MATERIAL SAFETY DATA SHEET FOR BOSS FOOD SAFE LUBRICANT

Transcription

1 MATERIAL SAFETY DATA SHEET FOR BOSS FOOD SAFE LUBRICANT IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY Product type: Intended use: Trade Name: Supplier of product: Food safe lubricant (Non-Mineral Oil) For general lubrication in all food processing areas, e.g. chains, overhead tracks, oven components, tools, knives and saws. BOSS Food Safe Lubricant The BSS Group Ltd Registered Office: Travis Perkins PLC, Lodge Way House, Lodge Way, Harlestone Road, Northampton NN5 7UG. Telephone/Fax Numbers: / Address Web site Address 2. HAZARD IDENTIFICATION Classification of the substance or mixture Directive 67/548/EEC & Directive 1999/45/EC: Label elements: Product Name: Hazard Symbol: reception@bssgroup.com F+; Extremely flammable According to Directive 67/548/EEC & Directive 1999/45/EC FSL GOLD Food Safe Lubricant. Risk Phrases: Safety Phrases: Additional Information: Other Hazards High concentrations: Additional Information: F+ R12: Extremely flammable. S2: Keep out of the reach of children. S23: Do not breathe vapour/spray. Pressurized container: protect from sunlight and do not expose to temperatures exceeding 50 C. Keep away from sources of ignition - No smoking. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material Vapours may cause drowsiness and dizziness. May cause eye irritation. None. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 1 of 7

2 3. COMPOSITION/INFORMATION ON INGREDIENTS Product as Supplied: Aerosol. Mixtures EC Classification No. 67/548/EEC Hazardous %W/W CAS No. EC No. REACH EC Classification ingredient(s) Registration No. and Risk Phrases Butane None assigned F+; R12 Isobutane Propane None assigned None assigned F+; R12 F+; R12 Additional Information For full text of R phrases see section FIRST AID MEASURES Description of first aid measures Inhalation: Eye Contact: Skin Contact: Ingestion: Most important symptoms and effects, both acute and delayed: Indication of any immediate medical attention and special treatment needed: 5. FIRE FIGHTING MEASURES Move person to fresh air. If symptoms persist, obtain medical attention. Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while lifting the eyelids. Continue to rinse for at least 10 minutes. Get medical attention if any discomfort continues. Wash skin with soap and water. If symptoms persist, obtain medical attention. Unlikely route of exposure. Unlikely to be required but if necessary treat symptomatically No special requirements. Extinguishing Media Extinguishing Media: Unsuitable Extinguishing Media: Special hazards arising from the substance or mixture: Advice for fire-fighters: Extinguish with carbon dioxide, dry chemical, foam or waterspray. Water jet spray. Heating may cause pressure rise with risk of bursting. May give off toxic fumes in a fire. Fire fighters should wear complete protective clothing including self-contained breathing apparatus. Keep fire exposed containers cool by spraying with water. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 2 of 7

3 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures: Environmental precautions: Methods and material for containment and cleaning up: Reference to other sections: See Also Section 7, 8, HANDLING AND STORAGE: Eliminate sources of ignition. Ensure adequate ventilation. Do not breathe vapour/spray. Caution - spillages may be slippery. Do not allow to enter drains, sewers or watercourses. Place leaking cans in a bucket or pail to minimise product contamination of surfaces. Leaked product will render floors very slippery. Adsorb spillages onto sand, earth or any suitable adsorbent material. Precautions for safe handling: Conditions for safe storage, including any incompatibilities: Storage Temperature: Storage Life: Incompatible materials: Specific end use(s): The vapour is heavier than air and spreads along ground. May form explosive mixture with air particularly in enclosed spaces. Ensure adequate ventilation. Keep away from sources of ignition - No smoking. Do not pierce or burn, even after use. Do not breathe vapour/spray. Keep out of reach of children. Do not eat, drink or smoke when using this product. Protect from sunlight. Store in dry place. Keep in a well ventilated place. Do not expose to temperatures exceeding 50 C/ 122 F. Strong oxidising agents, Strongly alkaline, Strongly acidic. For general lubrication in all food processing areas, e.g. chains, overhead tracks, oven components, tools, knives and saws. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Control Parameters Occupational Exposure Limits SUBSTANCE CAS No. LTEL (8 hr TWA ppm) LTEL (8 hr TWA mg/m³) STEL (ppm) STEL (mg/m³) Butane WEL WEL: Workplace Exposure Limit (UK HSE EH40) Note Biological limit value: PNECs and DNELs: Exposure controls Appropriate engineering controls: Not established Not established Provide adequate ventilation. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 3 of 7

4 8. EXPOSURE CONTROLS/PERSONAL PROTECTION (cont) Personal protection equipment Eye Protection: Skin Protection: Not normally required. Handling of larger amounts: Wear eye protection with side protection (EN166). Not normally required. Wear suitable gloves if prolonged skin contact is likely. Thermal hazards Respiratory Protection: Environmental Exposure Controls: No personal respiratory protective equipment normally required. Wear a suitable respirator if the ventilation is not sufficient to keep the solvent vapour concentration below the occupational limit values. Not applicable. Do not allow to enter drains, sewers or watercourses. 9. PHYSICAL AND CHEMICAL PROPERTIES Information on basic physical and chemical properties Appearance: Aerosol. Colour: Coloured liquid. Odour: Odourless. Odour Threshold: Ph: Melting Point/Freezing Point: Initial boiling point and boiling range: Flash point: Evaporation rate: Flammability (solid, gas): Extremely flammable. Upper/lower flammability or C explosive limits: Vapour pressure: Vapour density: Relative density: Solubility(ies): Insoluble in water. Soluble in: Aliphatic hydrocarbons. Partition coefficient: n- octanol/water: Auto-ignition temperature: 300 C (bulk product before aerosol packing). Decomposition Temperature: Viscosity: Explosive properties: Contains gas under pressure; may explode if heated. Oxidising properties: Not oxidising. Other information Can Pressure: 2.41bar BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 4 of 7

5 10. STABILITY AND REACTIVITY Reactivity Chemical stability: Possibility of hazardous reactions: Conditions to avoid: Incompatible materials: Hazardous Decomposition Product(s): Keep away from heat/sparks/open flames/hot surfaces. No smoking. Strong oxidising agents, Strongly alkaline, Strongly acidic. None known. 11. TOXICOLOGICAL INFORMATION Information on toxicological effects Mixtures Acute toxicity Ingestion: Low oral toxicity. Inhalation: High concentrations: Vapours may cause drowsiness and dizziness. Irritation: May cause eye irritation. Corrosivity: Not classified. Sensitisation: It is not a skin sensitiser. Repeated dose toxicity: None anticipated. Carcinogenicity: No evidence of carcinogenicity. Mutagenicity: There is no evidence of mutagenic potential. Toxicity for reproduction: None anticipated. Other information: None. 12. ECOLOGICAL INFORMATION Toxicity: Persistence and degradability: Bioaccumulative potential: Mobility in soil: Results of PBT and vpvb assessment: Other adverse effects: Low toxicity to aquatic organisms. The product is readily biodegradable. No information available. Insoluble in water. Not classified as PBT or vpvb. None. 13. DISPOSAL CONSIDERATIONS Waste treatment methods: Additional Information: Recycle only completely emptied packaging. Containers must not be punctured or destroyed by burning, even when empty. Non-emptied aerosol: Dispose of wastes in an approved waste disposal facility. Disposal should be in accordance with local, state or national legislation. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 5 of 7

6 14. TRANSPORT INFORMATION UN number: UN 1950 UN proper shipping name: AEROSOLS. Transport hazard class(es): 2 Packing Group: II Environmental hazards: Not classified as a Marine Pollutant. Special precautions for None. user: Transport in bulk Not applicable. according to Annex II of MARPOL73/78 and the IBC Code: Additional Information IMDG: 9022 Limited Quantity (LQ): Limited Quantity provisions apply. 15. REGULATORY INFORMATION Safety, health and environmental regulations/legislation specific for the substance or mixture EU regulations Authorisations and/or restrictions on use Candidate List of Substances of Very High All chemicals are not listed. Concern for Authorisation: REACH: ANNEX XIV LIST OF SUBSTANCES SUBJECT All chemicals are not listed. TO AUTHORISATION: REACH: ANNEX XVII RESTRICTIONS ON THE All chemicals are not listed. MANUFACTURE, PLACING ON THE MARKET AND USE OF CERTAIN DANGEROUS SUBSTANCES, PREPARATIONS AND ARTICLES: Community Rolling Action Plan (CoRAP): Other EU regulations: National regulations: Chemical Safety Assessment: 16. OTHER INFORMATION The following sections contain revisions or new statements: LEGEND LTEL STEL DNEL PNEC PBT VPvB Long Term Exposure Limit Short Term Exposure Limit Derived No Effect Level Predicted No Effect Concentration Persistent, Bioaccumulative and Toxic very Persistent and very Bioaccumulative F+ Extremely flammable Risk Phrases R12 Extremely flammable. All chemicals are not listed. COSHH - Control of Substances Hazardous to Health CHIP - Chemicals (Hazard Information and Packaging) Regulations None known. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 6 of 7

7 16. OTHER INFORMATION (cont) DISCLAIMER This information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process. Such information is, to the best of the company s knowledge and belief, accurate and reliable as of the date indicated. However, the user s responsibility to satisfy himself as to the suitability of such information for his own particular use. BOSS MSDS 016 REVIEWED: 04/03/2013 Page: 7 of 7