In-line sampling of basic oxygen steelmaking dust. Tobias Heinrich Anthony Griffiths Martyn Griffiths Andrew Hopkins Julian Steer
|
|
- Joanna Bates
- 6 years ago
- Views:
Transcription
1 In-line sampling of basic oxygen steelmaking dust Tobias Heinrich Anthony Griffiths Martyn Griffiths Andrew Hopkins Julian Steer
2 Contents Background Basic oxygen steelmaking (BOS) process Dust characteristics Dust extraction Sampling location and requirements Vertical particle distribution in slurry Sampling design and installation Sample preparation and results Conclusion
3 BOS process
4 Dust characteristics Quantity: kg per tonne of liquid steel Particle size: 90% with diameter less than 100 microns Composition: Fe 50-80%, Zn %, Ca %
5 Dust extraction BOS converter during blow period BOS dust extraction system
6 Sampling location and requirements Sampling location: 15 metres above ground Solids : g/litre Flow velocity: m/sec CO gas hazard Requirements: Representative sample to be directed to ground level Quick installation 10 litre samples Sampling every 30 sec
7 Rouse number Measurement of vertical particle distribution Ratio between fall velocity and upwards velocity Rouse number definition: (1) Shear velocity: (2) Bed shear stress: (3) Fall velocity: (4) Submerged specific gravity: (5)
8 Vertical particle distribution in slurry Bed load Suspended load Wash load Total sediment load Transport Rouse number Bed load > 2.5 Suspended load: 50 % > 1.2, < 2.5 Suspended load: 100 % > 0.8, < 1.2 Wash load < 0.8
9 Vertical particle distribution in slurry Particles under 200 microns transported as wash load micron particles transported as suspended load No bed load since all BOS dust particles are under 600 microns Sampling over complete cross section of pipe
10 Sampling design Three inlets to sample over wide cross section Inner diameter of the three sampling pipes much larger than diameter of the largest particles System was initially primed with vacuum cleaner Flow velocity in three sampling pipes: 2.8 m/sec
11 Sampling installation Sampler and flow meter installed in slurry pipe Three way valve on ground level for extraction of slurry
12 Sample preparation Samples weighed and left for particle settlement Wet vacuum cleaner used to reduce majority of waste water Samples dried, weighed and ground with a ring mill Inductively coupled plasma mass spectrometry for analysing chemical composition Laser diffraction particle size analyser and sieves for analysing particle size
13 Sampling results Generic dust mass and particle size profile during a BOS heat Mass flow profiles Composition profiles Particle size profiles Giving insight into how dust varies during each heat Allowing correlations between process changes and dust generation to be identified Research into treatment and recycling possibilities
14 Conclusion The in line sampling design allowed samples representative of the process to be taken at regular intervals. Difficulties due to the sampling location including the height and gas hazard were overcome by moving the actual sampling activity down to ground level in a safe area. Prior to the sampling process the particles and the flow characteristics were analysed, allowing a suitable sampling system to be designed. To ensure a representative sample was generated, the slurry was extracted at three different slurry depths under close to isokinetic conditions. This work has shown how to overcome various sampling difficulties by the use of practical, technical solutions.
15 Acknowledgments The authors wish to express their gratitude to Tata Steel UK for the financial support and ongoing assistance in this study and the practical assistance and guidance provided by: Fiona Abbott Claire Grainger Kevin Linsley
16 Thank you for listening. Any questions?
17 References European commission (2001) Best Available Techniques Reference Document on the Production of Iron and Steel, Integrated pollution prevention and control p.233, European commission, Joint research centre, Institute for prospective technological studies. Ferguson, R. & Church, M. (2004) A simple universal equation for grain settling velocity, Journal of Sedimentary Research, Vol. 74, No. 6, November 2004, p , Society of Sedimentary Geology. Flowline Manufacturing Ltd (n.d.) Flo-Dar Open Channel Flowmeter for sewer, drain and part full pipe measurement, viewed 13 July 2011, < Pictures: Gordon, N., et al. (2004) Stream hydrology: an introduction for ecologists, 2nd edition, ISBN , John Wiley & Sons Ltd., West Sussex, England.
The Impact Wear Behavior of Large Rocks on Slurry Pump Materials and Equipment.
The Impact Wear Behavior of Large Rocks on Slurry Pump Materials and Equipment. Robert J. Visintainer V.P. of Engineering and R&D GIW Industries Inc. Dan Wolfe Sr. Associate Mechanical Syncrude Canada
More informationModule 7: Hydraulic Design of Sewers and Storm Water Drains. Lecture 7: Hydraulic Design of Sewers and Storm Water Drains
Module 7: Hydraulic Design of Sewers and Storm Water Drains Lecture 7: Hydraulic Design of Sewers and Storm Water Drains 7.0 HYDRAULIC DESIGN OF SEWERS AND STORM WATER DRAINS 7.1 General Consideration
More informationGUIDANCE NOTE. Performance of Electromagnetic Meters Designed for Use in Part-Filled Pipes.
GUIDANCE NOTE Performance of Electromagnetic Meters www.tuvnel.com Performance of Electromagnetic Meters Introduction Electromagnetic flowmeters designed for use in part-filled pipes may be considered
More informationVERIFICATION STATEMENT
Verification Statement Verification Statement Verification Statement VERIFICATION STATEMENT GLOBE Performance Solutions Verifies the performance of Stormceptor EF4 and EFO4 Oil-Grit Separators Developed
More informationMechanism of filtration : 1- Straining action: strain particles that has a big size on the sand surface.
Filtration Purpose of filtration : Removal of remaining 4% of suspended solids. Removal of odor, color and taste. Removal of iron and manganese. Removal of 90 % of bacteria. Mechanism of filtration : 1-
More information6.5 Filtration General
6.5 Filtration 6.5.1 General Turbidity and algae are removed from raw waters by screens, gravel filters and slow sand or rapid gravity filters. The difference between slow and rapid sand filtration is
More informationVortex Separator. May be more cost-effective pre-treatment devices than traditional wet or dry basins.
Description Vortex separators: (alternatively, swirl concentrators) are gravity separators, and in principle are essentially wet vaults. The difference from wet vaults, however, is that the vortex separator
More informationDOWNSTREAM DEFENDER TESTING USING MAINE DEPARTMENT OF ENVIRONMENTAL PROTECTION PROTOCOL UTILIZING OK-110 FEED SAND
DOWNSTREAM DEFENDER TESTING USING MAINE DEPARTMENT OF ENVIRONMENTAL PROTECTION PROTOCOL UTILIZING OK-110 FEED SAND JULY 2002 Copyright 2001 H.I.L. Technology, Inc. All rights reserved. This report was
More informationVALLIAMMAI ENGINEERING COLLEGE DEPARTMENT OF CIVIL ENGINEERING Question Bank CE2354 - ENVIRONMENTAL ENGINEERING - II Prepared By: Year: 3rd year Semester: 6th Semester R.THENMOZHI / A.P.Civil J.SHANMUGAPRIYA
More information6 STOREY CONDOMINIUM 7480 DERRY ROAD WEST, MILTON
6 STOREY CONDOMINIUM 7480 DERRY ROAD WEST, MILTON STORM WATER MANAGEMENT DESIGN BRIEF NEW DEVELOPMENT DRAINAGE SYSTEM REV 0 August 29, 2017 PREPARED BY: HALLEX PROJECT #170532 HALLEX NIAGARA HALLEX HAMILTON
More informationStream Ecology Lab Module 4/5 Determining Discharge and Sediment Yield in a Small Stream
Stream Ecology Lab Module 4/5 Determining Discharge and Sediment Yield in a Small Stream Introduction: In this lab you will determine the total suspended solids yield per year for two streams a local stream
More informationA reliable solution for ditching, underpassing and rainwater drainage
PIPES AND CHAMBERS CULVERT PIPES A reliable solution for ditching, underpassing and rainwater drainage Culvert pipes are used to convey drain pipe water or rainwater under the ground. The smallest (110
More informationSPILL ESTIMATION. Not Just A Guess Anymore
SPILL ESTIMATION Not Just A Guess Anymore SPILL ESTIMATION Under current regulations accurate spill estimation has become critical to the operation and maintenance of a sanitary collection system Reporting
More informationMath Matters: Dissecting Hydrometer Calculations
Math Matters: Dissecting Hydrometer Calculations By Jonathan Sirianni, Senior Laboratory Assessor 2 Posted: April 2013 In the 16th century Galileo and the Tower of Pisa made famous the fact that two objects,
More informationRAINWATER HARVESTING SYSTEMS
BALMORAL TANKS RAINWATER HARVESTING SYSTEMS www.balmoralrainwatersystems.co.uk UK Designed and manufactured The Balmoral HydroStore TM With the recognition of water as a valued commodity, Balmoral Tanks
More informationWPL Diamond. Environmental Wastewater Solutions. EN approval Compact design No odours. Low visual impact Easy to install
EN12566-3 approval Compact design No odours WPL Diamond Small packaged sewage treatment plants for domestic and commercial properties Environmental Wastewater Solutions Low visual impact Easy to install
More informationProduction and Characteristics of Rock Dust Applied in Underground Mines. April 13, 2017
Production and Characteristics of Rock Dust Applied in Underground Mines April 13, 2017 About Greer Lime Greer Lime Company is located near Seneca Rocks, West Virginia. It was opened in 1960 under the
More informationGrit Collection & Classification Case Studies
Grit Collection & Classification Case Studies OWEA 2010 Specialty Biosolids Specialty Workshop Brian F. McNamara, HRSD Definition of Grit Metcalf & Eddy 2 nd Edition 1979 grit, consisting of sand, gravel,
More informationA Further Investigation of DIAjet Cutting. by:
INTRODUCTION A Further Investigation of DIAjet Cutting by: David A. Summers, Whang-Zhong Wu, Jianchi Yao Curators Professor, Associate Professor, Graduate Student University of Missouri-Rolla High Pressure
More informationMetal and Particulate Emissions from Incinerators Burning Sewage Sludge and Mixed Refuse
Metal and Particulate Emissions from Incinerators Burning Sewage Sludge and Mixed Refuse F. l. CROSS, JR. R. J. DRAGO H. E. FRANCIS Roy F. Weston West Chester, Pennsylvania National Air Pollution Control
More informationNaturally Entraining Solid Particle Injector
Y., Xie, V., Raghavan, A. S., Rangwala, Naturally Entraining Solid Particle Injector, Powder Technology, 2011 (accepted for pub). Naturally Entraining Solid Particle Injector Yanxuan Xie1, Vasudevan Raghavan2
More informationDomino. Domino VGS. Vertical Gravity Separator
Vertical Gravity Separator Oil Out Clean Water Outlet Oily Water In Sludge Outlet Introduction Product Overview The is an oil/water separator developed to effectively remove free oil, grease and suspended
More informationSlurry sampling. Benefits. Outotec slurry sampling
Slurry sampling Outotec slurry sampling Sampling from process streams and delivery to analyzer is crucial in process monitoring. Information on the process pipe, flow rates and the amount of sample required,
More informationLowering The Total Cost Of Operation
Lowering The Total Cost Of Operation The system removes more solids than conventional clarification, so filters can run longer between backwash cycles. Fewer backwash cycles means less backwash water,
More informationModule 9 : Sewage And Storm water Pumping Stations. Lecture 11 : Sewage And Storm water Pumping Stations
1 P age Module 9 : Sewage And Storm water Pumping Stations Lecture 11 : Sewage And Storm water Pumping Stations 2 P age 9.1 Introduction There are certain locations where it is possible to convey sewage
More informationCROP PROCESSING ENGINEERING Cleaning and Sorting
CROP PROCESSING ENGINEERING Cleaning and Sorting Comparative commercial value of a farm product is a function of its grade factor. Grade factors (that apply in various combinations to all products produced
More informationMix Design and Pumped Concrete
Mix Design and Pumped Concrete A simple method of concrete mix design for pumpable concrete based on an estimated weight of the concrete per unit volume is described in the paper. The tables and figures
More informationCHAPTER 6. Sanitary Sewer
CHAPTER 6 Sanitary Sewer A. Introduction All proposed developments, subdivisions, and buildings must have a properly designed and constructed sanitary sewer collection system. The system shall provide
More informationIntroduction. Wetland System. A Wetland Scene at Lorne C. Henderson Conservation Area near Petrolia
Wetland Treatment of Wastewater This monograph, one in a series of single issue documents that deal with our local environment, has been prepared by the Sarnia-Lambton Environmental Association in co-operation
More informationDefinition separation of unstable and destabilized suspended solids from a suspension by the force of gravity
SEDIMENTATION-1 TEKNOLOGI PENGOLAHAN LIMBAH Definition separation of unstable and destabilized suspended solids from a suspension by the force of gravity 1 Applications in Wastewater Treatment grit removal
More informationTypes of Hydropower Facilities
Types of Hydropower Facilities 1 Impoundment Hydropower- uses a dam to store water. Water may be released either to meet changing electricity needs or to maintain a constant water level. 2 Run-of-River
More informationQuality of Washed and Compacted Screenings
Quality of Washed and Compacted Screenings Markus Roediger*, Wolfgang Branner** * Dr. Roediger Consult, Stuttgart, Germany (dr.m.roediger@t-online.de) ** Huber SE, Berching, Germany (brw@huber.de) ABSTRACT
More informationMinerals. WARMAN Centrifugal Slurry Pumps WBV Vertical Cantilever Slurry Sump Pump Series
Minerals WARMAN Centrifugal Slurry Pumps WBV Vertical Cantilever Slurry Sump Pump Series The Warman WBV ultra heavy-duty range of vertical cantilevered slurry pumps sets a new industry benchmark for general
More informationEffect of hydrometer type on particle size distribution of fine grained soil
Effect of hydrometer type on particle size distribution of fine grained soil A. Kaur* & G.C. Fanourakis University of Johannesburg, Johannesburg, South Africa ABSTRACT: The particle size distribution of
More informationSAF SAF SUBMERGED AERATED FILTER THE PARTNER OF CHOICE
SAF SAF SUBMERGED AERATED FILTER THE PARTNER OF CHOICE Sewage treatment plant for small and large scale projects The Conder SAF Package Sewage Treatment Plant is the perfect solution for small and large
More informationDevelopment of EAF Dust Recycling and Melting Technology Using the Coal-based FASTMELT Process
Development of Recycling and Melting Technology Using the -based FASTMELT Process By M. Tateishi, H. Fujimoto, T. Harada, H. Sugitatsu Kobe Steel, Ltd. Editor s note: this article was adapted from a paper
More informationPollution Control BH-BL. BioDisc. High Performance Package Sewage Treatment Plants for Residential, Business & Leisure Applications. klargester.
Pollution Control BioDisc BH-BL High Performance Package Sewage Treatment Plants for Residential, Business & Leisure Applications klargester.com BioDisc BH-BL High Performance Package Treatment Plants
More informationStandard Test Procedures Manual
STP 205-10 Standard Test Procedures Manual Section: 1. SCOPE 1.1. Description of Test This method describes the quantitative determination of the distribution of particle sizes in soils. The distribution
More informationSTORMWATER MANAGEMENT
DRAINAGE SOLUTIONS SINCE 1908 STORMWATER MANAGEMENT STORMWATER TREATMENT AND FLOW CONTROL ENVIRONMENTAL PROTECTION EASE OF MAINTENANCE RELIABLE PERFORMANCE ARMTEC.COM STORMWATER TREATMENT Armtec is excited
More informationLaboratory Investigations of the Electrical Resistivity of Cokes and Smelting Charge for Optimizing Operation in Large Ferrochrome Furnaces
Southern African Pyrometallurgy 2006, Edited by R.T. Jones, South African Institute of Mining and Metallurgy, Johannesburg, 5-8 March 2006 Laboratory Investigations of the Electrical Resistivity of Cokes
More informationFact Sheet: Biosand Filter
Fact Sheet: Biosand Filter Submitted by omills on Mon, 2011/10/10-9:58pm The Treatment Process Potential Treatment Capacity Very Effective For: Bacteria Protozoa Helminths Turbidity Taste, odour, colour
More informationCartridge Filters, Fuel Gas Filters, Gas Scrubbers & Filter Separators. A Long Experience in Energy Equipment and one Goal:
A Long Experience in Energy Equipment and one Goal: The Customer s satisfaction. Cartridge Filters, Fuel Gas Filters, Gas Scrubbers & Filter Separators Established in 1907, TGT - Tormene Gas Technology
More informationAQUATEK rainwater harvesting systems can reduce mains water consumption in the average domestic dwelling by up to 50%."
RAINWATER HARVESTING SYSTEMS Aquatek rainwater harvesting systems capture and store rainwater from roofs allowing it to be reused around the house or building for supplying water to flush toilets, wash
More informationDrainage structure refers to manholes, catch basins, leaching basins, inlets and drop inlets. Drainage structures are designated as follows.
403.01 Section 403. DRAINAGE STRUCTURES 403.01 Description. Adjust, construct, or temporarily lower drainage structures. Clean existing drainage structures and leads as directed by the Engineer. Drainage
More informationIABSE-JSCE Joint Conference on Advances in Bridge Engineering-II, August 8-10, 2010, Dhaka, Bangladesh. ISBN:
IABSE-JSCE Joint Conference on Advances in Bridge Engineering-II, August 8-10, 2010, Dhaka, Bangladesh. ISBN: 978-984-33-1893-0 Amin, Okui, Bhuiyan (eds.) www.iabse-bd.org Construction of Hazrat Shah Paran
More informationAustralian Patented Technology ~ PCT pending months in process operation. Two Phase Solids Flow Distribution with a difference
FloCEP ~ Australian Patented Technology ~ PCT pending 39 + months in process operation Two Phase Solids Flow Distribution with a difference A Step Change producing low cost process profit using a balanced
More informationOperating characteristics of PNEUMATIC GRAIN CONVEYORS By R. W. KLEIS Bulletin 594 UNIVERSITY OF ILLINOIS AGRICULTURAL EXPERIMENT STATION Operating Characteristics of Pneumatic Grain Conveyors' By R. W.
More informationThe Bernoulli Filter
The Bernoulli Filter Simple and ingenious filtration Table of content 1. The Bernoulli history 2. Introduction of the Bernoulli Filter 3. The target application, protection of PHE 4. Bernoulli recommendations
More informationOperation and Performance of the Gas In-Vitro Exposure System (GIVES)
Operation and Performance of the Gas In-Vitro Exposure System (GIVES) Supplement to manuscript APC-2012-1: Gaseous VOCs Rapidly Modify Particulate Matter and Its Biological Effects: Part 1, Simple VOCs
More informationSAFL Baffle Research Summary
SAFL Baffle Research Summary Four years of research was conducted to develop and test the SAFL Baffle. The research took place at the University of Minnesota s St. Anthony Falls Laboratory and was funded
More informationTemporary Watercourse Crossing: Culverts
Temporary Watercourse Crossing: Culverts DRAINAGE CONTROL TECHNIQUE Low Gradient Velocity Control Short Term Steep Gradient Channel Lining Medium-Long Term Outlet Control Soil Treatment Permanent Symbol
More information200 / 300 Eazy Retro Upgrade Kit
NEXT21311131MAN NEXUS 210 / 310 UPGRADE KIT INSTALLATION 200 / 300 Eazy Retro Upgrade Kit Installation and instruction manual for: Type 2 - Nexus 200 and 300 Upgrade Kit (Upgrades the Eazy Filter in a
More informationInternational Journal of Engineering and Robot Technology
Research Article ISSN: 2395 5597 International Journal of Engineering and Robot Technology Journal home page: www.ijerobot.com INVESTIGATION INTO THE STRUCTURALPROPERTIES OF SUGARCANE BAGASSE FIBER IN
More informationHAVER Mining HAVER & BOECKER HAVER & BOECKER
HAVER Mining HAVER GROUP 2 HAVER GROUP Our Success Headquarters Subsidiaries Employees Sales HAVER & BOECKER, Germany 50 Locations 2.900 470 Mio 3 HAVER GROUP Our Passion 4 HAVER GROUP We focus on Premium
More informationCOMPUTATIONAL STUDY OF A TRAILBLAZER MULTI REACTOR TUNDISH (MRT) FOR IMPROVING YIELD AND QUALITY OF STEEL DURING CONTINUOUS CASTING
COMPUTATIONAL STUDY OF A TRAILBLAZER MULTI REACTOR TUNDISH (MRT) FOR IMPROVING YIELD AND QUALITY OF STEEL DURING CONTINUOUS CASTING Debasish Chatterjee Department of Metallurgical and Materials Engineering,
More informationInlet Process air and wash cycle scour air. Air grid Floor Nozzle
BIOSTYR Wastewater BIOSTYR Mastering advanced technology Veolia Water Solutions & Technologies has more than 20 years experience of supplying and operation BAFF (Biological Activated Flooded Filter) processes
More informationEnviro Voraxial Technology
1.0 Introduction Enviro Voraxial Technology 821 NW 57 th Place, Fort Lauderdale, FL 33309 Phone 954.958.9968 Fax: 954.958.8057 sales@evtn.com www.evtn.com Case Study Voraxial 4000 Separator On Offshore
More informationINVENTION ON SAMPLING BY YUNEL
A NEW ERA IN SAMPLING INVENTION ON SAMPLING BY YUNEL NEW TECHNOLOGY ON SAMPLING SYSTEMS OVER CONVEYOR 'SAMPLING SYSTEM WITH SUPER SHOCK PRINCIPLE IS IN CHARGE OVER CONVEYOR BELTS IN A COAL MINE 2 In New
More informationMinimum grade (%) Velocity at full flow (m s 1 )
1.6 Pipes Effluent can be conveyed by channels or pipes under gravity or in dedicated pipelines under pressure. If pipes are used, pressure rating, water-hammer and excessive friction losses must be considered
More informationCE 370. Filtration. Overview of the Process Location in the Treatment Plant
CE 370 Filtration 1 Overview of the Process Location in the Treatment Plant After the water has been settled, some fine solids/flocs may still be in suspension, therefore, removal of these fine solids
More informationStormwater Sediment Sampling Project Report Project ID: SUNTREE_SED_001
11341 Distribution Avenue East Suite #6 Jacksonville, Florida 32256 904-880-1817 Fax904-880-1339 Stormwater Sediment Sampling Project Report Project ID: SUNTREE_SED_001 Prepared for Mr. Henry Happel Suntree
More informationCGN 6933: Drinking Water Treatment Processes Department of Civil & Environmental Engineering University of South Florida Cunningham Spring 2013
Homework #5 Due Thurs., March 28 Topic: Filtration 1. (2 pts) When estimating the effectiveness of a granular-media filter, we usually estimate the single-collector efficiency,. If we account for three
More informationETV Joint Verification Statement
THE ENVIRONMENTAL TECHNOLOGY VERIFICATION PROGRAM U.S. Environmental Protection Agency NSF International ETV Joint Verification Statement TECHNOLOGY TYPE: SEDIMENTATION AND ADSORPTION OF MERCURY AMALGAM
More informationThis work was prepared by U.S. Government employees on official time and is therefore in the public domain and not subject to copyright.
BENCHMARKING AND MODELING OF A CLOSED-LOOP PILOT SYSTEM Carl Houtman and Karen Scallon USDA, Forest Products Laboratory, Madison, WI, USA Abstract Computer modeling and tracer studies are useful tools
More informationTraction sand. Spillage- Septic waste, plastics. Metal Salts, pure metals carbonates
Street Sweeping as a method to reduce surface water pollution June 30, 2010 Let s start with how pollution can get from the street to the water, where the pollution came from and what it might contain
More informationErosion Effects in Flowmeters
Subsea EXPO 2015 Conference, Aberdeen 11-12th February 2015 Erosion Effects in Flowmeters John Peters, NEL Tariq Boussouara, NEL Slide 1 Presentation Contents Project Objective Flowmeter Details, Test
More informationBerrybank Piggery There s more to pig waste than smell!
Berrybank Piggery There s more to pig waste than smell! Half of what pigs consume is returned as waste. Charles Integrated Farming Enterprises Pty Ltd (Charles I.F.E. Pty Ltd) considered this to be a poor
More informationLiquid Stream Fundamentals: Grit Removal
FACT SHEET Liquid Stream Fundamentals: Grit Removal Grit removal is an essential component of the wastewater treatment process. Not only does the removal of grit help protect downstream equipment from
More informationPreliminary Field Evaluation of EPA Method CTM-039 (PM2.5 Stack Sampling Method) Michael D. Buser and Derek P. Whitelock
Preliminary Field Evaluation of EPA Method CTM-039 (PM2.5 Stack Sampling Method) Michael D. Buser and Derek P. Whitelock ABSTRACT Agricultural operations are encountering difficulties complying with current
More informationAN EXPERIMENTAL STUDY OF THE OPTIMAL THICKNESS OF A SAND LAYER IN A SAND FILTER WATER QUALITY STRUCTURE. July 1994
DC WRRC Report No. 178 AN EXPERIMENTAL STUDY OF THE OPTIMAL THICKNESS OF A SAND LAYER IN A SAND FILTER WATER QUALITY STRUCTURE July 1994 D.C. Water Resources Research Center University of the District
More informationDetermination of design criteria for UASB reactors as a wastewater pretreatment system in tropical small communities
International Journal of Environmental Science & Technology Vol. 1, No. 1, pp. 51-57, Spring 2004 Determination of design criteria for UASB reactors as a wastewater pretreatment system in tropical small
More informationhigh efficiency ~ simple package ~ proven reliability ChromaPur Chromic Acid Purification Unit
high efficiency ~ simple package ~ proven reliability ChromaPur Chromic Acid Purification Unit Achieve maximum recovery, maximum cost reduction, and maximum quality consistency with Eco-Tec s chromic acid
More informationCHAPTER 1 INTRODUCTION
1 CHAPTER 1 INTRODUCTION 1.1 GENERAL Rapid economic growth and industrialisation has led to significant reduction in ambient air quality. There is an ever increasing demand for power and to meet this demand
More informationCHAR REACTIVITY AND ITS IMPLICATIONS. *J.M. Steer, R. Marsh, M. Greenslade ECCRIA 2016
CHAR REACTIVITY AND ITS IMPLICATIONS FOR BLAST FURNACE COAL INJECTION *J.M. Steer, R. Marsh, M. Greenslade Cardiff University - School of Engineering ECCRIA 2016 Content Introduction Blast furnace coal
More informationOver the past few decades the demand for steel
Hot metal desulphurisation: benefits of magnesium lime co-injection The evolution of external hot metal desulphurisation has been driven by the ever-increasing consumer demand for higher quality steels.
More informationCeramic and glass technology
1 Row materials preperation Plastic Raw materials preperation Solid raw materials preperation Aging wet milling mastication Mixing seving Grain size reduction Milling Crushing Very fine milling Fine milling
More informationFilter Tube Barriers (Instream)
Filter Tube Barriers (Instream) INSTREAM PRACTICES Flow Control No Channel Flow Dry Channels Erosion Control Low Channel Flows Shallow Water Sediment Control High Channel Flows Deep Water Symbol Photo
More informationINDIAN INSTITUTE OF TECHNOLOGY GANDHINAGAR Department of Civil Engineering Soil Mechanics Laboratory
THEORY: INDIAN INSTITUTE OF TECHNOLOGY GANDHINAGAR CONSOLIDATION TEST- (OEDOMETER TEST) (IS 2720-PART-15-1986) Reaffirmed-2002 When a compressive load is applied to soil mass, a decrease in its volume
More informationBetapure CMP Series. CMP Filter Capsules. Superior Reduction Of Large Particle Counts For Improved Yields. Features & Benefits.
Betapure Series Filter Capsules Features & Benefits Graded Porosity Design Superior reduction of hard and soft gel contaminants, for reduced defectivity and improved yields High contaminant holding capacity
More informationWM2008 Conference, February 24-28, 2008, Phoenix, AZ Abstract #8216. Thermal Pretreatment For TRU Waste Sorting
ABSTRACT Thermal Pretreatment For TRU Waste Sorting T. Sasaki, Y. Aoyama, Y. Miyamoto, and H. Yamaguchi Japan Atomic Energy Agency 4-33, Muramatsu, Tokai-mura, Ibaraki 319-1194 Japan Japan Atomic Energy
More informationStudy of the Compressive Strength of Concrete with Various Proportions of Steel Mill Scale as Fine Aggregate
Study of the Compressive Strength of Concrete with Various Proportions of Steel Mill Scale as Fine Aggregate Akhinesh K 1, Jithu G Francis 1, Junaid K T 1, Jishnulal K 1, Jeril Netto Joseph 1, Remya Neelancherry
More informationHeat exchangers and thermal energy storage concepts for the off-gas heat of steelmaking devices
Journal of Physics: Conference Series Heat exchangers and thermal energy storage concepts for the off-gas heat of steelmaking devices To cite this article: T Steinparzer et al 2012 J. Phys.: Conf. Ser.
More informationAMCOT COOLING TOWER CORPORATION LRC-H & LRC-LNS CROSS FLOW COOLING TOWER OPERATIONS AND MAINTAINENCE MANUAL
AMCOT COOLING TOWER CORPORATION LRC-H & LRC-LNS CROSS FLOW COOLING TOWER 1. Preface OPERATIONS AND MAINTAINENCE MANUAL 1-800-444-8693 Operation and Maintenance Manual For Amcot LRC-H Cooling Tower & LRC-LNS
More informationUnit Treatment Processes in Water and Wastewater Engineering
Unit Treatment Processes in Water and Wastewater Engineering T J Casey AQUAVARRA RESEARCH LIMITED 22A Brookfield Avenue Blackrock Co. Dublin. October 2006 Author s Note Water and wastewater treatment technology
More informationFABRICATION, TESTING AND EVALUATION OF A DUST FILTRATION SYSTEM FOR SMALL-SCALE SPICE GRINDING MILLS ABSTRACT
July 2005 FABRICATION, TESTING AND EVALUATION OF A DUST FILTRATION SYSTEM FOR SMALL-SCALE SPICE GRINDING MILLS D. A. N. Dharmasena 1., D. N. Jayatissa 1., N. G. V. C. M. Kumara 1. and D. T. N. Wijesinghe
More informationPeerless Europe. Separation and Filtration
Peerless Europe Separation and Filtration The Company Peerless Europe Limited has been established since 1992 and serves Europe, Africa, the Middle East and the Former Soviet Union. We are still broadening
More informationYour Water Treatment Technology Partners for Wash Water & Industrial Water Treatment. Design Supply Integration Installation Maintenance
Your Water Treatment Technology Partners for Wash Water & Industrial Water Treatment Design Supply Integration Installation Maintenance The Challenge for Businesses that Use Water PUBLIC HEALTH EPA state
More information> Pre-installation reference guide
> Pre-installation reference guide Toroid underground tanks > The patent and copyright are the property of Viscount Rotational Mouldings Pty. Ltd, and may not be reproduced without the written permission
More informationLecture 12 Converter Steelmaking Practice & combined blowing. Key words: Top blown steelmaking, combined blowing, bottom stirring, hot metal refining
Lecture 12 Converter Steelmaking Practice & combined blowing Contents: Refining of hot metal Composition and temperature during the blow Physico-chemical interactions Developments in Top blown steelmaking
More information2008 Beltwide Cotton Conferences, Nashville, Tennessee, January 8-11, 2008
546 UPDATE ON THE FIELD EVALUATION OF EPA METHOD CTM-039 (PM2.5 STACK SAMPLING METHOD) Michael D. Buser USDA-ARS Cotton Production and Processing Research Unit Lubbock, TX Derek P. Whitelock USDA-ARS,
More informationIRONMAKING and THEORY AND PRACTICE. Ahindra Ghosh Amit Chatterjee
IRONMAKING and STEELMAKING THEORY AND PRACTICE Ahindra Ghosh Amit Chatterjee IRONMAKING AND STEELMAKING IRONMAKING AND STEELMAKING Theory and Practice AHINDRA GHOSH Formerly Professor Materials and Metallurgical
More informationPROCESSING COMBINED LASER, SONAR AND HD IMAGING FOR BETTER EVALUATION DECISIONS
North American Society for Trenchless Technology (NASTT) No-Dig Show 2011 Washington, D.C. March 27-31, 2011 Paper F-3-05 PROCESSING COMBINED LASER, SONAR AND HD IMAGING FOR BETTER EVALUATION DECISIONS
More informationBy-Products from EAF Dust Recycling and Their Valorisation. Vlad POPOVICI
By-Products from EAF Dust Recycling and Their Valorisation Bredero Shaw, Canada 5 th Global Slag Conference, Brussels, 23-24 November 2009 Agenda Electric Arc Furnace Dust Global Production EAF Dust Recycling
More informationMeasuring, sampling, and analyzing white waters
T 656 cm-97 TENTATIVE STANDARD 1930 OFFICIAL STANDARD 1931 REVISED 1940 CORRECTED 1961 CLASSICAL METHOD 1983 REVISED 1997 1997 TAPPI The infmation and data contained in this document were prepared by a
More informationMill Inerting and Pulverizer/Mill Explosion Mitigation
Mill Inerting and Pulverizer/Mill Explosion Mitigation Richard P. Storm richardstorm@innovativecombustion.com (205) 453-0236 Coal Mills are the Heart of a Coal Fired Plant Maximum capacity, reliability
More informationModular Sediment Barriers (Instream)
Modular Sediment Barriers (Instream) INSTREAM PRACTICES Flow Control No Channel Flow Dry Channels Erosion Control Low Channel Flows Shallow Water Sediment Control High Channel Flows Deep Water Symbol Photo
More informationHydro Electric Power (Hydel Power)
Operating Principle Hydro Electric Power (Hydel Power) Hydro-electric power is generated by the flow of water through turbine, turning the blades of the turbine. A generator shaft connected to this turbine
More informationTransportation of High Concentration Coal Ash Slurries through Pipelines
International Archive of Applied Sciences and Technology, Vol 1 [1] JUNE 1: 1-9 Society of Education, India ISSN 976-488 http:// www.soeagra.com ORGINAL ARTICLE Transportation of High Concentration Coal
More informationAdvanced Enviro-Septic TM Basic Design and Installation Manual
Advanced Enviro-Septic TM Basic Design and Installation Manual New Zealand Distributors Environment Technology Ltd 14 Onekaka Iron Works Rd Takaka 7182 (03) 9707 979 www.et.nz info@et.nz Technical support
More informationRPM & RPMF Rotor Impact Mill. The Sand Maker
RPM & RPMF Rotor Impact Mill The Sand Maker Headquarters of BHS-Sonthofen The Company BHS-Sonthofen is an owner-operated group of companies specialized in machinery and plant engineering. The group is
More information