RS2650B ZERO TURN MOWER

Size: px

Start display at page:

Download "RS2650B ZERO TURN MOWER"

Allyson Warren
5 years ago
Views:

RS2650B ZERO TURN MOWER Published 10/12 PARTS MANUAL SECTION 99 An Operator s Manual was shipped with the

The Operator s Manual is an integral part of the safe operation of this machine and must be maintained with

READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating

1 RS2650B ZERO TURN MOWER Published 10/12 PARTS MANUAL SECTION 99 An Operator s Manual was shipped with the equipment. The Operator s Manual is an integral part of the safe operation of this machine and must be maintained with the unit at all times. READ, UNDERSTAND, and FOLLOW the Safety and Operation Instructions contained in this manual before operating the equipment. If the Operator s Manual is not with the equipment, contact your dealer or Bush Hog to obtain a copy before operating the equipment. Important Operating and Safety Instructions are found in the Mower Safety Video that can be instantly accessed on the internet at:

2 TABLE OF CONTENTS Mower Deck Height Adjustment Mower Deck Assembly Front Frame Assembly Control Assembly Engine Assembly Driving System Fuel Tank Assemblies Electrical System Decals -Safety Decals - Operational Decals - Marking

3 LIMITED WARRANTY BUSH HOG, INC RS2650B MOWER Bush Hog, Inc, ("Bush Hog") warrants that the Bush Hog RS2650B Mower ("Mower") will be free from defects in material and workmanship for a period of two years in a residential application from the original date of retail purchase. During the warranty period, Bush Hog will repair or replace, at its discretion, any Mower or part thereof which is found to be defective in material or workmanship. This warranty specifically excludes wear items, including but not limited to belts, blades, and tires. This warranty also specifically excludes parts covered by another manufacturer's warranty. This limited warranty extends only to the original retail purchaser ("Owner") of a Mower. It is not transferable. This warranty extends only to those Mowers purchased for private residential use. A Mower purchased for any other reason, for example as a rental unit, will not be warranted under the same terms and conditions as set forth herein. Proof of purchase will be required to substantiate all warranty claims. All warranty work must be performed by an authorized Bush Hog Dealer. Any work done on or to the Mower by anyone other than an authorized Bush Hog Dealer, including the original purchaser, voids all provisions of this warranty except those provisions which limit Bush Hog's liability (as set forth below). Any Mower or part thereof which, in Bush Hog's sole discretion is deemed defective shall be repaired or replaced, at Bush Hog's option, without charge for parts or labor. To take advantage of this warranty, the Mower must be returned to an authorized Bush Hog Dealer within the warranty period. The cost of delivering the Mower to the authorized Dealer and return delivery shall be the responsibility of the Owner. Bush Hog's sole responsibility with any claim made under this warranty is limited only to repairing or replacing the mower or a defective part thereof, and no claim of breach of warranty shall because for rescission, cancellation, or voiding the contract of sale of the Mower. This warranty does not extend to any Mower or part thereof which has been misused, neglected, damaged, abused, not properly installed or maintained, altered, or which has been operated in any way contrary to the operating instructions as specified in the Owner/Operator's Manual. This warranty does not extend to any repair or replacement made necessary by normal use. This warranty does not extend to the engine which is warranted separately by the engine manufacturer. THE WARRANTY EXPRESSED HEREIN IS IN LIEU OF OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING, WITHOUT LIMITA- TION, ANY IMPLIED WARRANTY OR MER- CHANTIBILITY OR FITNESS FOR A PARTICULAR USE, AND IS IN LIEU OF ANY AND ALL OTHER OBLIGATIONS OR LIABILITY ON BUSH HOG'S PART. UNDER ANY AND ALL CIRCUMSTANCES, BUSH HOG'S TOTAL LIABILITY TO OWNER FOR ANY AND ALL CLAIMS, LOSSES, OR DAMAGES, INCLUDING LOSS OF PROFITS, ARISING OUT OF ANY CAUSE WHATSOEVER, WHETHER BASED IN CONTRACT, NEGLI- GENCE, OR OTHER TORT, STRICTLIABILITY, BREACH OF WARRANTY, OR OTHERWISE, SHALL IN NO EVENT EXCEED THE PUR- CHASE PRICE OF THE MOWER. IN NO EVENT SHALL BUSH HOG BE RESPONSIBLE FOR SPECIAL, INCIDENTAL, CONSEQUEN- TIAL, OR EXEMPLARY DAMAGES.

4 NOTES Use this space to make any notes concerning this machine for future reference

5 MOWER DECK HEIGHT ADJUSTMENT ILLUSTRATION & PARTS LISTING No. No. Req d Hex Hd Bolt M6 16 A/R Flat Washer M10 A/R Locknut M10 A/R Locknut M8 A/R Hex Hd Bolt M10 30 A/R Grease Fitting M Hex Hd Bolt M8 20 A/R Locknut M6 A/R Bolt M10 25 A/R Bolt M8 45 A/R Deck Lift Assist Spring Washer 10 A/R No. No. Req d Lift Lever Handle Grip Swivel Deck Lift Shaft Weldment W Lift Shaft Mount B Bushing Tracking Plate Bolt M10 30 A/R Bolt M8 30 A/R Hex Hd Bolt M6 20 A/R Cutting Height Bracket 1

6 Land Maintenance Repair Parts Manual November, 2012 MOWER DECK ASSEMBLY ILLUSTRATION

7 Land Maintenance Repair Parts Manual November, 2012 MOWER DECK ASSEMBLY PARTS LISTING No. No. Req,d Hex Hd Bolt M6 16 A/R Flat Washer M6 A/R RH Belt Cover Discharge Chute Torsion Spring Bolt M8 160 A/R Flat Washer M10 A/R Locknut M10 A/R Washer M10 A/R Anti Scalp Roller W Scalp Roller Bushing W Disk Spring Washer M Bolt M A/R Hair Pin Washer M14 A/R Front Suspension Bracket Locknut M8 A/R Front Deck Support Rod Support Rod Pivot Bushing Support Rod Spacer Nut M14 A/R Bearing Cover W Stationary Idler 1 24 AN03495 Bearing RS 3 25 B Snap Ring M Idler Spacer Bushing Deck Stabilizer Rod Flat Washer M12 A/R Hex Hd Bolt M10 30 A/R Deck Lift Bracket Deck lift Rod Washer M12 A/R Washer M10 A/R Flange Bushing Grease Fitting M6 1 No. No. Req,d Pivot Tensioner Mount Deck Belt Tension Spring Bolt M10x35 A/R LH Belt Cover Deck Belt Tension Arm Bearing Spacer W Tension Pulley Bearing Spacer M W Tension Pulley Brace Hex Hd Bolt M10x25 A/R W Blade Drive Belt Deck Weldment Bolt M10x110 A/R Hex Hd Bolt M10x70 A/R Hex Hd Bolt M8x25 A/R Hex Hd Bolt M10x120 A/R Deck Wheel Spacer Nut M20 A/R Disk Spring Washer M Blade Pulley Top Dust Cover Bearing RS Spindle Bearing Spacer Spindle Housing 3 60 B Snap Ring M Lower Dust Guard Spindle Shaft 3 63 B1096-B625 Key B6x Blade Disk Spring Washer M BH Bolt M16x1.5x Spindle Assembly Nut M14 A/R Tension Pulley Assembly Tension Pulley Assy. Drive

8 FRONT FRAME ASSEMBLY ILLUSTRATION

9 FRONT FRAME ASSEMBLY PARTS LISTING No. No. Req d Locknut M8 A/R Hex Hd Bolt M8 20 A/R Main Frame W Foot Plate W Control Panel Hex Hd Bolt M8 16 A/R Split Lock Washer M8 A/R Flat Washer M8 A/R Control Panel Mount Front RH Tank Bracket W Rubber Bushing M Front LH Tank Bracket Rear RH Tank Bracket 1 79 B Grease Fitting M Hex Hd Bolt M8 60 A/R Bumper Bolt M8 70 A/R Rear Engine Guard (B&S) Rear LH Tank Bracket W Engine Base W Frame Brace LZ Rubber Bushing M W Battery Tray W Stabilizer Arm Mount Caster Pivot Cap Nut M16 A/R Spring washer M B Bearing 329/ B Grease Seal Caster Wheel Yoke Bolt M A/R W Caster Wheel Bushing W Bearing W Rim B Grease Fitting M W Tire XSZ Hair Pin Foot Plate Pivot Bushing Bolt M8 25 A/R Bolt M6 16 A/R Locknut M6 A/R Bumper Block Screw M6 30 A/R Deck Stop Bolt M6 20 A/R Safety Guard Nut M12 A/R Front Wheel Pull Ring Fixed Plate Owner's Manual

10 CONTROL ASSEMBLY ILLUSTRATION

11 CONTROL ASSEMBLY PATRTS LISTING No. No. Req d. No. No. Req d Flat Washer M6 A/R Locknut M10 A/R Locknut M8 A/R Grease Fitting M Hex Hd Bolt M8 20 A/R Split Lock Washer M8 A/R Flat Washer M8 A/R Hex Hd Bolt M8 20 A/R Hair Pin A/R A Right Handle Handle Grip Hex Hd Bolt M8 25 A/R RH Handle Mount Assembly W RH Control link Shoulder Pin Locknut M8 A/R Neutral Buckle M Screw M8 A/R 114 SIBJK8T Ball Joint B Hex Hd Bolt M8 40 A/R Damper Ignition Switch W Choke Cable Throttle Control Knob Throttle Control Assembly Bolt M6 16 A/R PTO Switch A Three Way Valve Locknut M6 A/R Right Switch Bracket W Brake Cable Cable Mount Bracket Brake Adjustment Link Seat A Seat Plate Bolt M10 25 A/R Hex Hd Bolt 5/16-18UNC A/R A Left Handle LH Handle Mount Assembly Left Switch Bracket W Left Control Link Axle Pin Nut M6 A/R Split Lock Washer M6 A/R Switch (Normal Open) A Seat Switch Screw ST A/R Washer Seat Rail W Pivot Shaft W Stop Bracket RH Torsion Spring W Torsion Spring, RH B Bearing Washer M6 A/R Pivot Block Weldment Right Brake Panel Operating Pin Roll Washer M12 A/R 269 B Pin Handle Mount Block W Spring B308-4 Steel Ball SR Washer M8 A/R Stop Bracket LH Torsion Spring Torsion Spring, LH Left Brake Panel Seat Pull Rod

12 ENGINE ASSEMBLY ILLUSTRATION

13 ENGINE ASSEMBLY PARTS LISTING No. No. Req d Locknut M10 A/R Washer 2 13 B Bolt M A/R Locknut M8 A/R Flat Washer M8 A/R Hex Hd Bolt M8 25 A/R Three Arm Knob Fan Cover Wing Nut M6 A/R Battery Strap Battery 12V 33AH A/R Spring Cap Spring Bolt M8 45 A/R W Clutch Stop Spacer Washer M8 A/R Clutch Stop Strap Rubber Washer M Clutch Stop Spacer Bolt M8 100 A/R Hex Hd Bolt M8 35 A/R Engine Shaft Spacer W Pump Drive Pulley Key Electric Clutch Bolt 7/16-20UNF 3 A/R W Tension Pulley Assembly Tension Pulley Spring W Pump Drive Belt Battery Clamp Bolt Bolt M10 60 A/R Tension Idler B RS Bearing RS B Snap Ring M W Tension Pulley Spacer W Pump Tension Arm W Tension Idler Spacer M B Bearing W Pivot Bushing Washer M11 A/R W BS Engine W/Muffler Washer M8 A/R 283 B Hose clamp Muffler Adaptor (B&S) Oil Filter Washer M

14 DRIVING SYSTEM ILLUSTRATION & PARTS LISTING No. No. Req,d Hex Hd Bolt M6 16 A/R Flat Washer M6 A/R Flat Washer M10 A/R Lockknut M10 A/R Locknut M8 A/R Flat Washer M8 A/R Hex Hd Bolt M8 60 A/R Bolt M8 70 A/R 103 XSZ Hair Pin Bolt M8 25 A/R Bolt M10 25 A/R Split Lock Washer M6 A/R Bolt M10 60 A/R Right Pressure Relief Rod 1 No. No. Req,d Fixed Plate, Front Bolt M10 50 A/R Left Pressure Relief Rod Washer M10 A/R Right Drive Axle W Axle Weldment Left Drive Axle Nut 1/2-20UNF A/R Tire Outer Axle Mounting Bracket LH Inner Axle Mount Bracket RH Inner Axle Mount Bracket Washer A/R Washer M6 A/R

15 Land Maintenance Repair Parts Manual November, 2012 FUEL TANK ASSEMBLY ILLUSTRATION & PARTS LISTING No. No. No Hex Hd Bolt M8 16 A/R Flat Washer M8 A/R Lock Washer M8 A/R Fuel Tank Cap B Grommet B Hose Clamp P68F Flexible Clamp Right Fender Left Fuel Tank Assembly Vent Valve Vent Grommet Storage Tray Fuel Line (Φ8.5 2) Washer A/R Washer M5 A/R British Bolt 10-24UNC 1/2 A/R Right-angle Switch Valve Fuel Line Adaptor Clamp Fuel Line Left Fuel Tank

16 Land Maintenance Repair Parts Manual November, 2012 ELECTRICAL SYSTEM ILLUSTRATION AND PARTS LISTING No. No. Req d Battery 12V 33AH A/R Switch (Normal Open) Ignition Switch PTO Switch Fuse 20A Relay 12V Starter Relay Battery Cables(+550) Nut 5/16-24UNF A/R Relay Cable Cover Cover (positive) Cover (negative) Wiring Harness (B&S) Relay Motor Wiring Negative Wire

17 DECALS - SAFTEY p p DANGER To avoid serious injury or death: Avoid blades unless engine and blades are stopped No. No. Req d W Cautio Decal - Guard W Caution Decal - Rear Guard W Caution Decal - Discharge Warning W Operational Warning Decal W Danger Decal - Blades Rotating Parts Decal W Caution Decal - Blade Replacement W Danger Decal - Shield Mising W EPA Decal

18 DECALS - OPERATIONAL No. No. Req d W Ignition Switch Decal W PTO Run/Stop Decal Fuel Valve Decal W Choke Decal Cutting Height - Inner W Cutting Height Locator Decal Transaxle Release L.H. Decal Transaxle Release R.H. Decal W Motion Control L.H. Decal W Motion Control R.H. Decal W International Instruction Decal Deck Belt Routing Decal Cutting Height Decal - Outer

19 DECALS - MARKING No. No. Req d Bush Hog Logo Decal Model Decal RS2650B Decal W 50 Decal Bush Hog Logo Decal

22 2501 GRIFFIN AVE. SELMA, AL (334) (334) PARTS ORDERING FAX

BUSH HOG LAND MAINTENANCE REPAIR PARTS MANUAL MODELS: HS1736B, HS1742B, HS1836B, HS1842B, HS2036K, HS2042K HOME SERIES ZERO TURN MOWER SECTION: 85

BUSH HOG LAND MAINTENANCE REPAIR S MANUAL MODELS: HSB, HSB, HSB, HSB, HS0K, HS0K HOME SERIES ZERO TURN MOWER SECTION: 0 Griffin Ave. Selma, AL 0 () -00 Parts Ordering -00-0- Fax -00-- www.bushhog.com OCTOBER,00