TM P MESSAGE CENTERS AN/GSQ-80 (NSN ), AN/GSQ-80A (NSN ), AND AN/GSQ-80B (NSN )

Transcription

1 TECHNICAL MANUAL TM P ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOK LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR MESSAGE CENTERS AN/GSQ-80 (NSN ), AN/GSQ-80A (NSN ), AND AN/GSQ-80B (NSN ) HEADQUARTERS, DEPARTMENT OF THE ARMY NOVEMBER 1976

2

3 *TM P T ECHNICAL M ANUAL HEADQUARTERS DEPARTMENT OF THE ARMY No P W ASHINGTON, DC, 23 November 1976 ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR MESSAGE CENTERS AN/GSQ-80 (NSN ), AN/GSQ-80A (NSN ), AND AN/GSQ-80B (NSN ) Current as of 9 August 1976 REPORTING OF ERRORS You can improve this manual by recommending improvements using DA Form (Test) located in the back of the manual. Simply tear out the self addressed form, fill it out as shown on the sample, fold it where shown, and drop it in the mail. If there are no blank DA Form (Test) in the back of your manual, use the standard DA Form 2028 (Recommended Changes to Publications and Blank Forms) and forward to the Commander, US Army Electronics Command, ATTN: DRSEL-MA-Q, Fort Monmouth, New Jersey In either case a reply will be furnished direct to you. Table of Contents Page Illus Figure SECTION I. II. Group SECTION III. IV. Introduction Repair parts list 5 Message Centers AN/GSQ-80, AN/GSQ-80A, and AN/GSQ-80B 5 Intercommunication Station LS-147C/FI (See TM P for parts.) Telephone Set TA-312/PT (See TM and TM for parts.) Shelters S-280A/G, S-280B/G, and S-141/G Power distribution panel Cable, Power Electrical CX-7705/U Cable, Power Electrical CX-7453/U Cable assembly, telephone 4 foot lone o/a 21 Special tools list (Not applicable) National stock number and part number index This manual supersedes so much of TM , 8 APril 1966, including Change 2, 21 January 1970, as pertains to repair parts and special tools list. i

4

5 SECTION I INTRODUCTION 1. Scope This manual lists repair parts and special tools required for performance of organizational, direct support, and general support maintenance of the AN/ GSQ-80, AN/GSQ-80A, and AN/GSQ-80B. 2. General This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in ascending numerical sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in ascending National item identification number (NIIN, last 9 digits) sequence, of all National stock numbers appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock number and part numbers are cross-referenced to each illustration figure and item number appearance. 3. Explanation of Columns The following provides an explanation of columns found in the tabular listings: a. Illustration. This column is divided as follows: (1) Figure number. Indicates the figure number of the illustration in which the item is shown. (2) Item number. The number used to identify each item called out in the illustration. b. Source, Maintenance, and Recoverability Codes (SMR). (1) Source code. Source codes are assigned to support items to indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: Code Definition PA Item procured and stocked for anticipated or known usage. PD Support item, excluding support equipment, procured for initial issue or outfitting and Code Definition stocked only for subsequent or additional initial issues or outfittings. Not subject to automatic replenishment. XD A support item that is not stocked. When required, item will be procured through normal supply channels. NOTE Cannibalization or salvage maybe used as a source of supply for any items source coded above except those coded XA, XD, and aircraft support items as restricted by AR (2) Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of maintenance: Code Application/Explanation O Support item is removed, replaced, used at the organizational level. F Support item is removed, replaced, used at the direct support level. H Support item is removed, replaced, used at the general support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i. e., all authorized maintenance functions). This position will contain one of the following maintenance codes: Code Application/Explanation O The lowest maintenance level capable of complete repair of the support item is the organizational level. F The lowest maintenance level capable of complete repair of the support item is the direct support level. H The lowest maintenance level capable of complete 1

6 TM P Code ApplicationlExplanation repair of the support item is the general support level. Z Nonreparable. No repair is authorized. (3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codes Definition Z Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. F Reparable item. When uneconomically reparable, condemn and dispose at the direct support level. H Reparable item. When uneconomically reparable, condemn and dispose at the general support level. D Reparable item. When beyond lower level repair capability, return to depot. Condemnation and disposal not authorized below depot level. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d. Part Number. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the item by means of its engineering drawings, specifications standards, and inspection requirements, to identify an item or range of items. NOTE When a stock numbered item is requisitioned, the repair part received may have a different part number than the part being replaced. e. Federal Supply Code for Manufacturer (FSCM). The FSCM is a 5-digit numeric code listed in SB which is used to identify the manufacturer, distributor, or Government agency, etc. f. Description. Indicates the Federal item name and, if required, a minimum description to identify the item. g. Unit of Measure (U/M). Indicates the standard of the basic quantity of the listed item as used in performing the actual maintenance function. This measure is expressed by a two-character alphabetical abbreviation (e. g., ea, in, pr, etc.). When the unit of measure differs from the unit of issue, the lowest unit of issue that will satisfy the required units of measure will be requisitioned. h. Quantity Incorporated in Unit. Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a functional group, subfunctional group, or an assembly. 4. Special Information a. Usable on codes are shown in the description column. Uncoded items are applicable to all models. Identification of the usable on codes used in this publication are: Code 2QE 2W5 2Y7 Used on AN/GSQ-80 AN/GSQ-80A AN/GSQ-80B b. The following publications pertain to the AN/ GSQ-80, AN/GSQ 80A and AN/GSQ-80B and its components: TM , Installation of Telephone Sets TA-312/PT and TA-1/PT with reel equipment CE-11 in gun, AAA-20MM, XM167. TM 1l P, Shelter, Electrical Equipment S-141/G and S-141B/G. TM P, Shelter, Electrical Equipment S-280A/G (NSN ) and S-280B/G (NSN ). TM , Telephone Set TA-312/PT (TO 31W1-2PT-291). TM , Telephone Set TA-312/PT (TO 31W1-2PT-292). TM , Intercommunication Stations LS-147A/FI, LS-147B/FI, LS-147C/FI and LS 147D/FI. TM 1l P, Intercommunication Station LS-147C/FI, FSN TM 1l , Intercommunication Stations LS-147A/FI, LS-147B/FI, LS-147C/FI and LS- 147D/FI. TM , Message Centers AN/GSQ-80, AN/GSQ-80A and AN/GSQ-80B. 5. How to Locate Repair Parts a. When National stock number or part number is unknown. (1) First, Using the table of contents, determine the functional group within which the repair part belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. (2) Second. Find the illustration covering the functional group to which the repair part belongs. (3) Third. Identify the repair part on the illustration and note the illustration figure and item number of the repair part. (4) Fourth. Using the Repair Parts Listing, find the figure and item number noted on the illustration. b. When National stock number or part number is known. (1) First. Using the Index of National Stock 2

7 Numbers and Part Numbers, find the pertinent National stock number or part number. This index is in ascending NIIN sequence followed by a list of part numbers in ascending alphanumeric sequence, crossreferenced to the illustration figure number and item number. TM P (2) Second. After finding the figure and item number, locate the figure and item number in the repair parts list. 6. Abbreviations Not applicable. (Next printed page is 4) 3

8 TM P Figure 1. Message Centers, AN/GSQ-80, AN/GSQ-80A, AN/GSQ-80B. 4

9 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 00 MESSAGE CENTERS, AN/GSQ-80A, AN/GSQ-80B 1 1 PDOHD S-141/G SHELTER,MODIFIED FOR AN/GSQ-80 OR 2QE EA PDOHD S-280A/G SHELTER,MODIFIED FOR AN/GSQ-80A OR 2W5 EA PDOHD S-280B/G SHELTER,MODIFIED FOR AN/GSQ-80B 2Y7 EA 1 5

10 TM P Figure 2. Shelters S-141/G, S-280A/G and S-280B/G (Sheet 1 of 5). 6

11 TM AP Figure 2. Shelters S-141/G, S-280A/G and S-280B/G (Sheet 2 of 5). 7

12 TM P Figure 2. Shelters S-141/G, S-280A/G and S-280B/G (Sheet 3 of 5). 8

13 TM P Figure 2. Shelters S-141/G, S-280A/G and S-280B/G (Sheet 4 of 5). 9

14 TM P Figure 2. Shelters S-141/G, S-280A/G and S-280B/G (Sheet 5 of 5). 10

15 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 03 SHELTERS S-141/G, S-280A/G, S-280B/G 2 1 PAOZZ LAMPHOLDER EA PAOZZ M LAMP,GLOW NE-34 EA XDOFF SCD POWER DISTRIBUTION PANEL EA PAOZZ SWITCH,TOGGLE 2QE EA PAOZZ SWITCH,TOGGLE 2W5,2Y7 EA PAOFF SMB LEAD,ELECTRICAL EA PAOZZ SCC AXE EA PAOZZ SCC BRACKET EA PAOZZ SCC LANTERN,ELECTRIC EA PAOZZ PR LAMP,INCANDESCENT EA PAOZZ SCC BRUSH,DUSTING EA PAOZZ BZ2RQ181P SWITCH,SENSITIVE 2QE EA PAOZZ BZ2RQ18A SWITCH,SENSITIVE 2W5,2Y7 EA PAOHH AT CLOCK,AIRCRAFT,MECHANICAL 2QE EA PAOZZ CONNECTOR,PLUG,ELECTRICAL 2QE EA PAOZZ SMC IMPELLER,FAN 2QE EA PAOZZ PRB-2-1/ BRACKET 2QE EA PAOZZ MX-148/G ROD,GROUND EA PAOZZ SMC IMPELLER,FAN 2QE EA PAOZZ KH37KG712X MOTOR,ELECTRICAL 2QE EA PAOZZ RC-435/U REEL,CABLE EA PAOZZ STRAP ASSEMBLY,TIE DOWN EA PAOZZ SMB TIE DOWN PLATE ASSEMBLY EA XDOOF CX-7453/U CABLE ASSEMBLY,POWER,ELECTRICAL EA XDOOF CX-7705/U CABLE,POWER,ELECTRICAL EA PAOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2QE,2W5 EA XDOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2Y7 EA PAHZZ MK-679/G MAINTENCE KIT,ELECTRONIC EA PAFZZ MK-681/G REPAIR KIT,ELECTRONIC EQUIPMENT SHELTER MK-681/G EA PAOOF SCD383873GP CABLE ASSEMBLY,TELEPHONE EA PAOZZ W/RS LAMP,INCANDESCENT EA PAOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2QE EA PAOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2W5 EA XDOZZ 7210B CONNECTOR,RECEPTACLE,ELECTRICAL 2W5 EA PAOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2Y7 EA PAOZZ CONNECTOR,RECEPTACLE,ELECTRICAL 2Y7 EA PAOZZ SCC LIGHT,EXTENSION EA PAOZZ FS STARTER,FLUORESCENT 2QE EA PAOZZ FS STARTER,FLUORESCENT 2W5,2Y7 EA 9 11

16 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE USABLE ON CODE U\M UNIT 2 32 PAOZZ X LAMPHOLDER 2QE EA PAOZZ X LAMPHOLDER 2W5,2Y7 EA PAOZZ P RETAINER,LAMP 2QE EA XDOZZ SWITCH,TOGGLE 2QE EA PAOZZ SCC CAPACITOR,FIXED,PAPER 2QE EA PAOZZ SMC352521GR CURTAIN,BLACKOUT SELECT 2QE EA PAOZZ SMC352521GR CURTAIN,BLACKOUT 2QE EA PAOZZ SCC SHIELD,LIGHT 2QE EA PAOZZ SCC SHIELD,LIGHT 2W5,2Y7 EA PAOZZ D BALLAST,LAMP 2QE EA PAOZZ X LAMPHOLDER 2QE EA PAOZZ X LAMPHOLDER 2W5,2Y7 EA PAOZZ F20T12CW LAMP,FLUORESCENT 2QE EA PAOZZ F20T1CW LAMP,FLUORESCENT 2W5,2Y7 EA PAOZZ SCC CLOCK,WALL 2W5,2Y7 EA PAOZZ SCD MOTOR,ELECTRICAL 2W5,2Y7 EA XDOZZ F SWITCH,TOGGLE 2W5,2Y7 EA PAOZZ U-106/U POST BINDING EA PAOZZ COVER,ELECTRICAL OUTLET EA PAOZZ U-238B/G CONNECTOR,RECEPTACLE,ELECTRICAL EA PAOZZ SCC CAP,ELECTRICAL EA 8 12/(13 BLANK)

17

18 TM AP Figure 3. Power Distribution Panel. 14

19 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 0301 POWER DISTRUBUTION PANEL 3 1 PAOZZ MR36W50SPECR AMMETER EA PAOZZ NE LAMP,GLOW EA PAOZZ LAMPHOLDER 2QE EA PAOZZ LAMPHOLDER 2W5,2Y7 EA PAOZZ Q CIRCUIT BREAKER EA PAOZZ Q CIRCUIT BREAKER EA PAOZZ Q CIRCUIT BREAKER EA PAOZZ MR36W150ACVVR VOLTMETER EA PAOZZ CT35B TRANSFORMER,CURRENT EA 1 15

20 TM P Figure 4. Cable, Power, Electrical CX-7705/U. 16

21 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 0302 CABLE, POWER, ELECTRICAL CX-7705/U 4 1 PAOZZ U-237B/G CONNECTOR,PLUG,ELECTRICAL EA 2 17

22 TM P Figure 5. Cable, Power, Electrical CX-7453/U. 18

23 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 0303 CABLE, POWER, ELECTRICAL CX-7453/U 5 1 PAOZZ U-237B/G CONNECTOR,PLUG,ELECTRICAL EA 2 19

24 TM1l P Figure 6. Cable Assembly, Telephone 4 Foot Long O/A 20

25 SECTION II TM P (1) (2) (3) (4) (5) (6) (7) (8) ILLUSTRATION QTY (a) (b) NATIONAL DESCRIPTION INC FIG ITEM SMR STOCK PART IN NO. NO. CODE NUMBER NUMBER FSCM USABLE ON CODE U\M UNIT GROUP 0304 CABLE ASSEMBLY, TELEPHONE 4 FT LONG O/A 6 1 XDOZZ J JACK,TELEPHONE EA 1 21

26 SECTION IV TM P NATIONAL STOCK NUMBER AND PART NUMBER INDEX NOTE: LATEST NATIONAL STOCK NUMBER ASSIGNMENTS ARE INCLUDED AT END OF INDEX FIGURE ITEM FIGURE ITEM STOCK NUMBER NO. NO. STOCK NUMBER NO. NO PART FIG. ITEM PART FIG. ITEM NUMBER FSCM NO. NO. NUMBER FSCM NO. NO. AT SCC BZ2RQ18A SCD383873GP BZ2RQ181P SCD CX-7453/U SCD CX-7705/U SCD FS SMB F20T12CW SMB F SMC352521GP J SMC542696GP KH37KG712X SMC542696GP MK-679/G U-106/U MK-681/G U-237B/G MR36W150ACVVR U-237B/G MR36W50SPECR U-238B/G MX-148/G M CT35B NE Apr PRB-2-1/ /12/ PR P W/RS Q Q Q RC-435/U S-141/G S-280A/G S-280B/G SCC B SCC352521GP X SCC X SCC D SCC SCC SCC SCC LATEST NATIONAL STOCK NUMBER ASSIGNMENTS FIGURE ITEM STOCK NUMBER NO. NO

27

28

29

30

31

32

33

34

35 By Order of the Secretary of the Army: BERNARD W. ROGERS General, United States Army Chief of Staff DISTRIBUTION: Active Army: USASA (2) COE (1) TSG (1) USAARENBD (1) DARCOM (1) TRADOC (2) OS Maj Comd (4) LOGCOMDS (3) MICOM (2) TECOM (2) USACC (4) MDW (1) Armies (2) Corps (2) HISA (Ft Monmouth) (33) Svc Colleges (1) USASIGS (5) USAADS (2) USAFAS (2) USAARMS (2) USAIS (2) USAES (2) USAICS (3) MAAG (1) USARMIS (1) SigFLDMS (1) USAERDAA (1) USAERDAW (1) NG: None USAR: None For explanation of abbreviations used see, AR Installations (2) except Fort Carson (5) Fort Gillem (10) Fort Huachuca (10) Ft Richardson (ECOM Ofc) (2) LBAD (14) SAAD (30) TOAD (14) SHAD (3) Units org under fol TOE: (1) (AA-AC)

36

37

38

39

40 PIN :

41 This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF= Military and Government Manuals</A> Sincerely Igor Chudov Chicago Machinery Movers