-474-7570 www.bestmaterials.com Table of Contents OVERVIEW...1 CAUTION...1 DISCLAIMER...1 PRODUCT
More information5V Crimp DESIGN/INSTALLATION INFORMATION
5V Crimp DESIGN/INSTALLATION INFORMATION IMPORTANT NOTICE READ THIS MANUAL COMPLETELY PRIOR TO BEGINNING THE INSTALLATION OF THE SYSTEM. METAL DEPOTS DETAILS MUST BE FOLLOWED AS A MINIMUM TO INSURE APPROPRIATE
More informationNUCOR VR 16 II STANDING SEAM ROOF SYSTEM TABLE OF CONTENTS
NUCOR VR 16 II STANDING SEAM ROOF SYSTEM TABLE OF CONTENTS Nucor VR16 II Vertical Rib Standing Seam Roof System...2 Nucor VR16 II Property and Span Tables...3 Standard Details...5 ED3010PE - Gutter...5
More informationw w w. s a q u l i t y m e ta l s. c o m
san antonio branch 210 W. Peden San Antonio TX 78204 P. (210) 227-7276 F. (210) 227-0329 MCALLEN branch 2221 Austin Ave McAllen TX 78501 P. (956) 627-2966 F. (956) 627-0918 w w w. s a q u l i t y m e ta
More informationBARREL VAULT Tile Counter Batten and Batten Installation Guide
BARREL VAULT Tile Counter Batten and Batten Installation Guide www.boral.com Page2 BARREL VAULT Tile Actual Size= 43 13/16 x 15 5/8 Exposure= 43 1/4 x 14 Weight= 5.4lbs. per panel Panels per square (100
More information5V and CORRUGATED Accessory Detail Manual
5V and CORRUGATED Accessory Detail Manual NOA # 06-0921.07 Miami Dade Approved - 5V Only Site Specific Engineering Required Thompson Architectural Metal Roofing is proud to be a partner of the Energy Star
More information1 1/2" SSR. FABRAL The pursuit of excellence since 1967
1 1/2" SSR Detail Manual and Estimate Guide 16" 1 1 2" PROPER STORAGE When moisture remains in contact with Galvanized panels in the absence of freely circulating air, white, black or dark gray corrosion
More informationDREXEL METALS CLIPS AND ACCESSORIES SIMPLIFYING METAL ROOFING SYSTEMS ARCHITECTURAL COMMERCIAL RESTORATION/CUSTOM
DREXEL METALS CLIPS AND ACCESSORIES SIMPLIFYING METAL ROOFING SYSTEMS Your machine makes one component of the total metal roof system. Drexel Metals has invested millions of dollars to ensure our metal
More informationDAN S CUSTOM SHEETMETAL Manufacturer and Distributor
About the Company DAN S CUSTOM SHEETMETAL Manufacturer and Distributor In 1993, DCSM was the first manufacture in the state of Florida to fabricate metal eave closure for tile. We have established a reputation
More informationUnion County Vocational - Technical Schools Scotch Plains, New Jersey
SECTION 074213 - INSULATED METAL WALL PANELS PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01 Specification
More informationSSL-175. Specifications
SSL-175 Specifications Everlast Metals 10 Enterprise Court Lebanon, PA 17042 Phone: (717) 270-6554 Fax: (717) 270-6569 www.everlastmetals.com 7410 Preformed Metal Roofing PART 1: GENERAL 1.01 SECTION INCLUDES
More informationFlat. Ribbed Striated and 1 ½ TCM-Lok Installation Manual
Flat Ribbed.748.941.472 15.75 1.248 Striated.748.472 14.75 1.5.248.941 www.tricountymetals.com 1 and 1 ½ TCM-Lok Installation Manual Table of Contents Important Notice/Safety/Storage/Tools...1 Roofing
More informationCentral Seam Plus. Central-Loc
Central Seam Plus Central-Loc Product Guide HELPFUL INFORMATION ON PANELS, TRIMS, GUTTERS AND ACCESSORIES 3" 3" " or 18" COVERAGE " or 18" COVERAGE Central Seam Plus Field seamed Central-Loc Snaps together
More informationMAXIMA. Maxima Testing Data, Section Properties, and Load Tables
MAXIMA Maxima Maxima Testing Data, Section Properties, and Load Tables For any available Testing Data, Section Properties, or Load Tables, please visit www.mcelroymetal.com. For additional information,
More informationInstallation Guide MATTERHORN METAL ROOFING TO LAST A LIFETIME. MATTERHORN Tile
Installation Guide MATTERHORN METAL ROOFING TO LAST A LIFETIME MATTERHORN Tile Watch detailed installation videos online at matterhornmetalroofing.com/tile-installation Table of Contents Accessories: Most
More informationDL-200. Specifications
DL-200 Specifications Everlast Metals 10 Enterprise Court Lebanon, PA 17042 Phone: (717) 270-6554 Fax: (717) 270-6569 www.everlastmetals.com 7410 Structural Preformed Metal Roofing PART 1: GENERAL 1.01
More information7/8 Corrugated. Corrugated Trim Pamphlet.indd 1
7/8 Corrugated Corrugated Trim Pamphlet.indd 1 5/9/12 4:36 PM FL ATiRON STEEL F L A S H I N G D E TA I L S 7/8 CO R R U G AT E D PANEL PROFILE 40 Wide Panel Wall Coverage Roof Coverage 7/8 Anti Siphon
More informationPacific Tile Counter Batten and Batten
Pacific Tile Counter Batten and Batten INSTALLATION GUIDE www.gerardusa.com INSTALLATION NOTIFICATION The installation procedures demonstrated in this manual are recommended methods for the installation
More informationPacific Tile Counter Batten and Batten
Pacific Tile Counter Batten and Batten INSTALLATION GUIDE www.gerardusa.com Page2 INSTALLATION NOTIFICATION The installation procedures demonstrated in this manual are recommended methods for the installation
More informationSL-16. Design/Installation Information
SL-16 Design/Installation Information IMPORTANT NOTICE READ THIS MANUAL COMPLETELY PRIOR TO BEGINNING THE INSTALLATION OF THE SL Series ROOFING SYSTEM. ALWAYS INSPECT EACH AND EVERY PANEL AND ALL ACCESSORIES
More informationClassic and NB Tile Counter Batten and Batten
Classic and NB Tile Counter Batten and Batten INSTALLATION GUIDE www.gerardusa.com INSTALLATION NOTIFICATION The installation procedures demonstrated in this manual are recommended methods for the installation
More informationALLMET CONTINENTAL INSTALLATION GUIDE
ALLMET CONTINENTAL INSTALLATION GUIDE www.allmet.com INSTALLATION NOTIFICATION The installation procedures demonstrated in this manual are recommended methods for the installation of the Allmet Continental
More informationDRAWING INDEX Description
DRAWING INDEX Qty. Description TOOL LIST PAGE #1 PANEL & PANEL RACK HANDLING TIPS 2 BASIC BUILDING COMPONENTS 3 ELEVATIONS 4 MATERIALS LIST 5 BUILDING LAYFLAT 6 FOUNDATION PREPARATION PLAN VIEW 7 BASE
More informationENERGY STAR PARTNER. PBR & R Panel
ENERGY STAR PARTNER 1 Table of Contents Important Information Installation Information Technical Information Trims and Flashings Illustration Roo ng Installation Details Eave Flashing (EF-3) Eave Flashing
More informationAgricultural Pricing Guide
Guide TABLE OF CONTENTS Panels Rain Guard Perma-Clad, WeatherSafe and Stormproof Stormproof with Drip Stop Corrugated 2 4 6 7 Accessories Flat Sheets Coils Roof Jacks Ventilators Light Transmitting Panels
More informationSNAP-LOK 1 1/2 Installation Manual
Flat Ribbed.709.394.197 15.5.248 1.417 1.496 Striated www.tricountymetals.com SNAP-LOK 1 1/2 Installation Manual Table of Contents Important Notice/Safety/Storage/Tools...1 Roofing Anatomy/Side Trim...2
More informationSECTION STEEL BUILDING SYSTEMS
PART 1 - GENERAL 1.01 SECTION INCLUDES: SECTION 13120 - STEEL BUILDING SYSTEMS A. Pre-engineered building and components including the following: 1. Structural steel frame. 2. Roof covering system including
More informationINSTALLATION GUIDE.
INSTALLATION GUIDE www.gerardusa.com INSTALLATION NOTIFICATION The installation procedures demonstrated in this manual are recommended methods for the installation of the Gerard Canyon Shake counter batten
More informationSheet Metal Flashing and Trim
University of New Hampshire University of New Hampshire Scholars' Repository Division 07 Thermal and Moisture Protection Chapter 5 Technical Construction and Renovation Standards 1-25-2013 076200 - Sheet
More informationa division of NCI Standing Seam Roof Systems
a division of NCI Standing Seam Roof Systems Building Benefits You Can Expect From A&S Materials Standing Seam roof panels weigh a relatively modest 11/2 pounds per square foot. When long life is required
More informationMS-100 MS-150. MS SERIES Flashing and Details Guide. MS150 Flashing and Details Guide. MS200 Flashings and Details Guide
Taylor Metal Products - Phone: 503-581-8338 or 800-574-1388 - Fax: 503-581-6877 - www.taylormetal.com MS200 Flashings and Details Guide MS150 MS SERIES MS-100 MS-150 MS-100 MECHANICALLY SEAMED The MS-100
More informationDETAIL MANUAL A COMPREHENSIVE GUIDE TO METAL ROOFING GULFLOKTM HIDDEN SCREW METAL ROOF SYSTEM
DETAIL MANUAL A COMPREHENSIVE GUIDE TO METAL ROOFING GULFLOKTM HIDDEN SCREW METAL ROOF SYSTEM Gulf Coast Standing Seam Roofing Panels Since 2004, Gulf Coast Supply and Manufacturing has been happy to offer
More informationTable of Contents. 3. Standing Seam Panels
Table of Contents 895 North Parkway 3. Standing Seam Panels Standing Seam Panels Table of Contents... PS1-2 Double-Lok... PS3-8 Ultra-Dek... PS9-14 BattenLok HS... PS15-18 Curved BattenLok HS... PS19-20
More informationArchitectural Wall Products Guide Specifications
Western States Metal Roofing 901 W. Watkins St. Phoenix, AZ 85007 PH: 602-495-0048 FX: 602-261-7726 Architectural Wall Products Guide Specifications FORMED METAL WALL PANELS This Guide Specification is
More informationSECTION STANDING-SEAM METAL ROOF PANEL
SECTION 074113 -STANDING-SEAM METAL ROOF PANEL PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01
More informationw w w. s a q u l i t y m e ta l s. c o m
san antonio branch 210 W. Peden San Antonio TX 78204 P. (210) 227-7276 F. (210) 227-0329 MCALLEN branch 2221 Austin Ave McAllen TX 78501 P. (956) 627-2966 F. (956) 627-0918 w w w. s a q u l i t y m e ta
More informationBrava Spanish Tile. Installation Manual. Brava Roof Tile Phone: Fax:
Brava Spanish Tile Installation Manual Brava Roof Tile Phone: 319-338-5706 Fax: 319-343-1038 www.bravarooftile.com This document includes the recommended and suggested installation procedures for Brava
More informationCentral Snap. Condition Details C SNAPDETAILS
Central Snap Condition Details D C SNAPDETAILS150612.2 The men and women at Central States Manufacturing, Inc. would like to welcome you. OUR MISSION Central States Manufacturing, Inc. is a 100% employee-owned
More informationEngineering Services Program
Product Evaluation Engineering Services Program The following product has been evaluated for compliance with the wind loads specified in the International Residential Code (IRC) and the International Building
More informationTABLE OF CONTENTS IMAGE II. Detail Conditions. Panel Information. Flashing Profiles
TABLE OF ONTENTS Product Page No. Product Page No. Panel Information Profi les...pim-2 Panel Overview...PIM-2 Flashing Profiles Eave...PIM-3 Extended Eave...PIM-3 leat...pim-3 Offset leat...pim-3 5K Gutter...PIM-3
More informationArchitectural Roof Products Guide Specifications
Western States Metal Roofing 901 W. Watkins St. Phoenix, AZ 85007 PH: 602-495-0048 FX: 602-261-7726 Architectural Roof Products Guide Specifications FORMED METAL ROOF AND WALL PANELS This Guide Specification
More informationDREXEL METALS CLIPS AND ACCESSORIES SIMPLIFYING METAL ROOFING SYSTEMS ARCHITECTURAL COMMERCIAL RESTORATION/CUSTOM
DREXEL METALS CLIPS AND ACCESSORIES SIMPLIFYING METAL ROOFING SYSTEMS Your machine makes one component of the total metal roof system. Drexel Metals has invested millions of dollars to ensure our metal
More informationCS-100 Guide Specifications
MANUFACTURER CUSTOM-BILT METALS 1333 Corporate Drive, Suite 103 Irving, Texas 75038-2520 (800) 826-7813 or info@custombiltmetals.com www.custombiltmetals.com CS-100 Guide Specifications This Guide Specification
More informationArchitectural Roof Products Guide Specifications
Western States Metal Roofing 901 W. Watkins St. Phoenix, AZ 85007 PH: 602-495-0048 FX: 602-261-7726 Architectural Roof Products Guide Specifications FORMED METAL ROOF AND WALL PANELS This Guide Specification
More informationTREMLOCK SL INSTALLATION MANUAL
TREMLOCK SL INSTALLATION MANUAL TREMLOCK SL TremLock SL i a concealed fatener architectural tanding eam roof panel. The TremLock SL panel are eaily intalled over decking, utilizing metal clip. TremLock
More information