: Musket DEF. SECTION 1: Identification of the substance/mixture and of the company/undertaking. SECTION 2: Hazards identification

Transcription

1 Date of issue: 07/13/2015 Version: 1.0 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product form Trade name : Mixture : Musket DEF 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture 1.3. Details of the supplier of the safety data sheet Manufacturer/Supplier: Musket Corporation 1111 Bagby Street, Suite 2400 Houston, Texas 77002, USA Phone: Emergency telephone number : Diesel Exhaust Fluid Emergency number : CHEMTREC: ; Outside the US/Canada SECTION 2: Hazards identification 2.1. Classification of the substance or mixture GHS-US classification Not classified 2.2. Label elements GHS-US labeling No labeling applicable 2.3. Other hazards other hazards which do not result in classification 2.4. Unknown acute toxicity (GHS-US) Not applicable : Exposure may aggravate those with pre-existing eye, skin, or respiratory conditions. SECTION 3: Composition/information on ingredients 3.1. Substance Not applicable 3.2. Mixture Name Product identifier % (w/w) GHS-US classification Water (CAS No) Not classified Urea (CAS No) Not classified Full text of H-statements: see section 16 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : When symptoms occur: go into open air and ventilate suspected area. Obtain medical attention if breathing difficulty persists. : Remove contaminated clothing. Drench affected area with water for at least 15 minutes. Discontinue use and obtain medical attention if irritation develops and persists. : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Obtain medical attention if pain, blinking or redness persists. : Rinse mouth. Do NOT induce vomiting. Obtain medical attention Most important symptoms and effects, both acute and delayed Symptoms/injuries : Not expected to present a significant hazard under anticipated conditions of normal use. Symptoms/injuries after inhalation Symptoms/injuries after skin contact : May cause mild skin irritation. 07/14/2015 EN (English) Page 1

2 Symptoms/injuries after eye contact Symptoms/injuries after ingestion : Ingestion of small amounts would not be expected to produce toxicity Indication of any immediate medical attention and special treatment needed Treat symptomatically. SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media Unsuitable extinguishing media 5.2. Special hazards arising from the substance or mixture Fire hazard Explosion hazard Reactivity 5.3. Advice for firefighters Firefighting instructions Protective equipment for firefighters SECTION 6: Accidental release measures : Use extinguishing media appropriate for surrounding fire. : Do not use a heavy water stream. Use of heavy stream of water may spread fire. : The product is not flammable. Hazardous combustion products. Carbon oxides (CO and CO2). Nitrogen oxides (NOx). Ammonia. : Product is not explosive. : Hazardous reactions will not occur under normal conditions Personal precautions, protective equipment and emergency procedures General measures : Exercise caution when fighting any chemical fire. Use water spray or fog for cooling exposed containers. : Do not enter fire area without proper protective equipment, including respiratory protection. : Avoid breathing dust, mist or spray. Avoid prolonged contact with eyes, skin and clothing For non-emergency personnel Protective equipment Emergency procedures : Personal protective equipment. For further information refer to section 8: Exposurecontrols/personal protection. : Evacuate unnecessary personnel For emergency responders Protective equipment Emergency procedures 6.2. Environmental precautions : Equip cleanup crew with proper protection. : Stop leak if safe to do so. Ventilate area. Prevent entry to sewers and public waters. Notify authorities if product enters sewers or public waters Methods and material for containment and cleaning up For containment Methods for cleaning up 6.4. Reference to other sections For further information refer to section 8 considerations". SECTION 7: Handling and storage 7.1. Precautions for safe handling Additional hazards when processed Hygiene measures 7.2. Conditions for safe storage, including any incompatibilities Technical measures Storage conditions Incompatible materials 7.3. Specific end use(s) Refer to section 1. : Contain any spills with dikes or absorbents to prevent migration and entry into sewers or streams. : Clear up spills immediately and dispose of waste safely. Absorb and/or contain spill with inert material (sand, vermiculite or other appropriate material), then place in suitable container. : Exposure-controls/personal protection. For disposal of residues refer to section 13: Disposal : When heated to decomposition, emits toxic fumes. : Handle in accordance with good industrial hygiene and safety practices. Wash hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work. : Comply with applicable regulations. : Store in a dry, cool and well-ventilated place. Keep container closed when not in use. Keep/Store away from extremely high or low temperatures, incompatible materials. : Strong acids. Strong bases. Strong oxidizers. Strong alkalis. 07/14/2015 EN (English) 2/6

3 SECTION 8: Exposure controls/personal protection 8.1. Control parameters 8.2. Exposure controls Appropriate engineering controls Personal protective equipment : Emergency eye wash fountains and safety showers should be available in the immediate vicinity of any potential exposure. Ensure adequate ventilation, especially in confined areas. Ensure all national/local regulations are observed. : In case of splash hazard: safety glasses. Materials for protective clothing Hand protection Eye protection Skin and body protection Respiratory protection Other information : Not applicable. : Wear chemically resistant protective gloves. : In case of splash hazard: chemical goggles or safety glasses. : Wear suitable protective clothing. : If exposure limits are exceeded or irritation is experienced, approved respiratory protection should be worn. : When using, do not eat, drink or smoke. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Liquid Appearance : Clear, colorless liquid. Color : Colorless Odor : Faint odor of ammonia Odor threshold ph : Melting point Freezing point : -12 C (11 F) Boiling point : 104 C (219 F) Flash point Relative evaporation rate (butyl acetate=1) Flammability (solid, gas) Explosive limits Explosive properties Oxidizing properties Vapor pressure Relative density Relative vapor density at 20 C Specific gravity / density : lbs./usg kg / 20 C (68 F) Specific Gravity : C (68 F) Solubility : 100% Log Pow Log Kow Auto-ignition temperature Decomposition temperature Viscosity Viscosity, kinematic Viscosity, dynamic 9.2. Other information 07/14/2015 EN (English) 3/6

4 SECTION 10: Stability and reactivity Reactivity Hazardous reactions will not occur under normal conditions Chemical stability Stable under normal conditions Possibility of hazardous reactions Hazardous polymerization does not occur Conditions to avoid Extremely high or low temperatures. Incompatible materials Incompatible materials Strong acids. Strong bases. Strong oxidizers. Strong alkalis Hazardous decomposition products Carbon oxides (CO, CO2). Nitrogen oxides (NOx). Ammonia. SECTION 11: Toxicological information Information on toxicological effects Likely routes of exposure Acute toxicity : Ingestion; Inhalation; Skin and eye contact LD50 oral rat LD50 oral rat LC50 inhalation rat (mg/l) ATE US (oral) Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms Symptoms/injuries after inhalation Symptoms/injuries after skin contact Symptoms/injuries after eye contact Symptoms/injuries after ingestion > 90 ml/kg mg/kg Urea dust at 22 mg/m3 caused mild irritation (species not specified) 5000,000 mg/kg bodyweight ph: ph: : Not expected to present a significant hazard under anticipated conditions of normal use. : May cause mild skin irritation. : Ingestion of small amounts would not be expected to produce toxicity. 07/14/2015 EN (English) 4/6

5 SECTION 12: Ecological information Toxicity LC50 fish 1 EC50 Daphnia mg/l (Exposure time: 96 h - Species: Poecilia reticulata) 3910 mg/l (Exposure time: 48 h - Species: Daphnia magna [Static]) Persistence and degradability Bioaccumulative potential BCF fish 1 < 10 Log Pow (at 25 C) Mobility in soil Other adverse effects Effect on the global warming SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations SECTION 14: Transport information : : Dispose of waste in accordance with local regulations. Department of Transportation (DOT) In accordance with DOT Not regulated for transport Additional information Other information : No supplementary information available. ADR Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations Listed on the United States TSCA (Toxic Substances Control Act) inventory Listed on the United States TSCA (Toxic Substances Control Act) inventory International regulations CANADA Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Uncontrolled product according to WHMIS classification criteria Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Uncontrolled product according to WHMIS classification criteria EU-Regulations Listed on the EEC inventory EINECS (European Inventory of Existing Commercial Chemical Substances) Listed on the EEC inventory EINECS (European Inventory of Existing Commercial Chemical Substances) 07/14/2015 EN (English) 5/6

6 Classification according to Regulation (EC) No. 1272/2008 [CLP] Not classified National regulations Listed on the AICS (Australian Inventory of Chemical Substances) Listed on IECSC (Inventory of Existing Chemical Substances Produced or Imported in China) Listed on the Korean ECL (Existing Chemicals List) Listed on NZIoC (New Zealand Inventory of Chemicals) Listed on PICCS (Philippines Inventory of Chemicals and Chemical Substances) Listed on the AICS (Australian Inventory of Chemical Substances) Listed on IECSC (Inventory of Existing Chemical Substances Produced or Imported in China) Listed on the Japanese ENCS (Existing & New Chemical Substances) inventory Listed on the Korean ECL (Existing Chemicals List) Listed on NZIoC (New Zealand Inventory of Chemicals) Listed on PICCS (Philippines Inventory of Chemicals and Chemical Substances) US State regulations SECTION 16: Other information Other information : None. SDS US (GHS HazCom 2012) This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be construed as guaranteeing any specific property of the product 07/14/2015 EN (English) 6/6