USNA Chemistry Department CORROSION LECTURE. USNA Chemistry Dept.
|
|
- Debra Pierce
- 6 years ago
- Views:
Transcription
1 USNA Chemistry Department CORROSION LECTURE
2 Corrosion
3 Why is Corrosion Important? Corrosion is the destructive attack of a metal due to an ELECTROCHEMICAL reaction. Attack of Elements on Structural Metals Financial - $350 Billion Dollar Annual Problem (4.25% of GNP) Department of Defense spends $6 8 Billion Your future Military career USMC USN
4 DoD Strategic Refueling Airframe Circa 1960 Circa 2040
5 General Corrosion Anodic Reaction: Fe 0 (s) Fe 2+ (aq) + 2e - Deterioration of metal Cathodic Reaction: 2H + (aq) + 2e - H 2 O (l) Chemical O 2 (g) + 2H 2 O (l) + 4e - 4OH - (aq) Atmospheric Overall Reaction: Fe 0 (s) + 2H + (aq) Fe 2+ (aq) + H 2 O (l) Chemical 2Fe 0 (s) + O 2 (g) + 2H 2 O (l) 2Fe 2+ (aq) + 4OH - (aq) Atmospheric
6 Activity Series Reduction Half Reactions E 0 (V) Au 3+ (aq) + 3e - Au (s) Ag + (aq) + e - Ag (s) O 2 (g) + 2H 2 O +4e - 4OH - (aq) Cu 2+ (aq) + 2e - Cu (s) H + (aq) + 2e - H 2 (g) 0.00 Sn 2+ (aq) + 2e - Sn (s) Fe 2+ (aq) +2e - Fe (s) Zn 2+ (aq) + 2e - Zn (s) Al 3+ (aq) + 3e - Al (s) Mg 2+ (aq) + 2e - Mg (s) -2.37
7 Corrosion to a Ship s Hull O 2 Hull of ship O 2 + 2H 2 O + 4e - 4OH - Fe OH - Fe(OH) 2 OH - Cathodic Region RUST Fe(OH) 2 + xh 2 O Fe 2 O 3 xh 2 O e - Anodic Region Fe 2+ Fe Fe e - Electrons Migrate from Anodic to Cathodic Region
8 Factors of General Corrosion 1. ph 2. Type of Metal Rate of Cathode Reaction ph 3. Temperature 4. Oxygen Content
9 Localized Corrosion Problems Galvanic Electrical contact of dissimilar metals underwater accelerate anode corrosion and decelerates cathode corrosion Exfoliation Active metal behind surface causes corrosive products Stress Ex. B-52 wing bend Corrosion due to accelerated oxidation to metals that are subjected to strain Pitting and Crevice Atoms too far Atoms too close Primary cause of Boiler Explosion Metal Corrosion at specific sites (low flow area) Less Active Metals Pitting Anodic Region Corrosion More Active Metals Bent Metal Water Flow Crevice
10 Galvanic Corrosion Electrical contact of dissimilar metals underwater accelerate anode corrosion and decelerates cathode corrosion
11 Galvanic Corrosion Active metal behind surface causes corrosive products
12 Stress Corrosion Corrosion due to accelerated oxidation to metals that are subjected to strain
13 Pitting and Crevice Primary cause of Boiler Explosion. Metal Corrosion at specific sites (low flow area) Pitting Corrosion Crevice Corrosion
14 Pitting Corrosion Horizontal grain attack Vertical grain attack Narrow, deep Subsurface Shallow, wide Undercutting Elliptical
15 Prevention of Corrosion Separate reactants with coatings Paint, grease, oils, and polymers Coat with less active metals (tin cans, noble metals) Exclude Water Exclude Oxygen O 2 Self Protective Coatings Aluminum Al 2 O 3 Magnetite Fe 3 O 4 Stainless Steel Cr oxides
16 Galvanic Protection Galvanized Steel Zinc coating Sacrificial Anodes Ship Hulls Subs (free flooding areas) Los Angeles Class Sub Arleigh-Burke Destroyer
17 Impressed Current Cathodic Protection Shipboard Power Shipboard Power Paint Layer Controller Reference Electrode Power Supply e - e - Hull Pt Anode Insulation
18 Real world application e + - -
19 Real World Examples Aloha Flight 243 (28 APR 1988) Flight 243 was a series of Hawaiian inter-island flights. First class cabin walls and ceiling were ripped from the airplane. Multiple site damage around (row 5) Corrosion of the metallic interior frame of the Boeing 737 (Stress Corrosion)
20 Nuclear Reactor Vessel Head Degradation February 16, 2002, Davis-Besse Nuclear Power Station in Oak Harbor, Ohio Boric Acid leak from control rod drive mechanism led to chemical corrosion of reactor vessel head Serious potential for loss of reactor coolant access
21 Corrosion of Aircraft Skin Corrosion on wing of Navy aircraft F/A-18C Hornet Because of the adverse environments Naval and Marine Aircraft operate in, corrosion of all materials is a major problem that experts are actively combating
22 Various Forms of Corrosion in High Strength Aluminum Alloy Structures Localized corrosion: Pits, Crevices, IGC, Exfoliation, Filiform Al-Cu-Mg Al-Cu-(Fe,Mn) Aluminum 2024-T3 4% Cu Topcoat Primer Oxide Coating Perpendicular cross section of corroded area from lap joint in KC-135
23 Steel Fasteners on the Wing of a KC-135 Results in Severe Corrosion of Al Alloy Fe 2+ (aq) + 2e- Fe (s) E = V vs. Al 3+ (aq) + 3e- Al (s) E = V O 2 (g) + 2H 2 O + 4e- 4OH- (aq) E = 0.40 V 4Al (s) + 3O 2 (g) + 6H 2 O 4Al 3+ (aq) + 12OH- (aq) E = 2.06 V!
24 New Mg-Rich Primers* Nano-science to the Rescue! New Mg ( mm) powders with robust nano-scale oxide coating* No Corrosion in Scratch! Aircraft Aluminum Alloy Mg 2+ (aq) + 2e- Mg (s) E = V vs. Mg powder in Primer O 2 (g) + 2H 2 O + 4e- 4OH- (aq) E = 0.40 V Al 3+ (aq) + 3e- Al (s) E = V 2Mg (s) + O 2 (g) + 2H 2 O 2Mg 2+ (aq) + 6OH- (aq) E = 2.77 V! *currently under testing. Potential for application on JSF
25 Tips for Reducing Corrosion Keep the Ship/Sub/Aircraft Clean Allows for detection of corrosion in early stages Lengthens service life of finished surfaces Reduction of all types of corrosion types by eliminating the electrical path (no dirt, no electrolyte, no corrosion) Keep the bilges dry Removal of electrolyte reduces the rate of all major corrosion types Keep on top of the rust Properly prepared surfaces last longer If a fastener is corroding in place, probably due to dissimilar metal corrosion
26 Questions
APPLICATIONS OF ELECTROCHEMISTRY
APPLICATIONS OF ELECTROCHEMISTRY SPONTANEOUS REDOX REACTIONS APPLICATIONS OF ELECTROCHEMICAL CELLS BATTERIES A galvanic cell, or series of combined galvanic cells, that can be used as a source of direct
More informationMethods of Corrosion Control. Corrosion Control or Corrosion Management?
Corrosion Control or Corrosion Management? Corrosion control is a process aimed at reducing the corrosion rate to a tolerable level (or predictable limits) Corrosion control focuses mainly on (i) materials
More informationModule-13. Corrosion and Degradation of materials
Module-13 Corrosion and Degradation of materials Contents 1) Corrosion of metals 2) Corrosion of ceramics 3) Degradation of polymers Deterioration of materials Conventional engineering materials are not
More informationGalvanic and Stray Current Corrosion
Chapter 5 Galvanic and Stray Current Corrosion MElec-Ch5-1 Overview Galvanic Corrosion Understanding Galvanic Corrosion Controlling Galvanic Corrosion Stray Current Corrosion Understanding Stray Current
More informationPROF. DR. M.M. B. EL SABBAH AL-AZHAR UNIVERSITY FACULTY OF SCIENCE CHEMISTRY DEPARTMENT
PROF. DR. M.M. B. EL SABBAH AL-AZHAR UNIVERSITY FACULTY OF SCIENCE CHEMISTRY DEPARTMENT 2016 PRINCIPLES OF CORROSION ELECTROCHEMICAL AND THERMODYNAMIC PRINCIPLES OF CORROSION Content 1. Definition of corrosion.
More informationNAVSEA Basic Paint Inspector Training: Introduction. l Certified paint inspector duties. l Formal inspection responsibilities. l Course objectives
NAVSEA Basic Paint Inspector Training: Introduction Introduction Topics NAVSEA Basic Paint Inspector Course (NBPI) l Certified paint inspector duties l Formal inspection responsibilities l Course objectives
More informationPrevention Strategies Design and Coatings
Lecture 14 Prevention Strategies Design and Coatings Keywords: Corrosion Prevention, Designs, Protective Coatings. There are a number of methods to control corrosion. The choice of any one control technique
More informationTWEED RIVER HIGH SCHOOL 2006 PRELIMINARY CHEMISTRY. Unit 2 Metals
TWEED RIVER HIGH SCHOOL 2006 PRELIMINARY CHEMISTRY Unit 2 Metals Part 2 Metals differ in their reactivity with other chemicals and this influences their uses. Describe observable changes when metals react
More informationMetropolitan Water Reclamation District of Greater Chicago 10/19/ Mark Joyce Senior Mechanical Engineer Engineering Department
Metropolitan Water Reclamation District of Greater Chicago 10/19/201 2 Mark Joyce Senior Mechanical Engineer Engineering Department 1 Definition of Corrosion Corrosion is the deterioration of a substance
More informationWhy Does Rust Occur? 7.1 IN GENERAL
Why Does Rust Occur? 7.1 IN GENERAL Rust damage on products costs large sums every year, and can also cause breakdowns through various kinds of corrosion weakening supporting structures. There are therefore
More informationCorrosion Control and Cathodic Protection Data Sheet
Data Sheet CORROSION CONTROL Corrosion control is the application of engineering principles and procedures to minimise corrosion to an acceptable level by the most economical method. It is rarely practical
More informationFundamentals of Corrosion and Corrosion Control for Civil and Structural Engineers
Fundamentals of Corrosion and Corrosion Control for Civil and Structural Engineers Thomas Sputo, Ph.D., P.E., S.E., SECB Corrosion of a Coated Handrail Corroded Rain Gutter Corrosion on the Nose of the
More informationGalvanic Corrosion Prevention Guide for Water Cooling Systems
WATER COOLED DEVICES Galvanic Corrosion Prevention Guide for Water Cooling Systems November 2017 White Paper Created by Helen E. Kane, Advanced Energy Industries, Inc. Water Cooled Devices Abstract This
More informationa: potential difference before direct current is applied b: potential difference after the application of current
CATHODIC PROTECTION Cathodic protection is a proven corrosion control method for protection of underground and undersea metallic structures, such as oil and gas pipelines, cables, utility lines and structural
More informationIntergranular Corrosion (IGC)
Intergranular Corrosion (IGC) Microstructure of metals and alloys is made up of grains (separated by grain boundaries) Intergranular corrosion is a localized attack along the grain boundaries, or immediately
More informationElectrochemical Considerations
17-1 CHAPTER 17 CORROSION AND DEGRADATION OF MATERIALS PROBLEM SOLUTIONS Electrochemical Considerations 17.1 (a) Oxidation is the process by which an atom gives up an electron (or electrons) to become
More informationDevelopment of Accelerated Corrosion Test Method
Development of Accelerated Corrosion Test Method James F. Dante ASETS Defense 12/7/2016 WP-1673: Accelerated Dynamic Corrosion Test Method Development Performers: SwRI, Luna, Boeing, Alcoa, UVA, NAVSEA,
More informationSelect adequate material of construction
NEWSLETTER March 2011 Select adequate material of construction Corrosion is recognized as one of the most serious problems in our modern societies and the resulting losses each year are in the hundreds
More informationDistribution Review. Corrosion Control. Corrosion Control Vocabulary. American Water College 1. Corrosion Control Training Objectives
Distribution Review Corrosion Control Corrosion Control Training Objectives To gain an understanding of: Corrosion control vocabulary The factors affecting corrosion Methods used to control corrosion Alkalinity
More informationCathodic Protection for Steel Water Storage Tanks Pocket Field Guide. David H. Kroon, P.E.
Cathodic Protection for Steel Water Storage Tanks Pocket Field Guide David H. Kroon, P.E. Copyright 2017 American Water Works Association All rights reserved. No part of this publication may be reproduced
More information5072 CHEMISTRY (NEW PAPERS WITH SPA) TOPIC 9: METALS 5067 CHEMISTRY (NEW PAPERS WITH PRACTICAL EXAM) TOPIC 9: METALS
5072 CHEMISTRY (NEW PAPERS WITH SPA) TOPIC 9: METALS 5067 CHEMISTRY (NEW PAPERS WITH PRACTICAL EXAM) TOPIC 9: METALS SUB-TOPIC 9.3 TO 5 EXTRACTION OF METALS; RECYLING OF METALS; IRON LEARNING OUTCOMES
More informationMarine Corrosion and its Prevention in Small Vessels
Marine Corrosion and its Prevention in Small Vessels Contents: i) Corrosion: Fundamental Principles ii) Forms of corrosion in marine metals iii) Corrosion above the waterline iv) Corrosion below the waterline
More informationRivet nut fully installed
Environment Rules Joint Design, by Adam Pratt Over seven decades ago rivet nuts were invented for airplane wing attachment points. Since then, the need for reliable threads in thin materials has dramatically
More informationSACRIFICIAL ANODE CATHODIC PROTECTION OF LOW CARBON STEEL IN SEA WATER
Volume 13 September 007 SACRIFICIAL ANODE CATHODIC PROTECTION OF LOW CARBON STEEL IN SEA WATER Dr. Aprael S. Yaro Dr. Khalid W. Hameed University of Baghdad / College of Engineering ABSTRACT Cathodic protection
More informationMECHANICAL TUBE DIVISION
MECHANICAL TUBE DIVISION GALVANIZING Why Galvanize? PROTECTS THE STEEL Galvanizing (zinc coating) has been used to protect iron and steel from rusting for over one hundred years. Galvanizing protects steel
More informationDevelopment and Application of Corrosion Control
Development and Application of Corrosion Control The Marine Environment World trade has always relied upon the sea We have a long history of maritime activity Large coastlines have proved good for trade,
More informationUNIT-III CORROSION CORROSION
CORROSION Syllabus: Causes and effects of corrosion theories of corrosion (dry/chemical and electrochemical corrosion) Factors effecting corrosion Corrosion control methods Cathode protection Sacrificial
More informationBuried Pipe Corrosion in the Power Plant Environment
Buried Pipe Corrosion in the Power Plant Environment Assessment and Mitigation in Nuclear Power Plants IAEA Technical Meeting on Buried Pipe October 15, 2014 Kurt M. Lawson Mears Group, Inc. Topics Background
More informationUnit 5 Review Electrolytic, Electrochemical Cells, Corrosion, & Cathodic Protection
Unit 5 Review Electrolytic, Electrochemical Cells, Corrosion, & Cathodic Protection Determine the half reactions for each cell and the cell voltage or minimum theoretical voltage. 1. Zn / Mg electrochemical
More informationMarine Galvanic Corrosion Made Easy. Brought to you by Marine Protection Systems Pty Ltd
Marine Galvanic Corrosion Made Easy. Brought to you by Marine Protection Systems Pty Ltd Introduction Made possible by the generous invitation and support of Sandringham Yacht Club Presented and Supported
More informationCorrosion Protection for Concrete Structures in Marine Environments. D.B.McDonald, Ph.D., P.E, FACI
Corrosion Protection for Concrete Structures in Marine Environments D.B.McDonald, Ph.D., P.E, FACI $182.3 billion Koch, Brongers et al. 2001 http://www.fyfeco.com/images/projects/nassco-pier.jpg ELECTRICAL
More informationAn Introduction to Cathodic Protection Principles
An Introduction to Cathodic Protection Principles Course No: E05-006 Credit: 5 PDH J. Paul Guyer, P.E., R.A., Fellow ASCE, Fellow AEI Continuing Education and Development, Inc. 9 Greyridge Farm Court Stony
More informationCathodic Protection as a Corrosion Control Alternative
Cathodic Protection as a Corrosion Control Alternative By William T. Scannell and Ali Sohanghpurwala Corrosion of reinforcing steel in concrete is a widespread and enormously costly problem in all parts
More informationMETALS AND THEIR COMPOUNDS
METALS AND THEIR COMPOUNDS Metals are elements whose atoms ionize by electron loss, while non-metals are elements whose atoms ionize by electron gain. Metals are in groups 1, 2 and 3 of the periodic table.
More informationSolutions. for Severe Corrosion
Solutions for Severe Corrosion Linas Mazeika, President, 3L&T Inc., USA, reveals how to prevent equipment corrosion caused by hot combustion gases in a cement plant. Summary The serious economic consequences
More informationCorrosion Rate Measurement on C-Steel
Measurements of corrosion rate on Carbon-steel using Electrochemical (potentiodynamic Polarization, EIS etc.) technique. Corrosion Rate Measurement on C-Steel Abdullah Al Ashraf 1. Introduction: The degradation
More informationOxidation and Reduction
Oxidation and Reduction An oxidation reaction is one in which oxygen is added to a substance. Example: Methane is oxidised when it burns in air. Oxygen is added to the carbon in methane, forming carbon
More informationCorrosion Issues & Test Methods. Jerry Byers
Corrosion Issues & Test Methods Jerry Byers Cost of Corrosion to US Industries Corrosion is the deterioration of a material (often a metal) due to interaction with its environment. A study in 1998 estimated
More informationDEFINITION OF METAL CORROSION.
DEFINITION OF METAL CORROSION. Metal Corrosion can be defined as the destructive attack of a metal through interaction with its environment. DRIVING FORCE FOR CORROSION. Most metals used in the construction
More informationVALVES. Hank Litchfield, Regional Director of Commercial/Industrial Product Sales, Nibco Inc., Houston, Texas Zinc, the metallic element popular
Zinc Too much of a good thing results in return of an old problem: dezincification Hank Litchfield, Regional Director of Commercial/Industrial Product Sales, Nibco Inc., Houston, Texas Zinc, the metallic
More informationA. Access doors and frames are part of an access door and frame allowance.
SECTION 08 31 13 ACCESS DOORS AND FRAMES PART 1 GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01 Specification
More informationITW ROCOL METAL ENRICHED PAINTS
ITW ROCOL METAL ENRICHED PAINTS The differences between standard paints and ROCOL Metal Enriched Paints are significant. Standard paints create a passive barrier, which when breached will offer no protection
More informationU.S. General Services Administration Historic Preservation Technical Procedures. Galvanized Iron And Steel: Characteristics, Uses And Problems
U.S. General Services Administration Historic Preservation Technical Procedures Galvanized Iron And Steel: Characteristics, Uses And Problems 05010-09 GALVANIZED IRON AND STEEL: CHARACTERISTICS, USES AND
More informationNathan Kofira Technical Development Manager
Nathan Kofira Technical Development Manager Overview 1 2 3 Types of Corrosion in Coatings Mechanisms of Corrosion Corrosion Inhibitor Selection 4 Formulating with Anti-Corrosives 5 Temporary Rust Prevention
More informationSome chemistry of Iron
1 of 7 21/11/2006 04:05 PM Some chemistry of Iron History For some background information on the origin and history of Iron see the Rossell Forge Site in Andorra Introduction Iron is the most abundant
More information(a) To find out which is the more reactive metal, zinc or tin, the following experiment could be carried out. piece of zinc shiny surface
1 The reactivity series lists metals in order of reactivity. (a) To find out which is the more reactive metal, zinc or tin, the following experiment could be carried out. piece of zinc shiny surface tin(ii)
More information5th Pan American Conference for NDT 2-6 October 2011, Cancun, Mexico. Detecting Corrosion in Metal Elements of Ammunition by IR Thermography Methods
Detecting Corrosion in Metal Elements of Ammunition by IR Thermography Methods Waldemar SWIDERSKI Military Institute of Armament Technology; Zielonka, Poland Phone: +48 22 7614552, Fax: +48 22 7614447;
More informationThe effect of electroplating of Cr and Sn on corrosion resistance of low carbon steel (CK15)
AMERICAN JOURNAL OF SCIENTIFIC AND INDUSTRIAL RESEARCH 2010, Science Huβ, http://www.scihub.org/ajsir ISSN: 2153-649X doi:10.5251/ajsir.2010.1.3.565.572 The effect of electroplating of Cr and Sn on corrosion
More informationLaboratory Experiments in Corrosion Engineering II
Lecture - 40 Laboratory Experiments in Corrosion Engineering II Keywords: Polarization Experiments, Pitting Potentials, Microbial Corrosion. A. Electrochemical tests in a given environment Polarization
More informationEvaluation of Zn-rich Primers and Rust Converters for Corrosion Protection of Steel Leonardo Caseres
Evaluation of Zn-rich Primers and Rust Converters for Corrosion Protection of Steel Leonardo Caseres Southwest Research Institute Report Documentation Page Form Approved OMB No. 0704-0188 Public reporting
More informationLocalized Corrosion of a 7075 Aluminum Alloy Exposed to KCl
Localized Corrosion of a 7075 Aluminum Alloy Exposed to KCl Christopher F. Mallinson Department of Mechanical Engineering Sciences The Surface Analysis Laboratory Monday, 20 April 2015 1 Outline Introduction
More informationAvailable online at ScienceDirect. Procedia Engineering 184 (2017 )
Available online at www.sciencedirect.com ScienceDirect Procedia Engineering 184 (2017 ) 418 422 Advances in Material & Processing Technologies Conference Development of Al-Zn-Cu Alloy for Low Voltage
More informationNovel Corrosion Control Coating Utilizing Carbon Nanotechnology
Novel Corrosion Control Coating Utilizing Carbon Nanotechnology Susan A. Drozdz U.S. Army Engineer Research and Development Center Todd Hawkins Tesla NanoCoatings Limited Report Documentation Page Form
More information1. Scaling. H.O.: H-5/21, KRISHNA NAGAR, DELHI Tel.: , Fax:
Boiler Water Problems and Its Causes Water is the essential medium for steam generation. Conditioning it properly can increase the efficiency of boiler and as well as extend the boiler s life. Treating
More informationElectricity and Chemistry
Electricity and Chemistry Electrochemistry: It is a branch of chemistry that deals with the reactions involving the conversion of chemical energy into electrical energy and vice-versa. Electrochemical
More informationRPR Insul-Mate Sheet and Roll Jacketing
RPR Insul-Mate Sheet and Roll Jacketing ALUMINUM PRODUCTS Rolled Jacketing Sheeting (Flat and Corrugated) Cut to Length Cut & Rolled Width/Length: 36 and 48 wide 100, 50 and cut to length (thicker gauges
More informationMATERIALS I LECTURE COURSE 2 PROPERTIES OF MATERIALS
MATERIALS I LECTURE COURSE 2 PROPERTIES OF MATERIALS Approach from the point of view of the user: Properties mechanical physical chemical technological MECHANICAL PROPERTIES Characterize the reaction of
More informationMaterials Issues Related to Reactor Design, Operation & Safety
Materials Issues Related to Reactor Design, Operation & Safety Professor R. G. Ballinger Department of Nuclear Engineering Department of Materials Science & Engineering 22.39 Lecture 1-1 Objective To Develop
More informationMore than just a Zinc Phosphate. Zinc Phosphate ZP 10
More than just a Zinc Phosphate Zinc Orthophosphate Hydrate Corrosion can be inhibited by chemical and/or electrochemical (Active Pigments) or physical (Barrier Pigments) processes of anticorrosive pigments.
More information85 Q.51 Which of the following carbonates would give the metal when heated with carbon? (1) MgCO 3 (2) PbCO 3 (3) K 2 CO 3 (4) CuCO 3
Metal and metal reactivity / Section 2 / Sect2pp.doc / S. W. Tse / P.1 85 Q.51 Which of the following carbonates would give the metal when heated with carbon? (1) MgCO 3 (2) PbCO 3 (3) K 2 CO 3 (4) CuCO
More informationEvaluation of Dipsol IZ-C17 LHE Zinc-Nickel Plating
Evaluation of Dipsol IZ-C17 LHE Zinc-Nickel Plating By: Stephen Gaydos Boeing St. Louis for HCAT/JCAT Meeting January 24, 2007 1 Report Documentation Page Form Approved OMB No. 0704-0188 Public reporting
More informationUNIFIED FACILITIES CRITERIA (UFC) DESIGN: ELECTRICAL ENGINEERING CATHODIC PROTECTION
UFC 3-570-02N 16 January 2004 UNIFIED FACILITIES CRITERIA (UFC) DESIGN: ELECTRICAL ENGINEERING CATHODIC PROTECTION APPROVED FOR PUBLIC RELEASE; DISTRIBUTION UNLIMITED UFC 3-570-02N 16 January 2004 UNIFIED
More informationCorrosion in Through-Hull Fittings and seacock valves in yachts and boats
Corrosion in Through-Hull Fittings and seacock valves in yachts and boats By M.Sc. Eng, Naval architect and corrosion specialist Piet Jansen Fortunately, incidents of sudden ingress of seawater into pleasure
More informationEffect of Anodization on the corrosion behavior of Aluminium Alloy in HCl acid and NaOH
International Journal of Materials Engineering 212, 2(4): 38-42 DOI: 1.5923/j.ijme.21224.2 Effect of Anodization on the corrosion behavior of Aluminium Alloy in HCl acid and NaOH Madakson P. B, Malik I.
More informationAluminium Alloys for Hull Construction and Marine Structure
(May 1998) (Rev.1 May 2004) (Rev.2 Dec 2004) (Rev.3 May 2006) (Rev.4 Dec 2011) (Rev.5 June 2014) Aluminium Alloys for Hull Construction and Marine Structure TABLE OF CONTENTS 1. Scope 2. Approval 3. Aluminium
More informationCLEANING AND CORROSION CONTROL VOLUME I CORROSION PROGRAM AND CORROSION THEORY
NAVAIR 01-1A-509-1 TECHNICAL MANUAL CLEANING AND CORROSION CONTROL VOLUME I CORROSION PROGRAM AND CORROSION THEORY This publication supersedes NAVAIR 01-1A-509/TM 1-1500-344-23, dated 1 May 2001 and NAVAIR
More informationCONCRETE STEPS, HANDRAILS, AND SAFETY RAIL
SUDAS Standard Specifications Division 9 - Site Work and Landscaping Section 9080 - Concrete Steps, Handrails, and Safety Rail CONCRETE STEPS, HANDRAILS, AND SAFETY RAIL PART - GENERAL.0 SECTION INCLUDES
More informationPreferred. Steel, Epoxy Powder Coated. Satisfactory. Limited
Corrosion Resistance We manufactures enclosures from a wide range of materials, offering varying degrees of resistance against chemical corrosion. All materials are affected by corrosion in some manner.
More informationAn Inexpensive Corrosion Laboratory Experiment - Suitable for All Ages.
An Inexpensive Corrosion Laboratory Experiment - Suitable for All Ages. John R. Williams Purdue University Statewide Technology Kokomo, IN 46904-9003 Abstract One of the most obvious effects of corrosion
More informationIntroduction. Jeremy Hailey, P.E.
Introduction Jeremy Hailey, P.E. Engineer with 16 years experience Started NW 10 years ago Focus on corrosion control system designs, troubleshooting, and some installation work Conduct training seminars
More informationThe Selection of Magnesium alloys as Sacrificial Anode for the Cathodic Protection of Underground Steel Structure
The Selection of Magnesium alloys as Sacrificial Anode for the Cathodic Protection of Underground Steel Structure Sundjono 1, Gadang Priyotomo 2, Lutviasari Nuraini 3 Researchers, Research Center for Metallurgy
More informationThe Basics of Dezincification
The Basics of Dezincification Larry Muller Director, Metallurgy and Technical Services Chase Brass and Copper Company, LLC. Montpelier, OH 1 Presentation Summary This presentation is not to be copied or
More information3 The Formation, Mining, and Use of Minerals
CHAPTER 3 3 The Formation, Mining, and Use of Minerals SECTION Minerals of the Earth s Crust BEFORE YOU READ After you read this section, you should be able to answer these questions: How do minerals form?
More informationCORROSION BEHAVIOR OF TITANIUM METAL IN PRESENCE OF INHIBITED SULFURIC ACID AT 50 o C 1
CORROSION BEHAVIOR OF TITANIUM METAL IN PRESENCE OF INHIBITED SULFURIC ACID AT 50 o C 1 Ismaeel N. Andijani, Shahreer Ahmad and Anees U. Malik Research & Development Center Saline Water Conversion Corporation
More informationCORROSION PHENOMENA AN INTRODUCTION G P Rothwell
CORROSION PHENOMENA AN INTRODUCTION G P Rothwell The objective of this talk is to provide broad-brush comments on a wide range of corrosion phenomena in order to provide a measure of common ground for
More informationCorrosion, Coatings and Hydropower
Corrosion, Coatings and Hydropower Steve Reiber, Ph.D. sreiber@hdrinc.com The Pat Tillman Bridge: Under Construction 2009 Completed 2011 Acknowledgements Materials kindly supplied by: Society for Protective
More informationGalfan - Low Cost, High Performance Metallic Coating
Galfan - Low Cost, High Performance Metallic Coating David Harrison, Bronx International, Australia. Introduction Bronx International provides Coil Coating Line solutions to steel and aluminium companies,
More informationCHAPTER I 1.0 INTRODUCTION
CHAPTER I 3 1.0 INTRODUCTION 1.1. The Nature of Matter [1] All matter is made of atoms composed of protons, neutrons, and electrons. The center, or nucleus, of the atom is composed of positively charge
More informationAluminium as a viable solution for offshore wind turbines. Dr. Simon Jupp Deep Sea Offshore Wind R&D Seminar, 20. January 2011
Aluminium as a viable solution for offshore wind turbines Dr. Simon Jupp Deep Sea Offshore Wind R&D Seminar, 20. January 2011 (1) 18 January 2011 Climate strategy intro? Hydro s mission to create a more
More informationCorrosion Characteristics And Mechanical Properties Of Aluminum Coatings Applied By The Cold Spray Process
Bucknell University Bucknell Digital Commons Master s Theses Student Theses 2011 Corrosion Characteristics And Mechanical Properties Of Aluminum Coatings Applied By The Cold Spray Process Ben Bouffard
More informationGalvanic corrosion evaluation of 6061 aluminum coupled to CVD coated stainless steel Elizabeth Sikora and Barbara Shaw 6/9/2016
SHAW AND ASSOCIATES CONSULTING Galvanic corrosion evaluation of 6061 aluminum coupled to CVD coated stainless steel Elizabeth Sikora and Barbara Shaw 6/9/2016 Evaluation of galvanic corrosion of aluminum
More informationOffshore Wind Turbines Power Electronics Design and Reliability Research
Offshore Wind Turbines Power Electronics Design and Reliability Research F. P. McCluskey CALCE/Dept. Of Mechanical Engineering University of Maryland, College Park, MD (301) 405-0279 mcclupa@umd.edu 1
More informationMATERIALS SCIENCE-44 Which point on the stress-strain curve shown gives the ultimate stress?
MATERIALS SCIENCE 43 Which of the following statements is FALSE? (A) The surface energy of a liquid tends toward a minimum. (B) The surface energy is the work required to create a unit area of additional
More informationCORROSION PROTECTION INDEX
CORROSION PROTECTION 71862 7 Table of Contents Page Specifications............................... 7-1 Special Tools............................ 7-1 Lubricants, Sealers, and Adhesives......... 7-1 Wiring
More informationThe Effect of Preparation and Cleaning Techniques on Electrochemical Testing of Aluminium Anodes
The Effect of Preparation and Cleaning Techniques on Electrochemical Testing of Aluminium Anodes B Linde and R Northey Cathodic Diecasting, Australia SUMMARY: When comparing the preparation and cleaning
More informationWASA Technical Paper «... w*~ December 1983
WASA Technical Paper 2236 December 1983 «... w*~ Galvanic Coupling Between D6AC Steel, 6061-T6 Aluniinum 5 Inconel 718 9 and Graphite- Epoxy Composite Material: Corrosion Occurrence and Prevention Merlin
More informationPerformance Attributes of Organic Corrosion Inhibitors
Performance Attributes of Organic Corrosion Inhibitors Additives 2012 Conference September 12-13, 2012 Sheraton Inner Harbor Baltimore, MD Nathan Kofira Technical Development Manager Overview 1 2 3 Requirements
More informationCorrosion Considerations PP C
Corrosion Considerations Objectives Rust Protection Methods Paint Standards Chemical Corrosion Stainless Steel Protective Coatings Interior Protection Metal Corrosion, Rust Corrosion presents a major threat
More informationCondensed Study Guide
192-0401 Corrosion Reactions This module will discuss a variety of corrosion types. Each type involves either a chemical reaction or an electrochemical reaction. Chemical Reaction Chemicals in the environment
More informationBallast Water Tanks Repair Guide for Crew
January 2011 Ballast Water Tanks Repair Guide for Crew This brief introduction is only intended as a guide for crew repairs with CHEMCO products Epo-chem RS 500P and RA 500M. This is a guideline for how
More informationMachinability is the ease with which a given material may be worked with a cutting tool
Machinability Machinability is the ease with which a given material may be worked with a cutting tool Machinability ratings (MR) provide and understanding of the severity of a metalworking operation in
More informationProperties A Metal B Non- metal Electronic configuration?? Nature of oxides?? Oxidizing or reducing action?? Conduction of heat and electricity??
CLASS: X NCERT (CBSE) SCIENCE: Chemistry Page: 1 Question 1: Compare the properties of a typical metal and a non-metal on the basis of the following. Fill in Column A, B. Properties A Metal B Non- metal
More informationWhite Paper. by Jeffrey Kochelek V.1.0.2
White Paper Mission Critical Facilities - Is the Use of Galvanized Pipe an Effective Corrosion Control Strategy in Double Interlock Preaction Fire Protection Systems? by Jeffrey Kochelek V.1.0.2 Copyright
More informationDuctile Iron Piles Corrosion Resistance
Ductile Iron Piles Corrosion Resistance Ductile Iron Piles are often a preferred, cost-effective foundation support solution for a variety of projects particularly in urban settings. Similar to other types
More informationGUIDE SPECIFICATION EXETER VERSA SHIELD SECURITY SCREEN SYSTEM
1 GUIDE SPECIFICATION EXETER VERSA SHIELD SECURITY SCREEN SYSTEM 1.01 WORK INCLUDED PART 1: GENERAL A. Provide for all labor, equipment, materials, and services to furnish and install VERSA SHIELD Window
More informationApplication and importance of copper and copper powder on powder metallurgy field
Application and importance of copper and copper powder on powder metallurgy field In recent years, powder metallurgy scholars have paid more attention to materials that have nanometer and composite feature.
More informationACCELERATED CORROSION TESTING OF GALVANIC COUPLES. James F. Dante, Josh Averett, Fritz Friedersdorf, and Christy Vestal
ACCELERATED CORROSION TESTING OF GALVANIC COUPLES James F. Dante, Josh Averett, Fritz Friedersdorf, and Christy Vestal Luna Innovations 706 Forest St. Suite A Charlottesville, VA 22903 dantej@lunainnovations.com
More informationGalvanic Anode Cathodic Protection System Design
Galvanic Anode Cathodic Protection System Design by James B. Bushman, P.E. Principal Corrosion Engineer Bushman & Associates, Inc Medina, Ohio USA The contents of this white paper including all graphics
More informationSensitization & Corrosion Behaviour of Austenitic Stainless Steel 304 & 316
Sensitization & Corrosion Behaviour of Austenitic Stainless Steel 304 & 316 Manish Kumar Verma Mechanical, Columbia Institute of Engineering & Technology, Raipur (India) ABSTRACT Austenitic Stainless steels
More informationALUMINUM ALLOY B O AT B U I L D I N G
ALUMINUM ALLOY B O AT B U I L D I N G The first aluminum pleasure boat, a 40 ft motor yacht, Le Mignon, was reportedly built in France in 1891. Forty years later in England, the 55 ft motor yacht named
More information