Zero Liquid discharge for the Industrial sector
|
|
- Buddy Phillips
- 5 years ago
- Views:
Transcription
1 Zero Liquid discharge for the Industrial sector
2 Major Concerns... Where is the space for process plant??? Reduce Foot Print
3 Major Concerns... Can I use treated wastewater somewhere??? Recycle & Reuse of Treated Wastewater
4 Major Concerns... Can I avoid liquid discharge??? Zero Liquid Discharge (ZLD)
5 Major Concerns... Can I generate/save energy??? Energy Recovery & Maximization of Energy Efficiency
6 Water & Wastewater Solution
7 Solutions... Selection of Appropriate Technologies Integrated Design Approach Solution under one roof
8 Zero Liquid Discharge...
9 How to Achieve ZLD... STEP 1 Effluent From Process Plant Recovery of solvents by using distillation Process
10 How to Achieve ZLD... STEP 2 Effluent after Solvent Recovery Removal of Organic Matter by Using Anaerobic Digestion
11 How to Achieve ZLD... STEP 3 Anaerobically Treated Effluent Removal of Balance Organic Matter by Using Aerobic Digestion
12 How to Achieve ZLD... STEP 4 Treated Effluent from ETP Clarification by using, tube settler /Clariflocculator
13 How to Achieve ZLD... STEP 5 Effluent after Clarification Further Reduction in TSS by using Filters
14 How to Achieve ZLD... STEP 6 Effluent after Filters Reduction in Turbidity and SDI by using Ultra Filtration
15 How to Achieve ZLD... STEP 7 Effluent after UF Recovery of low TDS Permeate by using RO
16 How to Achieve ZLD... STEP 8 High TDS Rejects from RO Concentration of RO Rejects by using battery of evaporators
17 How to Achieve ZLD... STEP 9 Separation of salts from Mother Liquor using Centrifuge In case if advance technologies like MBR is used for the treatment of effluents then 4th to 6th steps can be eliminated Drying of Mixed Salts using ATFD
18 How to Achieve ZLD... In case if advance technologies like MBR is used for the treatment of effluents then 4th to 6th steps can be eliminated TANK VOLUME Conventional ASP 100% MBR Process 40%
19 Key Challenges in ZLD... Efficient Treatment for Reduction of COD & BOD High Recovery through RO to reduce load on Evaporation system Highly Corrosive Effluent Material Compatibility at Higher Temperature High Capital Investment Operating Cost for the treatment Turnkey Responsibility
20 How to Address Challenges... Efficient Removal of COD & BOD - Use of Advance Biological Treatment High Recovery through RO - Use of Proper Pre-treatment - Right Selection of Membranes and RO Configuration Material Compatibility at Higher Temperature - Operate Evaporation System at low temperature High Capital Investment - Use various combination of Evaporators Operating Cost for the treatment - Use innovative approach like TVR or MVR
21 Solutions... Conventional Falling Film Evaporator Forced Circulation Evaporator Forced Falling Film Evaporator Fluidized Bed Patented Evaporator
22 Falling Film Evaporator... STEAM VAPORS COND. FEED
23 Features and Limitations... Better Heat Transfer Coefficient. Low Power consumption. Can be started up quickly and changed to cleaning mode. Useful in heat sensitive chemical solutions Not suitable at higher suspended solid concentration and higher viscosity. Distribution system is critical and can lead to tube fouling in absence of adequate wetting rate. Frequent C.I.P. Required.
24 Forced Circulation... STEAM VAPORS FEED CONDENSATE CONC. PRODUCT
25 Features and Limitations... Capable of handling Suspended slurry, Saturated solution & viscous liquids. Can be operated with min temperature differences between the heating media and the boiling liquid. No frequent Scale inside the tubes. High Capital Investment. High Operating Cost. Can be installed vertically as well as horizontally.
26 Forced Falling Film... LIQUOR IN SHOWER NOZZLE DISTRIBUTOR LIQUOR FILM Tube Wall FALLING FILM UPPER MAIN LIQUOR BOX Condensed Steam Or Vapor On Outside Wall Of Tube LIQUOR VAPOR
27 Features... All advantages of conventional falling film Evaporation. Comparatively less problem of tube wetting rate due to Spraying Nozzles. Less prone to fouling as compared with Conventional Falling Film Evaporator.
28 Flubex... Flubex- Concept Recirculating fluidized bed heat exchanger Evaporation by Flashing in Vapor Liquid Separator. Fluidizing medium in Tube. Self-cleaning action.
29 Flubex...
30 Flubex... Continuous self-cleaning action avoid scaling. No Frequent C.I.P. Less generation & disposal problem of C.I.P. Effluent. No standby unit required. Lesser floor space.
31 Advanced Technology... ECOPHOTOx... Photo - Light (Photon) Oxidation - Addition of Oxygen Pollutant and oxidant are elevated to an activated state wherein the oxidation rate increases multifolds. As a result, the COD contributing molecules are broken down, oxidised and leave the effluent stream in the form of CO2 and H2O Complex Organic Compounds UV Activation Oxidant Intermediates UV Activation Oxidant CO 2 + H 2 O
32 What is ECOPHOTOx It destroys/treats non-biodegradable organic contaminants present in wastewater, which are generally represented as Recalcitrant Chemical oxygen demand. It enhances the oxidation rate with the help of ultraviolet light in presence of oxidizing chemicals such as hydrogen peroxide, ozone etc Praj Industries Ltd 32
33 What is ECOPHOTOx Exposing H 2 O 2 to Ultraviolet radiation generates OH radical. H2O2 + light energy (hv) *OH OH radical (hydroxyl radical) is powerful but relatively non-selective transient oxidizing species. *OH has the highest thermodynamic oxidation potential. Most environmental contaminants react 1 million to1 billion times faster with *OH than with O 3 - a conventional oxidant. Praj Industries Ltd 33
34 What is ECOPHOTOx Oxidant OH 2.80 O( 1 D) 2.42 O H 2 O Perhydroxy Radical Oxidation Potential 1.70 Permangante Ion 1.67 Chlorine Dioxide 1.50 Chlorine 1.36 O 2 Oxidation Potential Unit (ev) 2 Praj Industries Ltd 34
35 Flubex Installation...
36 MVR Based Evaporator Installation.. Steam less Evaporation Stripper for Process Condensate Recyclable quality of process condensate Concentrate having high calorific value use as a fuel
37 Evaporator Plant Installation.. Recovery of Globur Salts (Na2SO4.10 H2O) Selling at handsome price Smart Payback
38 3 Effect TVR Based MEE.. Recovery of NaCl Salts Selling at handsome price Smart Payback
39 Other Technologies in Basket.. Advanced Anaerobic Digestion Advanced Aerobic System (MBBR, SBR, MBR etc) All types of Membrane Applications Ozonation
40 Solution under One Roof.. More than 600 references in 50 countries
41 Thank you Manish Kharwade Praj Industries Ltd
Zero Liquid discharge for the Industrial sector. by Amit Udgirkar Sr. Manager Environmental Engineering Praj Industries Ltd
Zero Liquid discharge for the Industrial sector by Amit Udgirkar Sr. Manager Environmental Engineering Praj Industries Ltd Major Concerns... Where is the space for process plant??? Reduce Foot Print Major
More informationZero Liquid Discharge for Pharma Challenges & Solutions
Zero Liquid Discharge for Pharma Challenges & Solutions 5.02.2013 1 Green Chemistry Water & Wastewater Solution www.praj.net 2 Effluent Composition Solvents Methanol MDC ACN IPA Toluene Acetone Ethanol
More informationGreen Business Options: Zero Liquid Discharge Solutions for Industries. By Manish Kharwade
Green Business Options: Zero Liquid Discharge Solutions for Industries By Manish Kharwade Industries Major Concerns Praj Industries Ltd www.praj.net Major Concerns... Where is the space for process plant???
More informationZLD solution for Pharmaceutical Industry
ZLD solution for Pharmaceutical Industry Hemant Wagh Associate Vice President Water & WW solutions Group Major Concerns... Where is the space for process plant??? Can I generate/save energy??? Can I use
More informationOsmoBC Integrated Membrane Systems
OsmoBC Integrated Membrane Systems For Industrial Wastewater Treatment Fluid Technology Solutions, Inc. OsmoF2O FO Membranes HBCR High Brine Concentrator OsmoZLD Treatment Process INTEGRA Disk Filtration
More informationPretreatment of Industrial Wastewater for ZLD/Resources Recovery
Pretreatment of Industrial Wastewater for ZLD/Resources Recovery An Application of Oxidative Evaporation Technology Philip Chen, PhD, P.E. O E Technology, LLC Info@oetech.com 1 Process Plant Bio-Unfit
More informationEffluent Treatment Methods And Reverse Osmosis and its Rejects Handling
Effluent Treatment Methods And Reverse Osmosis and its Rejects Handling Dr P P Lal Krishna Chief Executive Officer Ramky Pharma City (India) Ltd Developer of Jawaharlal Nehru Pharma City - Vizag TREATMENT
More informationdischarge summary system design
liquid discharge ZLDzero summary system design ZLD TECHNOLOGY S.M.A.R.T. Z PROCESS TM S.M.A.R.T. Z PROCESS TM Zero Liquid Discharge (ZLD) is the ultimate cutting-edge process for the total elimination
More informationTITLE : ZERO LIQUID DISCHARGE TECHNOLOGIES & ECONOMICS
TITLE : ZERO LIQUID DISCHARGE TECHNOLOGIES & ECONOMICS Author : Soham Mehta Managing Director Advent Envirocare Technology Pvt. Ltd. A-1, 8th Floor, Safal Profitaire, Corporate Road, Prahaladnagar, Ahmedabad
More informationWastewater Recycling Plants with Zero Effluent Discharge. Water Recycling Plants
Wastewater Recycling Plants with Zero Effluent Discharge By Transparent Technologies Private Limited Business Groups Co-generation systems Absorption Cooling Systems Water Recycling Plants Heat recovery
More informationReduction of Biochemical Oxygen Demand and Chemical Oxygen Demand of Metalworking Fluid Wastewater by Electrochemical Oxidation
1 Reduction of Biochemical Oxygen Demand and Chemical Oxygen Demand of Metalworking Fluid Wastewater by Electrochemical Oxidation J. M. Burke STLE Houghton International A. Petlyuk, PhD STLE Houghton International
More informationEffluent Treatment Using Evaporation and Crystallisation Technology
Effluent Treatment Using Evaporation and Crystallisation Technology Brecknell C, Lilliott M, Pavlik A Wellman Process Engineering Newfield Road, Oldbury. B69 3ET. UK The authors will demonstrate with the
More informationPACKAGED SEW AGE TREATMENT PLANT
PACKAGED SEW AGE TREATMENT PLANT AGUAPURO also offers Packaged Sewage Treatment Plant, easyto-install, prefabricated solution, outstanding performance and efficiency. Package system includes the tanks
More informationNadeem Shakir Qatar Petroleum. The 2nd Joint Qatar Japan Environmental Symposium, QP JCCP The 21st Joint GCC Japan Environmental Symposium
Nadeem Shakir Qatar Petroleum Scheme of Presentation General Overview of QP Refinery, Mesaieed. Challenges in Treatment Existing Waste Water Treatment Facilities Capacity Expansion and Upgradation of WWTP
More informationTreated Effluent (TSE) Reuse Applications and Challenges. Saudi Arabia
Treated Effluent (TSE) Reuse Applications and Challenges Saudi Arabia > Agenda General Treatment Technologies Cooling Towers Application Power Application Industry Application Brine Disposal TITRE PRÉSENTATION
More informationChemical Precipitation and Ballasted Flocculation
Chemical Precipitation and Ballasted Flocculation Rationale to Recycle Fracing Flowback and Produced Water As the unconventional oil/gas industry faces an evolving regulatory environment, increasing public
More informationZero Discharge for Textile Industry
Zero Discharge for Textile Industry C K Sandeep, General Manager Corporate Marketing, Ion Exchange (India) Ltd. Introduction The post liberalization period has led to the rapid growth of industrial output
More informationKirill Ukhanov, GE Water & Process Technologies, Russia, describes how advanced membrane technology is helping a Russian refinery to meet stringent
Kirill Ukhanov, GE Water & Process Technologies, Russia, describes how advanced membrane technology is helping a Russian refinery to meet stringent wastewater requirements. In Russia, there are strict
More informationWASTE WATER RECYCLE MANAGEMENT ION EXCHANGE INDIA LTD
WASTE WATER RECYCLE MANAGEMENT ION EXCHANGE INDIA LTD Blue Issues Scarcity & rising costs Drought Pollution Tremendous pressure on available finite water resources due to Rapid industrialisation, Expanding
More information27 th ANNUAL WATEREUSE SYMPOSIUM CHALLENGES OF HIGH-SULFATE WASTEWATER RECYCLE. Abstract. Introduction
27 th ANNUAL WATEREUSE SYMPOSIUM CHALLENGES OF HIGH-SULFATE WASTEWATER RECYCLE William Matheson, Duraflow, Tewksbury, MA Abstract A cement products manufacturer, having a sulfate and total dissolved solid
More informationSustainable Water Management for the Pharmaceutical and Cosmetics Industry
Sustainable Water Management for the Pharmaceutical and Cosmetics Industry WATER TECHNOLOGIES Creating Water Solutions for the Pharmaceutical and Cosmetics Industry Veolia Water Technologies provide specialized
More informationOBG WASTE MANAGEMENT PRESENTS: 18 th Annual New England Pretreatment Coordinators Workshop (October 27, 2016) Landfill Leachate Overview Mark Greene,
OBG WASTE MANAGEMENT PRESENTS: 18 th Annual New England Pretreatment Coordinators Workshop (October 27, 2016) Landfill Leachate Overview Mark Greene, Ph.D., P.E. OBG Anne Reichert, P.E. WM AGENDA Leachate
More informationTechnology for the Treatment/Reuse of Refinery Wastewater
Technology for the Treatment/Reuse of Refinery Wastewater Joseph Sebastian Biological Treatment Typical Applications and Operating Conditions Designed primarily for removal of biodegradable organic matter,
More informationWaste Management Waste Heat Evaporator for RO Reject Management Bosch Limited Nashik Plant
1 Waste Management Waste Heat Evaporator for RO Reject Management Bosch Limited Nashik Plant Background Need for the Project Requirement of low cost & optimized solution for RO reject handling Trigger
More informationPOREX Tubular Membrane Filter (TMF ) Applied in a ZLD System as Critical Solid/Liquid Separation Process
POREX Tubular Membrane Filter (TMF ) Applied in a ZLD System as Critical Solid/Liquid Separation Process Abstract Introduction Beijing Shougang Biomass Energy Technology Co., Ltd, a branch company of SHOUGANG
More informationZERO DISCHARGE PROCESSES USING NEW LOW COST EVAPORATION TECHNOLOGY
ZERO DISCHARGE PROCESSES USING NEW LOW COST EVAPORATION TECHNOLOGY Applicability of different water treatment technologies 3 = high separation 2 = moderate 1 = low separation Note! ph may change rating
More informationWater Solutions for Downstream Oil & Gas
Water Solutions for Downstream Oil & Gas WATER TECHNOLOGIES Solutions that ensure your productivity Veolia Water Technologies is dedicated to serving the oil and gas industry globally. With a wide array
More information1. What is ZLD? 2. ZLD Drivers
1. What is ZLD? Zero Liquid Discharge (ZLD) is a treatment process that its goal is to remove all the liquid waste from a system. The focus of ZLD is to reduce economically wastewater and produce clean
More informationPURPOSE PROCESS PAYOFF
Water Reuse 4/04/13 PURPOSE PROCESS PAYOFF Water Water Everywhere but not a drop to drink! Seawater versus Water Reuse UF - RO for brackish waste water streams: 0.81.2 kw h/m3 MBR RO for brackish waste
More informationMEMBRANE BIOREACTORS FOR RO PRETREATMENT
ABSTRACT MEMBRANE BIOREACTORS FOR RO PRETREATMENT Simon Dukes, Antonia von Gottberg Koch Membrane Systems, 850 Main Street, Wilmington, MA 01887 Currently, treated municipal wastewater is typically discharged
More informationHow can liquid ozone be used in different industries?
How can liquid ozone be used in different industries? WATER TREATMENT SYSTEMS AND PLANTS: Pre-oxidant, pre-disinfectant, coagulant aid, and biofilm remover. Effluent disinfection. ULTRA-FILTRATION SYSTEMS
More informationTANNERY WASTEWATER TREATMENT & MANAGEMENT
Next-Gen Technologies for Leather Sector: Approaches towards Industry 4.0., Central Leather Research Institute (CLRI), Chennai. TANNERY WASTEWATER TREATMENT & MANAGEMENT SILVANO STORTI, CEO - EUROPROGETTI
More informationRaw Water Treatment. Ion Exchange. Membrane Processes. Recycle/Reuse. Zero Liquid Discharge. Industrial Concentration.
Raw Water Treatment Ion Exchange Membrane Processes Recycle/Reuse Zero Liquid Discharge Industrial Concentration Desalination Performance Excellence & Technology Leadership Aquatech International Corporation,
More informationWater Treatment Technology
Lecture 4: Membrane Processes Technology in water treatment (Part I) Water Treatment Technology Water Resources Engineering Civil Engineering ENGC 6305 Dr. Fahid Rabah PhD. PE. 1 Membrane Processes Technology
More informationZero Liquid Discharge for Water Remediation. Bill Berzins, M.A.Sc. P.Eng.
Zero Liquid Discharge for Water Remediation Bill Berzins, M.A.Sc. P.Eng. Zero Liquid Discharge Strategy Technology Selection Case Studies Recommendations Project Portfolio: Design-Build-Operate-Transfer
More informationTreatability Study and Reverse Osmosis Pilot Study of Industrial Wastewater at a Wood Products Mill
Treatability Study and Reverse Osmosis Pilot Study of Industrial Wastewater at a Wood Products Mill NC AWWA-WEA 2017 Annual Conference Randall Foulke, PE, BCEE, LEED AP Tracey Daniels, EI November 14,
More informationAppendix D JWPCP Background and NDN
Appendix D JWPCP Background and NDN JWPCP Background JWPCP Water Quality Primary Clarifiers HPO Reactors Final Clarifiers Unit Influent Primary Effluent Secondary Effluent BOD mg/l 460 240
More informationWastewater Treatment clarifier
Wastewater Treatment Pretreatment During pretreatment, items would normally be removed that would hinder the further processes of treatment. Items commonly removed include roots, rags, cans, or other large
More informationDavid Delasanta Executive Vice-President. Superior Distillation Performance on High TDS Water Using Flash Vacuum Distillation
David Delasanta Executive Vice-President Superior Distillation Performance on High TDS Water Using Flash Vacuum Distillation For Hydrofracking Produced and Flowback Water Symbol: TMEN www.thermoenergy.com
More informationMembrane BioReactor: Technology for Waste Water Reclamation
Membrane BioReactor: Technology for Waste Water Reclamation Sachin Malekar - Senior Manager, Technology & Nilesh Tantak - Executive, Technology Ion Exchange (India) Ltd. BACKGROUND Due to diminishing water
More informationWater Treatment Solutions A - Z
Watch Water GmbH Fahrlachstraße 14 68165 Mannheim Germany A - Z Market forecast (2014-2020) New Treatment Methods Our Objective Brief description of Watch Solutions -by Deepak Chopra October 2013 Web:
More informationZERO LIQUID DISCHARGE The Ultimate Challenge Fluor. All rights reserved. FLUOR is a registered service mark of Fluor Corporation.
ZERO LIQUID DISCHARGE The Ultimate Challenge 2015 Fluor. All rights reserved. FLUOR is a registered service mark of Fluor Corporation. 1 Agenda Introduction Drive towards ZLD Block Flow Diagram Fluor s
More informationHorizontal Falling Film Brine Concentrator
Horizontal Falling Film Brine Concentrator The 3rd International Sede Boqer Conference on Water Technologies, 2012: Advanced Technologies in Water Management Tuesday 16 October 2012 Dr. Yony Weiss, VP,
More informationAdvanced Technologies for Produced Water Treatment 2014 PERF Spring Meeting
Advanced Technologies for Produced Water Treatment 2014 PERF Spring Meeting Doha, Qatar April 13-14, 2014 Presentation Topics Global Water Sustainability Center Advanced Technologies for Produced Water
More informationBOOMERANG FROM BIO-EFFLUENT TO POTABLE WATER
BOOMERANG FROM BIO-EFFLUENT TO POTABLE WATER FROM BIO-EFFLUENT TO POTABLE WATER Waterleau uses state of the art membrane technology for closing the loop in the water cycle. A double barrier membrane concept
More informationPROCESS INTENSIFICATION A usual approach in water treatment for the chemical industry
PROCESS INTENSIFICATION A usual approach in water treatment for the chemical industry Sylvie BAIG Head of Scientific Innovation Treatment Solutions Agnès PILAS-BEGUE Head of Global Environmental R&I Network
More informationReverse Osmosis and Nano-filtration Innovation for Water Re-use
Reverse Osmosis and Nano-filtration Innovation for Water Re-use 5 th Water Arabia Conference and Exhibition Safiya Alsogair Research and Development Engineer Dow Middle East Innovation Center (MEIC) 18
More informationMEMBRANE BIOREACTOR NIHAR DOCTOR. Director
TM MEMBRANE BIOREACTOR NIHAR DOCTOR Director en-vısı n Enviro Technologies Pvt. Ltd. (Pollution Control Consultants & Engineers) Shree Ram Complex, 2 nd Floor, Above Bank Of India, Near Kargil Chowk, Surat
More informationInternational Journal of Science, Environment and Technology, Vol. 4, No 5, 2015,
International Journal of Science, Environment and Technology, Vol. 4, No 5, 2015, 1330 1335 ISSN 2278-3687 (O) 2277-663X (P) TREATABILITY STUDY METHODOLOGY & APPLICATION Ms. Seema A. Nihalani Head and
More informationCooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India - Reducing the water footprint in coal fired power plants -
Powergen Bangkok 3 rd October 2103 Session 5 Intake, Cooling and Blowdown Treatment Considerations Cooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India - Reducing the water footprint
More informationWATER AND WASTEWATER FACILITY CLASSIFICATION APPLICATION FORM
WATER AND WASTEWATER FACILITY CLASSIFICATION APPLICATION FORM APPLICATION INSTRUCTIONS Please print or type. In keeping with the privacy provisions of the Nova Scotia Freedom of Information & Protection
More informationRO System Design & CSMPRO v6.0 Program
RO System Design & CSMPRO v6.0 Program CONTENTS 1 System Design 2 CSMPRO v6.0 Introduction 1 1 System Design 2 Consideration of Feed Source, Application The membrane system design depends on Feed Source,
More informationJ.K. ENGINEERING LTD. CONSULTING * RESEARCH * DEVELOPMENT
J.K. ENGINEERING LTD. CONSULTING * RESEARCH * DEVELOPMENT #320, 7930 - Bowness Rd. N.W. Calgary, AB, T3B 0H3, Tel. (403) 247-1777 Fax. (403) 286-9895, e-mail: jkeng@telus.net WATER TECH 2009 BANFF, ALBERTA,
More informationAchieve Zero-liquid Discharge of Industrial Wastewater. (Distill Process Waste for Reuse)
(Distill Process Waste for Reuse) by Gary N. Dixon, Sr.Application Engineer, Samsco Water Evaporators Innovative, patented, multi-staged, full distillation, vacuum technology evaporation equipment from
More informationWATER RECYCLING PLANT IN WAFRA. Feras Al Salem
WATER RECYCLING PLANT IN WAFRA Feras Al Salem Introduction 2 The Joint Operations (JO) was born in 1960 when the two oil companies formed a joint committee to oversee and supervise their operations with
More informationSonoran CryoDesal LLC Freeze Desalination: non-membrane desalination technology for difficult water / wastewater streams.
Sonoran CryoDesal LLC Freeze Desalination: non-membrane desalination technology for difficult water / wastewater streams July 17, 2017 1 CryoDesalination: When RO Is Not a Good Option Reverse Osmosis (RO)
More informationSaving Energy and Water. Working with High Recovery Water Treatment Plants
Saving Energy and Water Working with High Recovery Water Treatment Plants > Saving Energy and Water Working with High Recovery Treatment Plants Reverse Osmosis - Benefits o Reliable and Consistent Technology
More informationBEING GOOD STEWARDS: IMPROVING EFFLUENT QUALITY ON A BARRIER ISLAND. 1.0 Executive Summary
BEING GOOD STEWARDS: IMPROVING EFFLUENT QUALITY ON A BARRIER ISLAND Brett T. Messner, PE, Tetra Tech, Inc., 201 E Pine St, Suite 1000, Orlando, FL 32801 Brett.Messner@tetratech.com, Ph: 239-851-1225 Fred
More informationNovel Memthane Anaerobic MBR realizing sustainable ambitions. Frankfurt; June 19, 2012; 11:30 Jan Pereboom and Jeroen van der Lubbe
Novel Memthane Anaerobic MBR realizing sustainable ambitions Frankfurt; June 19, 2012; 11:30 Jan Pereboom and Jeroen van der Lubbe Contents 1. Introduction 2. Drivers for AnMBR 3. Novel Memthane technology
More informationTreatment of saline streams: removal of non-precipitable salts Case studies
Treatment of saline streams: removal of non-precipitable salts Case studies Mauchauffee S., Denieul M.-P., Le Calvez G., De Laval A., Coste M. Veolia Environnement Recherche & Innovation 16/07/2012) Veolia
More informationCooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India Reducing the water footprint in coal fired power plants
Cooling Tower Blowdown Treatment and Reuse in a Coal Fired Power Plant in India Reducing the water footprint in coal fired power plants Author name Deepak Kachru Company Aquatech Systems (Asia) Pvt. Ltd.
More informationEnergy-Efficient Textile Dyeing Effluent Recycling
Efficient Effluent Recycling Jai Swaminathan 1 Energy-Efficient Textile Dyeing Effluent Recycling Jaichander Swaminathan Prof. John H. Lienhard V Dept. of Mechanical Engineering Problem: Cheap Zero Discharge
More informationNanomaterials for Industrial Wastewater
Dais: An Overview Aqualyte : The Foundation of Dais Materials Moving Molecules 2018 Dais Analytic Corporation. All rights reserved. www.daisanalytic.com 14 March 2018 Slide 1 Nanomaterials for Industrial
More informationGreen Business Options
Green Business Options 19 th & 20 th March 2016, Krishna Palace, Ambernath. Organizer MPCB Co organizers - IGCW Introduction.. Waste water treatment and Zero liquid discharge : Way to sustain What s Happening!
More informationModule 23 : Tertiary Wastewater Treatment Lecture 39 : Tertiary Wastewater Treatment (Contd.)
1 P age Module 23 : Tertiary Wastewater Treatment Lecture 39 : Tertiary Wastewater Treatment (Contd.) 2 P age 23.3.6 Membrane module A single operational unit into which membranes are engineered for used
More informationWaste Management for Food & Agriculture Industry Cleaner Production for Food industries
Waste Management for Food & Agriculture Industry Cleaner Production for Food industries Thilina Gunawardhana Dept. of Chemical & Process Engineering University of Moratuwa Cleaner Production In simple
More informationATTACHMENT E.3 EMISSIONS TO SEWER LOCATION OF EMISSION TO SEWER (IE DR-0003) Consent of copyright owner required for any other use.
ATTACHMENT E.3 EMISSIONS TO SEWER LOCATION OF EMISSION TO SEWER (IE0310818-22-DR-0003) Page 152 of 217 Attachment E.3 Emissions to Sewer It is proposed that trade and foul effluent from the facility will
More informationAPPLICATIONS AND SUSTAINABLE WATER SOLUTIONS FOR. Food and Beverage
APPLICATIONS AND SUSTAINABLE WATER SOLUTIONS FOR Food and Beverage Let s Solve Water For over a century, Xylem s well-known global brands have served the water market in more than 150 countries. Xylem
More informationis a paradigm shift in produced water treatment technology occurring at SAGD facilities?
Water Technologies & Solutions technical paper is a paradigm shift in produced water treatment technology occurring at SAGD facilities? Paper presented at the Canadian International Petroleum Conference
More informationWastewater Reclamation at Industrial Parks
Confederation of Indian Industry Conference on Water Management Hilton Chennai, 17 June 2016 June 2016 Mohamad Nor Ahmad Ranhill Holdings Berhad 1 Why Reclaim Our Wastewater? 71% of earth is covered by
More informationLenntech. Tel Fax
Case History Lenntech info@lenntech.com Tel. +31-152-610-900 www.lenntech.com Fax. +31-152-616-289 Site Information Location: Beijing, China Capacity: Second Phase, 150m 3 /h; Third Phase, 160m 3 /h Time
More informationReclaimed Waste Water for Power Plant Cooling Tower Water & Boiler Feed Make-up. Richard Coniglio, Business Product Manager
Reclaimed Waste Water for Power Plant Cooling Tower Water & Boiler Feed Make-up Richard Coniglio, Business Product Manager 70% Covered with Water 3% is Fresh Water 1% of the Fresh Water is only accessible.
More information"Significant Cost Savings Obtained Using Advanced Membrane Systems for Cooling Tower Water Treatment and in ZLD plants
Better Lives. Better Planet.SM "Significant Cost Savings Obtained Using Advanced Membrane Systems for Cooling Tower Water Treatment and in ZLD plants Webcast December 2012 Bernhard Doll Pall GmbH Disclaimer
More informationBrian Carrico, AICP, Senior Project Manager/Environmental Planner
Technical Memorandum Date: Subject: From: To: Zero Liquid Discharge Description Dan Shafar, PE, Project Engineer Brian Carrico, AICP, Senior Project Manager/Environmental Planner Route to: INTRODUCTION
More informationYOUR DIRTY PROCESS WATER IS INCREASING YOUR TOTAL OPERATING COSTS
YOUR DIRTY PROCESS WATER IS INCREASING YOUR TOTAL OPERATING COSTS Presented by Vortisand Water Expert Mike Ditton 2017 Evoqua Water Technologies LLC MIKE DITTON WATER FILTRATION EXPERT Mike Ditton Water
More informationSulaibiya world s largest membrane water reuse project
Water Technologies & Solutions technical paper Sulaibiya world s largest membrane water reuse project background In May 2001, a consortium including Mohammed Abdulmohsin Al-Kharafi and Sons (The Kharafi
More informationEVALED. Evaporator and Crystallizer WATER TECHNOLOGIES
EVALED Evaporator and Crystallizer WATER TECHNOLOGIES _Evaporation Technologies Evaporation is not only a natural phenomenon but also a clean separation technology that has been recognized as a best available
More informationRohan M. Patil NIRTECH Pvt. Ltd., Mumbai. ALL INDIA DISTILLERS ASSOCIATION TECHNICAL SEMINAR, NEW DELHI Date : 19 th February, 2016
Rohan M. Patil NIRTECH Pvt. Ltd., Mumbai ALL INDIA DISTILLERS ASSOCIATION TECHNICAL SEMINAR, NEW DELHI Date : 19 th February, 2016 Objectives of Distilleries Achieve ZSD Zero Spent Wash Discharge Have
More informationIndustrial Waste Water Treatment. Unit 5
Industrial Waste Water Treatment Unit 5 Outline Levels of treatment methods 1 Biological wastewater treatment Caste study Heavy metals Biological wastewater treatment Treatment Methods employed Biological
More informationAdvanced Treatment by Membrane Processes
Advanced Treatment by Membrane Processes presented by Department of Hydraulic and Environmental Engineering 1 Fundamentals of membrane technology Definition: A membrane is a permselective barrier, or interface
More informationRecycling of Food Processing Wastewater to Potable Water Standards
Recycling of Food Processing Wastewater to Potable Water Standards The issues surrounding wastewater recycling in the food and drinks sector are generally well known. Over the past ten years a UK owned
More informationContainerized Ultrafiltration (UF) Water Treatment Plant
Containerized Ultrafiltration (UF) Water Treatment Plant Small UF System Containerized UF Water Treatment Plant This UF containerized water treatment plant can be used to treat water from a variety of
More informationWater Solutions for the Power Industry
GE Power & Water (Water & Process Technologies) Water Solutions for the Power Industry Conference on Water Conservation in Power Plants June 2013, New Delhi Agenda Effluent reuse for Power Plants MBR Technology
More informationUnit Treatment Processes in Water and Wastewater Engineering
Unit Treatment Processes in Water and Wastewater Engineering T J Casey AQUAVARRA RESEARCH LIMITED 22A Brookfield Avenue Blackrock Co. Dublin. October 2006 Author s Note Water and wastewater treatment technology
More informationBiothane Anaerobic Technology Memthane 2.0 WATER TECHNOLOGIES
Biothane Anaerobic Technology Memthane 2.0 WATER TECHNOLOGIES State-of-the-art solution Memthane is an Anaerobic Membrane Bio-Reactor (AnMBR) which maximizes renewable energy production while producing
More informationCLEANING UP GANGA RIVER HOW EASY IS IT?
CLEANING UP GANGA RIVER HOW EASY IS IT? WWW.GANGAACTION.ORG PREPARED BY KIRAN PANDYA TECHNICAL CONSULTANT WATER TREATMENT PROJECTS GANGA ACTION PARIVAR For questions email: pandyaken@gmail.com Introduction
More informationNANO FILTERING SYSTEM
NANO FILTERING SYSTEM Membrane technology The nano filtration technique is mainly used for the removal of two valued ions and the larger mono valued ions such as heavy metals. This technique can be seen
More informationFLAGSHIP DHAKA CETP (BD) LTD DHAKA EXPORT PROCESSING ZONE CENTRAL ETP
FLAGSHIP DHAKA CETP (BD) LTD DHAKA EXPORT PROCESSING ZONE CENTRAL ETP ECC ENHANCEMENT FROM 21,000M3/DAY DEPARTMENT OF ENVIRONMENT 2017 o 1 ST FOREIGN OWNED & OPERATED CETP UNDER PMO o PROVIDES FOREIGN
More informationStandard Water Treatment Equipment Solutions WATER TECHNOLOGIES
Standard Water Treatment Equipment Solutions WATER TECHNOLOGIES Innovative Standard Product Line Veolia Water Technologies, a leading provider of integrated water solutions for industrial and commercial
More informationPacific States Water, Inc. Solution for the Treatment and Recovery of Oil & Gas Produced Water
Pacific States Water, Inc. Solution for the Treatment and Recovery of Oil & Gas Produced Water The safe and sustainable treatment of its processed water remains a priority for the Oil & Gas industry. Increased
More informationZero Discharge Treatment Method for Cooling Towers and Heat Exchangers with SP3, I-SOFT-OB, OXYDES & KATALOX LIGHT
Zero Discharge Treatment Method for Cooling Towers and Heat Exchangers with SP3, I-SOFT-OB, OXYDES & KATALOX LIGHT By Deepak Chopra Watch Water GmbH Fahrlachstraße 14 68165 Mannheim Germany May 2013 Web:
More informationAbout Us. Envisol A part of Arvind Limited
About Us Envisol A part of Arvind Limited Our Business is Water Arvind Limited, a part of The $1.3 billion Lalbhai Group was incorporated in 1931 and is in the businesses of Textiles fabric & garment manufacturing,
More informationWastewater treatment objecives
Wastewater treatment objecives Removal of suspended and floatable materials Degradation of biodegradable organics Removal of nutrients Elimination of priority pollutants Elimination of pathogenic organisms
More informationTurbo4bio System For the Treatment of Sewage & Organic Effluents
Turbo4bio System For the Treatment of Sewage & Organic Effluents Dr.Hans. H.Badreddine President Turbo4bio Page 1 Executive Summary The Turbo4bio system has been patented in the UK and Europe by Hans Bioshaft
More informationSLOP / VINASSE CONCENTRATION AND INCINERATION
SLOP / VINASSE CONCENTRATION AND INCINERATION PRESENT STATUS OF TECHNOLOGY AVANT-GARDE Vinasse Fermented Wash from which the Ethanol and other Volatile Hydro Carbons have been removed in the Stripper Column
More informationDR. SANJAY V. PATIL HEAD AND TECHNICAL ADVISER DEPARTMENT OF ALCOHOL TECHNOLOGY VASANTDADA SUGAR INSTITUTE, MANJARI, PUNE (INDIA)
DR. SANJAY V. PATIL HEAD AND TECHNICAL ADVISER DEPARTMENT OF ALCOHOL TECHNOLOGY VASANTDADA SUGAR INSTITUTE, MANJARI, PUNE (INDIA) Email: sv.patil@vsisugar.org.in AIDA Technical Seminar www.vsisugar.com
More informationWater and Wastewater Engineering Dr. Ligy Philip Department of Civil Engineering Indian Institute of Technology, Madras
Water and Wastewater Engineering Dr. Ligy Philip Department of Civil Engineering Indian Institute of Technology, Madras Advanced Wastewater Treatment Lecture # 33 Last class we were discussing about various
More informationFPO. Food and Beverage
FPO SUSTAINABLE APPLICATIONS WATER AND SUSTAINABLE SOLUTIONS FOR WATER THESOLUTIONS FOR Food and Beverage Market Let s Solve Water For over a century, Xylem s well-known global brands have served the water
More informationAddressing increasing wastewater volumes in industrial and oil & gas operations using thermal systems
Water Arabia 2013 Conference & Exhibition Innovative Water and Wastewater Technologies for a Sustainable Environment 4 to 6 February, 2013 Le Meridien Khobar, Saudi Arabia Addressing increasing wastewater
More informationTreatment of saline streams: removal of precipitable salts Case study Denieul M.-P., Mauchauffee S., Le Calvez G., De Laval A., Coste M.
Treatment of saline streams: removal of precipitable salts Case study Denieul M.-P., Mauchauffee S., Le Calvez G., De Laval A., Coste M. Veolia Environnement Recherche & Innovation 16/07/2012) Veolia Environnement
More information