Barrett Enterprises Inc Introduces GigaHouse Panel System from GigaCrete
|
|
- Betty Turner
- 6 years ago
- Views:
Transcription
1 Barrett Enterprises Inc Introduces GigaHouse Panel System from GigaCrete GigaHouse is a super insulated steel-framed construction system specifically targeting projects where rapid speed of construction and ease of assembly are important. Steel Foam Panel system homes are perfect for residential, commercial and industrial applications. The EPS Panel System is engineered to be fire-proof, water, insect, vermin, mold, hurricane and earthquake resistant. This Green Pre-Fab home is quick to assemble, environmentally friendly and the sustainable answer to the crisis facing our global community- Affordable, Safe and Energy Efficient Housing
2 GIGAPANEL COMPARATIVE TECHNICAL INFORMATION ATTRIBUTE WOOD STUD STEEL STUD CMU BLOCK SIPS ICF GIGAPANEL AVERAGE TRADES REQD INSULATION R-VALUE HURRICANE RESISTANCE NO YES YES NO YES YES SEISMIC RESISTANCE NO YES NO NO YES YES VAPOR RESISTANCE NO NO NO NO YES YES MOLD RESISTANCE NO YES NO NO NO YES MILDEW RESISTANCE NO YES NO NO NO YES INSECT RESISTANCE NO YES YES NO YES YES VERMIN RESISTANCE NO YES YES NO YES YES FIRE RESISTANCE POOR GOOD GOOD POOR GOOD GOOD TOXICITY PRODUCED HIGH LOW LOW HIGH LOW VERY LOW AIR LEAKAGE TIME TO COMPLETE SLOW SLOW VERY SLOW FAST SLOW VERY FAST WEIGHT PER kgs./m RECYCLABILITY % % 10% 35% 99% Conclusions Faster construction times than conventional construction Significantly reduced labor costs Reduced project timeline costs Higher R-Values Higher resistance levels in all areas Higher recyclability Healthier materials GIGAPANEL SPECIFICATIONS Engineered up to 200 MPH wind speeds Engineered for all Seismic Zones Mold, Mildew, Insect and Vermin Resistant Meets IBC Fire Testing Standards Meets Steel Framed Construction standards MATERIALS USED 1.0 to 2.0 lbs. density EPS foam, meets ASTM 84 StuccoMax exterior cementitious coating using natural Limestone fillers, Fiberglass mesh, NO SILICA SAND PlasterMax interior fire rated ceramic plaster direct applied over foam, no gypsum board. Meets NFPA 286, ASTM E84, ASTM E136, ASTM G121, ASTM C587. Utilizing Natural Limestone fillers, Fiberglass mesh, No silica sand is used.
3 Our mission is to provide the building materials that structurally and environmentally outperform today s conventional building products. Goal is to provide affordable and energy efficient housing GigaPanel building system allows a high performance sustainable home to be constructed at or below stick built prices! GigaCrete is a family of products based on low carbon footprint Green ceramic binders significantly outperforming Portland cement: We never use PORTLAND CEMENT which is a high CO2 producer StuccoMax, a waterproof exterior coating that is non-combustible PlasterMax, a fire rated abuse resistant coating over foam replacing gypsum board All GigaCrete coatings bond permanently to EPS insulation foam, concrete products, bricks and plasters. All are one coat applications and fast to apply All are abuse resistant, non combustible, no VOC s, no off-gassing utilizing only safe and healthy materials that will not support the growth of mold or mildew.
4 What are GigaCrete s unique PanelSystems PanelSystems is not what you think. It is not a SIP s panelized building system at all. It is a patented steel framed insulation system! The building components are structural steel stud construction, proven for decades, signed off by a local structural engineer who only has to agree with the calculations of leading structural engineering already completed. We reversed the building process Typically the structural part comes first, then R19 insulation is added in between the studs last, this leaves inefficiencies, thermal leaks and sound transmission through the steel into the home. Neither fast or ideal. PanelSystems starts with the last component R28 rigid foam insulation panels with computerized insert channels cut into the foam precisely where structural engineering dictates the steel studs fit to meet code compliance for a steel framed structure! The structural components are then slipped into place and securely attached with self tapping screws.exactly the same as steel framed construction only this can be done by unskilled labor, purposely made to be very simple, guaranteed square, right the first time, no measuring, no room for errors.
5 Overview of installation methodology 1. Layout steel track on slab and permanently attach to slab 2. Locate wall insulation panels into track 3. Slide down connectors and screw together top and bottom 4. Cut in electrical conduits and secure with insulating foam 5. Coat exterior with 3,500 psi StuccoMax (same day) 6. Coat roof with Gigaroof (StuccoMax) 7. Coat interior with fire rated, 8500 psi PlasterMax
6 Panel System Homes can be made from 500 to 7000 sq.ft! Where else can you get a home for only $26.99 per sq foot? Chart shows a 576 sq foot home for $ FOB Las Vegas NV. Call today to order! DESCRIPTION TYPE SIZE SIZE LIN/FT QTY TOTAL PYRAMID ROOF 24X footprint 1 1 WALL PANELS EPS 6" thick 102 lin 8 ft high 816 sq ft WALL STUDS 3.5/8" 18 ga 8 ft lin ft WALL TRACK 3.5/8" 18 ga 8 ft 204 CEILING LID EPS 6" thick 4x8 sheets CEILING LID STUDS 3.5/8" 18 ga 8 ft 168 CEILING LID TRACK 3.5/8" 18 ga 8 ft 72 ROOF PANELS EPS 6" thick 600 sq ft 4x8 600 sq ft ROOF STUDS 3.5/8" 18 ga 8 ft 548 lin 548 lin ROOF TRACK 3.5/8" 18 ga 8 ft ROOF PLATES 12 ga 90 and straight 8 ROOF TIE DOWNS 5/8" all thread 8 ft TRUSS PACKAGE 200 mph 12" 100 lin ft 1 lot 576 sq ft STUCCOMAX 3/16" + 11 oz mesh 768 sq ft PLASTERMAX 3/16" + 11 oz mesh 1440 sq ft ROOF FINISH StuccoMax (non US) 600
7 Tools needed to build a house : Step Ladder, Screw Gun, Ramset Gun, Tape Measure, Metal Shears, Pry Bar
8 6 thick PanelSystems components Easy to store and ship.
9 PanelSystems are designed for rapid assembly by unskilled labor Large wall insulation Panels can be lifted with one hand.
10 16 linear feet of wall PanelSystems is easily carried into position NO Heavy Machinery Needed.
11 Step 1: Lay out the bottom tracks according to plans and include water resistant gaskets between the bottom track and the slab.
12 Step 2: Attach bottom track into the slab with Ramset pins
13 Step 3: Locate panels next to where they are needed
14 Step 4: Insert foam panel into steel stud bottom track Track positioned over moisture gasket and shot into slab. Tools needed: ramset gun, pins and load and tape measure
15 Panels are laid in place in minutes not days Rooms take shape instantly CNC cut they are guaranteed to be square with studs located exactly where they need to be as per structural engineering specifications NO SPECIAL SKILLS NEEDED No Measuring No Room for Errors
16 Step 5: Insert studs Tools needed: Step ladder Screw gun, Pry bar Patented connectors based on steel framed construction methods Slide down engineered grooves in panels forming panel to panel connections and the structural members both at the same time. Note: the PanelSystems designs determine where the structural studs and connectors are placed
17 Finished top track Top track inserted into EPS panel and screwed to vertical studs
18 Exploded view of connections
19 Section through a typical panel shows double studs connecting panel to panel and either 16 on center for perimeter walls or 24 steel studs as shown above for interior walls.
20 Pre-cut T sections
21 Pre-cut corner sections
22 Column made from 4 pre-cut corners Columns are used for additional Structural support, HVAC (heating ventilation air conditioning systems) Plumbing and venting chases. Typically used in corners
23 90 Corner and T connected together
24 Foundation to wall connection Hurricane anchors solid steel connection from the roof to the foundation
25 Step 6: Laser level and brace walls before adding roof trusses
26 Step 7: Roof trusses added to walls a few hours after building walls
27 Compression ring holds 200 mph roof trusses securely together
28 Step 8: Install doors and windows
29 Window or door panel layout
30 Step 9: Roof panels are laid onto trusses and studs slid into location holes
31 Step 10: Roof studs are screwed to trusses with steel brackets
32 Roof panels from inside the house, showing stud perlins
33 Step11: StuccoMax is direct applied over the foam insulation panels
34 Window and Door trims cut from EPS foam are covered with StuccoMax
35 Step 12: Colored GigaRoof spray applied directly over the EPS foam Roof is R 45 G
36
37 GigaCrete coatings are added directly to the EPS foam, note the imbedded mesh. Interior PlasterMax and Exterior StuccoMax are used
38 Gutter system integrated into moulding for rain collection~ Doors added
39 Conduits are pre cut into panels ready to pull wiring.
40 Conduit or plumbing passing through walls Electrical wiring inside chase
41 Retrofit electrical after house is completed PlasterMax Mesh Cut flush Foam not yet cut Note the conduit and box is Foam glued into place and excess foam shaved flat, ready to be coated with PlasterMax Walls are rasped where needed to make flat
42 Foam shapes are precut and fitted over trusses
43 PlasterMax applied directly over EPS foam panels. All seam lines are covered over to create a seamless and durable ceramic finish.
44 Ceiling underside of roof panels and beams covering structural roof trusses Foam sheets are screwed into the steel studs Fire rated PlasterMax applied over the EPS foam
45 Finished PlasterMax over the foam interior wall panels Note: Optional storage area above bedroom and bathroom
46 Optional Magnesium board ceilings (no gypsum board) With PlasterMax knockdown texture coating
47 Step15: Window trims are added, screwed into steel studs, patched and ready for paint.
48 Step16: StuccoMax is washed to remove dust particles, primed and painted.
49 Simonton vinyl windows ( no wood ) comes in all standard sizes
50 End Result= Very energy efficient and virtually maintenance free living environment
51 StuccoMax 3/16 thick TOUGH ENOUGH TO DRIVE A TRUCK ON StuccoMax (exterior) is sprayed or troweled over foam
52 GIGAHouse SYSTEMS HAVE SO MANY USES The PanelSystems are ideal tent replacements creating secure shelters. Uses include HOMELAND SECURITY DOD, GOVERNMENT BUILDINGS, MILITARY F.E.M.A. FOREIGN AID AND DISASTER RELIEF SECURED FACILITIES AND SAFE ROOMS. FACILITIES REQUIRING HIGH SECURITY PROTECTION FROM EXTERNAL THREATS INCLUDING TERRORISM, HURRICANES,TORNADOS,EARTHQUAKES,FIRES,VANDALISM AND THEFT. Due to the materials lightweight and ease of rapid assembly, there may be no faster building method in the world than the GigaCrete panelsystem. PanelSystems can be used for single family housing or multi story applications, schools, hospitals, orphanages, retail centers, churches, temples, and many types of commercial structures. One factory can create onsite employment for thousands of un-skilled workers and quickly rebuild a devastated area, providing safe and affordable shelter.
53 SUSTAINABLE PanelSystems build strong, build safe, build fast Green Pre-Fab homes~ Quality home, Strength to withstand natural disasters 1. Completed rapidly with supervised local labor 2. Simplicity = speed = reduced cycle time=language barriers are minimized 3. High R values means less operating costs to heat or cool 4. Only healthy materials are used 5. No Portland cement used in the house structure 6. Exterior StuccoMax is WATERPROOF 7. Interior PlasterMax is the Worlds only fire rated, psi abuse resistant plaster designed specifically for applications over insulation foam Barrett Enterprises Inc~ The Green Building Products Store When ordering mention code BE GREEN! Shipped FOB Las Vegas NV
GigaHouse Specifications
GigaCrete Inc. 6775 Speedway Blvd. Suite M105 Las Vegas, NV 89115 Ph (702) 643-6363 Fax (702) 643 1453 www.gigacrete.com GigaHouse Specifications GigaHouse : Factory made highly insulated housing materials
More informationHigh Performance Insulating Concrete Form
Insulating Concrete Form High Performance Insulating Concrete Form The Best Way to Build! liteform.com FlexxBlock Insulating Concrete Forms PROVIDE sustainable, energy efficient building envelopes. LiteForm
More informationTechnical Data Sheet
Technical Data Sheet ProGUARD Concrete Insulated Sheathing Specifications & Installation Table Of Contents Product Description... pg. 1 Basic Use... pg. 1 Exterior Finishes... pg. 1 Standard Sizes... pg.
More informationIntroducing EF Block TM
Introducing EF Block TM Introduction to EF Block Building Materials Overview of EF Block and the competition The EF Block System Proprietary (Patent Pending) Plant, Product and Processes of the EF Block
More informationInsulated Concrete Forms (ICFs)
Insulated Concrete Forms (ICFs) Cover of Walls & Ceilings Magazine May 2006 ICFs Getting Attention Cover of Construction Dimensions Magazine June 2006 Table of Contents Construction Dimensions Magazine
More informationSIP Homes: Built for a Lifetime of Comfort and Value
Innovative Steel Structures (949) 607-9729 leosmarthomes@gmail.com SIP Homes: Built for a Lifetime of Comfort and Value In also offer high-performance, sustainable homes made with Structural Insulated
More informationGigaCrete Specification PlasterMax
GigaCrete Inc. 6775 Speedway Blvd. Suite M105 Las Vegas, NV 89115 Ph (702) 643-6363 Fax (702) 643 1453 www.gigacrete.com GigaCrete Specification PlasterMax PlasterMax : Fire Rated, Abuse Resistant Interior
More informationResidential Construction
Structural Insulated Panels (SIPs) are modern engineered building components that combine great structural strength with outstanding energy performance. ERECTING A STRUCTURALLY SOUND THERMALLY EFFICIENT
More informationDESIGNING SAFE ROOMS AND SAFE HOMES WITH LOGIX.
. Actual ICF-Built Home That Survived Katrina Table of Contents Section Page Overview Logix Wind Resistance Advantages...3 Logix Wall Engineering To 300 MPH Wind Rating...6 Fema-Compliant Design Specifications
More informationIssue Date: April 2003 Release: I. Product Specifications
Issue Date: April 2003 Release: I Product Specifications Forming System Components Standard System Commercial System Issue Date: April 2003 Release: I 1.1 Issue Date: April 2003 Release: I 1.2 Specification
More informationFIRESTOP JOINT SPRAY CFS-SP WB. 2mm (0.079") WET FILM ± 7.5 ± 5
Design No. CEJ 27 P (HI/JS 20-05) Table. CONCRETE FLOOR ASSEMBLY: Max. two-hour rated concrete floor assembly made from either lightweight or normal weight concrete with a density of 00-50 pcf, with a
More informationThermaSteel Corporation ASSEMBLY MANUAL
ThermaSteel Corporation ASSEMBLY MANUAL TABLE OF CONTENTS 1- INTRODUCTION 1.1 THERMASTEEL TM WALL PANELS 1.2 Drawing and Element Numbers 2- ASSEMBLY 2.1 Sequence of Assembly 2.2 Preparation of Foundation
More informationDesign No. HI/BP PERIMETER FIRE BARRIER SYSTEM Hilti, Inc. ASTM E 2307 Table 1
FIRESTOP JOINT SPRAY CFS-SP WB SILICONE JOINT SPRAY CFS-SP SIL F-RATING 2-HR. 2-HR. T-RATING -HR. -HR. APPLICATION THICKNESS PERIMETER FIRE BARRIER SYSTEM Hilti, Inc. ASTM E 2307 Table /8" WET FILM (/6"
More informationThe Ashland Project. Total Area: 1,778 Sq.Ft. 3 Bedroom, 2 Bath, 2 Car Garage
The Ashland Project Total Area: 1,778 Sq.Ft. 3 Bedroom, 2 Bath, 2 Car Garage The garage and bedroom extend from the front of this three bedroom home, drawing you visually into the entryway. Brick and stucco
More informationGigaCrete Specification PlasterMax. PlasterMax : Fire Rated Plaster for Direct Application to Insulated Concrete Forms (ICF) Interior Walls
GigaCrete Inc. 6775 Speedway Blvd. Suite M105 Las Vegas, NV 89115 Ph (702) 643-6363 Fax (702) 643 1453 www.gigacrete.com GigaCrete Specification PlasterMax PlasterMax : Fire Rated Plaster for Direct Application
More informationFOR RESIDENTIAL & LIGHT COMMERCIAL CONSTRUCTION
FOR RESIDENTIAL & LIGHT COMMERCIAL CONSTRUCTION IBC IRC International Building Code (IBC) & International Residential Code (IRC) approved Energy Efficient R-20 & R-30 Wall Systems Mold/Mildew Resistant
More informationGigaCrete Specification PlasterMax. PlasterMax : Fire Rated Plaster for Direct Application over Cement Masonry Units (CMU) Interior Walls
GigaCrete Inc. 6775 Speedway Blvd. Suite M105 Las Vegas, NV 89115 Ph (702) 643-6363 Fax (702) 643 1453 www.gigacrete.com GigaCrete Specification PlasterMax PlasterMax : Fire Rated Plaster for Direct Application
More informationFraming Methods Structural Components
Framing Methods Structural Components Balloon Framing *Balloon framing or Eastern framing the exterior studs run from the top of the foundation to the top of the highest level. Benefits of this type of
More informationProfessional Engineers Ontario West Toronto Chapter. Maziyar Bolour, P. Eng.
Professional Engineers Ontario West Toronto Chapter Maziyar Bolour, P. Eng. Slide 1 of 45 Learning Objectives At the end of this presentation, participants will be able to: describe an ICF and its components,
More informationPS 3000 Installation Manual Step-By-Step Procedures C.9. DOOR AND WINDOW OPENINGS C.9.1 PREPARE IN ADVANCE. C.9.2 VBUCK CONSTRUCTION.
C.9. DOOR AND WINDOW OPENINGS Openings for doors and windows are formed with bucks, or frames, which are constructed to the rough opening dimensions required for the doors and windows to be installed.
More information2013 COMMERCIAL PRODUCTS
2013 COMMERCIAL PRODUCTS EXPLORE GEOMETRY AND SPACE WITHOUT COMPROMISING BUILDING ENVELOPE PERFORMANCE Commercial design considerations come with very specific challenges that can t be addressed with just
More informationINSTALLATION MANUAL KOCH
INSTALLATION MANUAL KOCH TECHNICAL SYSTEMS GROUP PRE-FAB ACOUSTICAL/THERMAL PANELS AND ENCLOSURES GEORGE KOCH SONS, LLC TECHNICAL SYSTEMS GROUP 10 South Eleventh Avenue Evansville, Indiana 47744 812-465-9600
More informationDurakit Instant Houses
Durakit Instant Houses DuraKit is a company that was established to develop housing for the homeless internationally using environmentally friendly building practices. More than 75% of each Instant House
More informationINSTALLATION MANUAL. HIGH-R Insulated Ceiling and Wall Systems. Affiliations: th Street, Ames, IA
INSTALLATION MANUAL HIGH-R Insulated Ceiling and Wall Systems 2335 230th Street, Ames, IA 50014 888-292-2382 info@high-r.com www.high-r.com Affiliations: GSA Contract GS-07F-0215U TABLE OF CONTENTS SECTION
More informationThe original. insulation.
The original recycled rubber impact sound insulation. ESTABLISHED 2000. SOUND INSULATION Original. Tested. Guaranteed. Previously Known As Dodge-Regupol QT ACHIEVING KICK NOISE OUT. THE INDUSTRY S BEST
More informationGCT insulated concrete components are prefabricated lightweight structural sections consisting of an expanded polystyrene (EPS) core sandwiched betwee
GC T GULF CONCR ETE TECHNOLOGY SCIP Building System Made in USA www.gctm2.com GCT insulated concrete components are prefabricated lightweight structural sections consisting of an expanded polystyrene (EPS)
More informationThin Architectural Splitface Block Veneer Specification Guide
Thin Architectural Splitface Veneer System with AccuTab Technology R Thin Architectural Splitface Block Veneer Specification Guide Section 04711: Manufactured Concrete Veneer Use this specification guide
More informationInsulation. First Revison October DC14 Drainage Mat INSTALLATION GUIDE FOR RESIDENTIAL & COMMERCIAL APPLICATIONS
Insulation First Revison October 2016 DC14 Drainage Mat INSTALLATION GUIDE FOR RESIDENTIAL & COMMERCIAL APPLICATIONS 1. General Information This Guide describes the use of Kingspan GreenGuard DC14 Drainage
More informationMETALWorkS. RH200 Custom Hook-on Panels. General Installation Instructions. Ceiling 1.0 GENERAL Site Conditions Product Description
Ceiling Systems Between us, ideas become reality METALWorkS General Installation Instructions RH200 Custom Hook-on Panels 1.0 GENERAL 1.1. Product Description RH200 system is a downward accessible, metal
More informationICBO Evaluation Service, Inc Workman Mill Road, Whittier, California
Reissued June 1, 2002 ICBO Evaluation Service, Inc. 5360 Workman Mill Road, Whittier, California 90601 www.icboes.org Filing Category: DESIGN Concrete DURISOL WALL FORMS FOR CONCRETE CONSTRUCTION DURISOL
More informationTECHNICAL EVALUATION REPORT No. 27/2008/2060
TECHNICAL EVALUATION REPORT No. 27/2008/2060 Sheet 1 of 16 Sheets This report is a correct record of the measurements and observations made. The report is intended for the private information of those
More informationLOOSE LAY INSTALLATION GUIDE PAGE 1 of 6
INSTALLATION GUIDE PAGE 1 of 6 MATERIALS REQUIRED FOR INSTALLATION: Tape Measurer Square Ruler Utility Knife 100lb Roller (if using adhesive) ACCEPTABLE SUBFLOORS: Happy Feet International will not warrant
More informationSECTION UNIT MASONRY
SECTION 04200 UNIT MASONRY PART 1 GENERAL 1.01 SUMMARY A. Furnish labor, materials, and equipment and perform functions required in the installation and maintenance of the work covered by this Section.
More informationPolycrete Big Block Standard Specification
Polycrete Big Block Standard Specification SECTION 03 11 19 INSULATED CONCRETE FORMING 10/13 PART 1 GENERAL 1.1 REFERENCES The publications listed below form a part of this specification to the extent
More informationSTOP ANTIQUATED BUILDING PRACTICES STEP INTO THE 21st CENTURY
MEGCRETe PRODUCT LINE PRODUCT OVERVIEW FW SERIES LVL SERIES TS SERIES STOP ANTIQUATED BUILDING PRACTICES STEP INTO THE 21st CENTURY MEGCRETe Panelized Wall SystemS provide a total solution for healthy,
More informationProGUARD Guide Specification
ProGUARD Guide Specification MANUFACTURER Section: 072100 Insulating Sheathing T.Clear Corporation 3255 Symmes Rd. Hamilton, OH 45015 Phone: 800-544-7398 Phone: 513-870-9246 Fax: 513-870-9606 072113 Cementitious
More informationINNOVATION. TECHNOLOGY. SOLUTIONS. INSULATED PANELS SEE THE DIFFERENCE in appearance, value, performance and installation.
INNOVATION. TECHNOLOGY. SOLUTIONS. INSULATED PANELS SEE THE DIFFERENCE in appearance, value, performance and installation. 1 2 Leading the industry in technology, design flexibility, quality, and value
More informationGold Bond BRAND Gypsum Sheathing
BRAND 09 06 29 16 00/NGC 43/NGC brand is a moisture-resistant sheathing installed on the outside of exterior framing as a substrate for exterior claddings. It is manufactured with a treated water-resistant
More informationEnvelope Highlights Mandatory Measures Prescriptive High Performance Walls 150.1
Solutions for California Title 24 Title 24 Envelope Highlights Envelope Highlights Mandatory Measures 150.0 There are several new thresholds for mandatory envelope requirements including: Ceiling/Roof
More informationEXCEL Medical Waste - Equipment Installation Section SECTION GYPSUM BOARD
SECTION 09 29 00 GYPSUM BOARD PART 1 - GENERAL 1.1 DESCRIPTION This section specifies installation and finishing of gypsum board. 1.2 RELATED WORK A. Installation of steel framing members for walls, partitions,
More informationThe art. of building. Profit from modular construction! LIGHT STEEL FRAMING STRUCTURAL INSULATED PANELS CELLULOSE LIGHT CONCRETE MODULAR UNITS
The art of building Profit from modular construction! LIGHT STEEL FRAMING STRUCTURAL INSULATED PANELS CELLULOSE LIGHT CONCRETE MODULAR UNITS Profit from our experience! Our team has been involved in the
More informationWE International, Inc.
M E E T Y O U R R O U N D T H E Steel Frame Building Roof Application - Drape Method Ideal insulation for steel frame building application Quick and easy to install Provides reflective insulation for radiant
More informationICFs. Insulating Concrete Forms. Shorten Construction Schedule Enhance Comfort and Safety Reduce Energy Costs
ICFs Shorten Construction Schedule Enhance Comfort and Safety Reduce Energy Costs Build An Environmentally Friendly Home Add up residential heating and cooling, lighting, appliances and other electronic
More informationPROVIDING TODAY S WORLDWIDE BUILDING SOLUTIONS
PROVIDING TODAY S WORLDWIDE BUILDING SOLUTIONS Precision Foam Fabricators ( PFF ) is leading the worldwide movement for building with Structural Insulated Panels (SIPs). SIPs are the basic component to
More informationSECTION GYPSUM BOARD ASSEMBLIES
SECTION 09 21 16 GYPSUM BOARD ASSEMBLIES PART 1 GENERAL 1.1 SECTION INCLUDES A. Metal stud wall and ceiling framing, 20 gauge. B. Metal channel suspended ceiling framing. C. Gypsum board. D. Gypsum sheathing.
More informationFIRE PROTECTION AND PERFORMANCE DRY LINING BOARD THE ULTIMATE IN FIRE PROTECTION! 91 mins fire integrity and 86 mins fire insulation on 9mm board
THE ULTIMATE IN FIRE PROTECTION! 91 mins fire integrity and 86 mins fire insulation on 9mm board + Euroclass A1 Non-combustible FIRE PROTECTION AND PERFORMANCE DRY LINING BOARD Magply Fire PASSIVE FIRE
More informationWhat is NUFORM HOUSE KIT?
Introduction Nuform Building Technologies Inc. (NUFORM ) is creating a better way to deliver affordable housing the NUFORM HOUSE KIT is a solution for creating neighborhoods where people live with pride
More informationNortrax Section David Manchester Road, Ottawa NON-STRUCTURAL METAL FRAMING 16 May 2014 Page 1
16 May 2014 Page 1 PART 1 GENERAL 1.1 DESCRIPTION This section specifies steel studs wall systems, shaft wall systems, ceiling or soffit suspended or furred framing, wall furring, fasteners, and accessories
More informationSection 1 - Introduction 1.1 Introduction Welcome to Fox Blocks. You have made an excellent decision to use Fox Blocks Insulated Concrete Forms (ICFs)
Section 1 Introduction 1.1 Introduction 1.2 Company History 1.3 Description of General Types of ICF Wall System Products 1.4 Description of Fox Blocks ICF Wall System Products 1.5 The Fox Blocks Clever
More informationTABLE OF CONTENTS. 1.0 INTRODUCTION 1.1 Greenstone Structural Engineered Panels 1.2 Drawing and Element Numbers
version 2.5 updated as of 08.04.2017 2 TABLE OF CONTENTS 1.0 INTRODUCTION 1.1 Greenstone Structural Engineered Panels 1.2 Drawing and Element Numbers 2.0 ASSEMBLY 2.1 Sequence of Assembly 2.2 Preparation
More informationSECTION NON-STRUCTURAL METAL FRAMING
SECTION 09 22 16 PART 1 - GENERAL 1.1 DESCRIPTION A. This section specifies steel studs wall systems, shaft wall systems, ceiling or soffit suspended or furred framing, wall furring, fasteners, and accessories
More informationHenri Fennell, CSI/CDT ABX 2015
Henri Fennell, CSI/CDT ABX 2015 Henri is an architect and building envelope specialist with over forty years of experience in the construction industry. He was a pioneer in the solar industry, introduced
More informationFOCAL POINT RENDAPANEL TM CLADDING SYSTEM
FOCAL POINT RENDAPANEL TM CLADDING SYSTEM strength and durability SYSTEM INFORMATION & TECHNICAL SPECIFICATION V4 2002 Page 1 of 7 INTRODUCTION Monolithic Light Weight Cement Render Cladding RendaPanel
More informationFIRE PROTECTION AND PERFORMANCE DRY LINING BOARD THE ULTIMATE IN FIRE PROTECTION! 91 mins fire integrity and 86 mins fire insulation on 9mm board
THE ULTIMATE IN FIRE PROTECTION! 91 mins fire integrity and 86 mins fire insulation on 9mm board + Euroclass A1 Non-combustible FIRE PROTECTION AND PERFORMANCE DRY LINING BOARD MAGPLY FIRE PROTECTION BOARD
More informationPATENTED. StoneFit Wall System WITH DRYFIT TECHNOLOGY
PATENTED StoneFit Wall System WITH DRYFIT TECHNOLOGY StoneFit Wall System with DryFit Technology An innovative stone cladding solution that uses patented interlocking panels. Product Features REDUCED LABOR
More informationPRODUCTION SPECIFICATIONS INSULATED CONCRETE FORMS
PRODUCTION SPECIFICATIONS SECTION 03135 INSULATED CONCRETE FORMS PART 1 GENERAL 1.1 SECTION INCLUDES A. Insulated panel permanent concrete form system for: 1. Exterior structural wall panels. 2. Interior
More informationPRODUCTION SPECIFICATIONS INSULATED CONCRETE FORMS
PRODUCTION SPECIFICATIONS SECTION 03135 INSULATED CONCRETE FORMS PART 1 GENERAL 1.1 SECTION INCLUDES A. Insulated panel permanent concrete form system for: 1. Exterior structural wall panels. 2. Interior
More informationWorking with you to make life Better Presented by. Clever House - West Africa
Working with you to make life Better Presented by Clever House - West Africa The German founder of Clever House who invented and designed the Foam-Cement wall panel technology had a dream, and that dream
More informationtough by design. custom by choice kellyklosure.com Building innovative steel structures since 1968
tough by design. custom by choice. 800-228-7230 kellyklosure.com Building innovative steel structures since 1968 built well. built by you. Customized for a gritty power plant or an air-conditioned office,
More informationH I S T O R Y O F S U C C E S S
THE SYSTEM Composite Technologies Corporation (CTC) was founded in 1980 by Robert T. Long. His innovative thinking and vision led to the development of the THERMOMASS Building Insulation System. At the
More informationSept 30, 2004 Page 1 PRODUCT DESCRIPTION PRODUCT FEATURES
Sept 30, 2004 Page 1 PRODUCT FEATURES BASIC USES / RELATED USES LOGIX Insulated Concrete Forms are stackable, interlocking expanded polystyrene (EPS) blocks that serve as permanent formwork to create solid
More informationSECTION TILT-UP PRECAST CONCRETE SANDWICH PANELS. A. Work includes, but is not limited to, the following:
PART 1 GENERAL 1.01 SUMMARY SECTION 03460 TILT-UP PRECAST CONCRETE SANDWICH PANELS A. Work includes, but is not limited to, the following: 1. Architectural precast concrete sandwich wall panels. 2. Integral
More informationA-ONE Insulated Forms Installation Manual
A-ONE Insulated Forms Installation Manual Rockford, MN www.aoneform.com www.diversifoam.com info@diversifoam.com A-ONE Manual 180426.docx Disclaimer Notice The information in the A-ONE Insulated Forms
More informationDIVISION: CONCRETE SECTION: INSULATING CONCRETE FORMING REPORT HOLDER: DIVERSIFOAM PRODUCTS EVALUATION SUBJECT:
0 ICC ES Evaluation Report ICC ES 000 (800) 423 6587 (562) 699 0543 www.icc es.org Most Widely Accepted and Trusted ESR 1815 Reissued 10/2018 Revised 11/2018 This report is subject to renewal 10/2020.
More informationProGUARD DP The Game-changing Wall System
ProGUARD DP The Game-changing Wall System Arriscraft ARRIS-stack over ProGUARD DP Insulated Cement Board Panels, using Laticrete MVIS materials. PROGUARD DP INSULATED CONCRETE BOARD, manufactured by T.
More informationUnion County Vocational - Technical Schools Scotch Plains, New Jersey
SECTION 092216 - NON-STRUCTURAL METAL FRAMING PART 1 - GENERAL 1.1 RELATED DOCUMENTS A. Drawings and general provisions of the Contract, including General and Supplementary Conditions and Division 01 Specification
More informationPanelize Your Dreams. With Enercept, The Better Way To Build. Structural Insulated Panels The Builders Choice
Panelize Your Dreams With Enercept, The Better Way To Build. Structural Insulated Panels The Builders Choice www.enercept.com STRONGER ENERCEPT SIPS ARE 2 1/2 TIMES STRONGER THAN CONVENTIONAL STICK FRAMING.
More informationA. Description of Work: Work of this section includes self leveling underlayment for interior finish flooring but is not limited to, the following:
SECTION 03540 [03 54 13] Floor Underlayment PART 1 - GENERAL ***Notes to Architect are highlighted in red**** 1.01 SUMMARY A. Description of Work: Work of this section includes self leveling underlayment
More informationInstallation Guide Wall Panels
Installation Guide Wall Panels Jointless or Dry-Stacked Installation (Read Prior to installation) The MStone system is a jointless / dry-stacked installation where panels and corners fit tightly together
More information1/2 in. (12.7 mm) and 5/8 in. (15.9 mm) glass mesh. It has an exceptionally hard, durable surface that can withstand prolonged exposure to moisture.
BRAND 09 29 28 00/NGC 1/2 in. (12.7 mm) and 5/8 in. (15.9 mm) brand is a rigid substrate made of Portland cement, aggregate and glass mesh. It has an exceptionally hard, durable surface that can withstand
More informationGold Bond BRAND Kal-Kore Plaster Base
BRAND 09 29 22 00/NGC 39/NGC Kal-Kore Plaster Base brand Kal-Kore Plaster Base is a tapered-edge gypsum plaster base with 100-percent recycled gray absorptive face paper surface designed to permit rapid
More informationProject No: Pakenham Branch Library, Pakenham, Ontario Section DECEMBER, 2016 Page 1 of 6
DECEMBER, 2016 Page 1 of 6 1 GENERAL 1.01 RELATED SECTIONS.1 Section 01 33 00 - Submittal Procedures..2 Section 07 21 16 - Batt and Blanket Insulation..3 Section 07 92 10 - Sealants..4 Section 09 91 00
More informationConcrete Framing Systems - Walls and Columns
Concrete Framing Systems - Walls and Columns Casting a Concrete Wall Wall Footing Reinforcing Wall Forms Pouring Concrete Finishing the Concrete Controlling Cracking Insulating Concrete Forms (ICF) Tilt-Up
More informationROOT VEGETABLE STORAGE WAREHOUSES
TECHNICAL BULLETIN No.35-091212 WAREHOUSES Designers, builders and owners of root vegetable storage warehouses know that there are two key objectives to good design and construction of root storage facilities:
More informationDurisol: Insulated Concrete Form (ICF) Wall Forming System
Durisol: Insulated Concrete Form (ICF) Wall Forming System Bruce Coldham, Coldham Architects, LLC www.coldhamarchitects.com Affordable Comfort. - Westford, MA October, 2003 An explanation of the material
More information1 Exam Prep Prov Module: Thermal and Moisture Protection Questions and Answers
1 Exam Prep Prov Module: 27203-13 Thermal and Moisture Protection Questions and Answers 1. The R-value is a measure of the ability of a material to. A. Resist the passage of moisture B. Resist heat conduction
More informationPerimeter Relief and Control Joints in Fire-Rated Gypsum Board
Perimeter Relief and Control Joints in Fire-Rated Gypsum Board In multi-family residential construction, involving fire-rated assemblies stress relief in the firerated assemblies is important, but often
More informationEcohousing Building Systems Capability Document
Ecohousing Building Systems Capability Document In 2001 an International Patent application was filed by Tonny Bergqvist s Patent Attorneys; Titled: BUILDING STRUCTURE AND MODULAR CONSTRUCTION METHOD The
More informationSIPs Structural Insulated Panels System. The building technology of the future
SIPs Structural Insulated Panels System The building technology of the future What are SIPs? Structural Insulated Panels (SIPs) are prefabricated insulated structural elements for use in building walls,
More informationStructural Insulated Panels Dispelling the Myths to Give You the Green Edge with Surprising Paybacks By Patrick Egan, Thermocore Panel Systems
from Successful HOME BUILDING, September 2008 issue Structural Insulated Panels Dispelling the Myths to Give You the Green Edge with Surprising Paybacks By Patrick Egan, Thermocore Panel Systems In today
More informationThe Starbucks Project
The Starbucks Project Total Area: 1,738 Sq.Ft. Sarasota, FL Contractor: Innovative Construction Concepts of Florida Starbucks is a perfect example of the versatility that Structural Insulated Panel Systems
More informationDrywall and Plastering
Drywall and Plastering Drywall Drywall 120433 1 / 2 4 X 8 White Drywall Approx. 60/Lift None 120442 5 / 8 4 X 8 Firecode White Drywall Approx. 48/Lift None 120451 1 / 2 4 X 8 XP Drywall Approx. 48/Lift
More informationACCESSORY STRUCTURE Building permit information For 1 & 2-family dwellings
ACCESSORY STRUCTURE Building permit information For 1 & 2-family dwellings Building Safety Department 400-2 nd Street South St. Cloud, MN 56301 (320) 255-7239 A building permit is required for any accessory
More informationContinuous Insulation Systems for Exterior Walls
Continuous Insulation Systems for Exterior Walls High performance through sprayed-in-place foam insulation www.icynene.com Program Registration Icynene Inc. is a registered provider with The American Institute
More informationTILT-UP PRECAST CONCRETE SANDWICH PANELS. A. Work includes, but is not limited to, the following:
PART 1 GENERAL 1.01 SUMMARY SECTION 03460 TILT-UP PRECAST CONCRETE SANDWICH PANELS A. Work includes, but is not limited to, the following: 1. Architectural precast concrete sandwich wall panels. 2. Integral
More informationHigh-performance structural cement-bonded particle board (CBPB)
High-performance structural cement-bonded particle board (CBPB) for floors, roofs and walls fire resistant moisture resistant durable exceptional strength exceptional value THE PRODUCT Versaroc is a high-performance
More informationSept 30, 2004 Page 1
Sept 30, 2004 Page 1 This section includes a manufacturer's guide specification for TERRAFOAM EPS building insulation. Refer also to Product Description for detailed product properties, options, and other
More informationMID-RISE DESIGN & CONSTRUCTION
TECHNICAL BULLETIN No.38-021616 Rev072116 MID-RISE DESIGN & CONSTRUCTION Logix effective R-values range from R-24 to R-28+ Insulated concrete forms (ICF) are becoming a main stream choice for the construction
More informationGreenix 3w Emergency Shelters. SIP Supply, LLC
Greenix 3w Emergency Shelters SIP Supply, LLC Single Unit - Plan View 12.0 Feet Power Panel Generator Window 8.5 Feet Single Unit - Elevation Front View 12.0 Feet 7.5 Feet 4 x4 pressure treated timbers
More informationhome owner Building Has Evolved. TM
home owner Building Has Evolved. TM innovation makes us the better building choice. the principle is simple. NUDURA Insulated Concrete Forms are stay-in-place forms that offer you a variety of superior
More informationPANELIZED BUILDING SYSTEMS
PANELIZED BUILDING SYSTEMS CONSTRUCTSHIELD PRODUCT LINE FW SERIES FW SERIES LVL SERIES TS SERIES Frank Lloyd Wright designed using structural insulated panels. PRODUCT OVERVIEW STOP ANTIQUATED BUILDING
More informationSTARRCO M O D U L A R O F F I C E S Y S T E M S S P A C E S O L U T I O N S F O R T O D A Y A N D T O M O R R O W
STARRCO M O D U L A R O F F I C E S Y S T E M S SPACE SOLUTIONS FOR TODAY W.W. Cannon, Inc. 2653 Brenner Dr. Dallas, TX 75220 Phone: 214-357-2846 Toll Free: 800-442-3061 Fax: 214-357-4576 www.wwcannon.com
More informationMay 2013 CONSTRUCTION MANUAL
May 2013 CONSTRUCTION MANUAL Table of Contents Limitations... 1 Panel Specification... 2 Facing Material (OSB)... 2 Adhesive Material... 2 Core Material... 2 Panel Weight... 3 Panel Insulation... 3 Panel
More informationThermasheath-XP. Insulation for Exposed Use
Insulation for Exposed Use PRODUCT DESCRIPTION Rmax Thermasheath-XP is an energy-efficient thermal insulation board composed of a closed-cell polyisocyanurate (Polyiso) foam bonded to durable, embossed
More informationTitle: Building Construction for the Fire Service. Time: 3 hours. Teaching Materials: White board Building Construction for the Fire Service (PDF)
Title: Building Construction for the Fire Service Time: 3 hours Teaching Materials: White board Building Construction for the Fire Service (PDF) Motivation: With the evolution of newer building construction
More informationTRIDIPANEL The Disaster Proof Way to Build - FAQ's
TRIDIPANEL The Disaster Proof Way to Build - FAQ's 1. WHAT IS TRIDIPANEL? HOW IS IT MADE? WHAT IS IT MADE OF? The Tridipanel is an insulated stay in place form. When Portland Cement is applied, by any
More informationINDUSTRIAL GUARDRAIL SYSTEMS
INDUSTRIAL GUARDRAIL SYSTEMS STRONGEST GUARDRAIL ON THE MARKET MANUFACTURED IN THE U.S.A. BEST PRICES MOST VARIETIES HEAVY DUTY ONE-LINE OR TWO-LINE Posts: 4 Sched 80 pipe Rail: 6 Sched 40 pipe Sleeved
More informationCarroll County Bureau of Permits and Inspection Residential Code Compliance Guidelines Detached Garage
Carroll County Bureau of Permits and Inspection Residential Code Compliance Guidelines Detached Garage The following list of code requirements is intended to assist you in complying with the Code of Public
More informationSECTION WALL AND DOOR PROTECTION
PART 1 - GENERAL 1.1 DESCRIPTION: SECTION 10 26 00 WALL AND DOOR PROTECTION SPEC WRITER NOTE: Delete between // // if not applicable to project. Also delete any other item or paragraph not applicable to
More information