No violations were noted at the time of the inspection. Please refer to the attached inspection report for any comments.
|
|
|
- Sara Cori Farmer
- 5 years ago
- Views:
Transcription
1 April 25, 2016 Mary Emily Slate, Vice President Nucor Steel P.O. Box 30 Armorel, AR RE: Nucor Steel/Hickman Hill Inspection AFIN: Permit No.: AR Dear Ms. Slate: On March 29, 2016, I performed a Compliance Sampling Inspection of the above referenced facility in accordance with the provisions of the Federal Clean Water Act, the Arkansas Water and Air Pollution Control Act, and the regulations promulgated thereunder. A copy of the inspection report is enclosed for your records. No violations were noted at the time of the inspection. Please refer to the attached inspection report for any comments. If I can be of any assistance, please contact me at ext.-15 or frasher@adeq.state.ar.us. Sincerely, Sarah Frasher District 3 Field Inspector Water Division Page 1 of 32
2 WATER DIVISION INSPECTION REPORT AFIN: PERMIT #: AR DATE: 3/29/2016 COUNTY: 47 Mississippi PDS #: MEDIA: WN GPS LAT: LONG: LOCATION: Entrance FACILITY INFORMATION INSPECTION INFORMATION NAME: Nucor Steel/Hickman Hill LOCATION: FACILITY TYPE: 2 - Industrial INSPECTOR ID#: S - State FACILITY EVALUATION RATING: INSPECTION TYPE: 7301 East CR Satisfactory Compliance Sampling CITY: DATE(S): ENTRY TIME: EXIT TIME: PERMIT EFFECTIVE DATE: Blytheville 3/29/ :50 15:15 7/1/2011 RESPONSIBLE OFFICIAL 3/30/ :25 11:40 PERMIT EXPIRATION DATE: NAME: / TITLE 6/30/2016 Mary Emily Slate / Vice President COMPANY: FAYETTEVILLE SHALE RELATED: N Nucor Steel MAILING ADDRESS: P.O. Box 30 CITY, STATE, ZIP: Armorel AR PHONE & EXT: / FAX: / CONTACTED DURING INSPECTION: No FAYETTEVILLE SHALE VIOLATIONS: N INSPECTION PARTICIPANTS NAME/TITLE/PHONE/FAX/ /ETC.: Wayne Turney/Environmental Manager/ ext Kimberly Rhodes/Environmental Coordinator/ ext Corey Morrow/Environmental Engineer/ ext Jay Mitchell/Coldwell and Sanitary Wastewater Operator Robert Chandler/Hot Mill Water Operator J.D. Harris/ Environmental Coordinator AREA EVALUATIONS (S=Satisfactory, M=Marginal, U=Unsatisfactory, N=Not Applicable/Evaluated) S PERMIT S FLOW MEASUREMENT N STORMWATER S RECORDS/REPORTS S LABORATORY S FACILITY SITE REVIEW S OPERATION & MAINTENANCE S EFFLUENT/RECEIVING WATER S SELF-MONITORING PROGRAM S SAMPLING S SLUDGE HANDLING/DISPOSAL N PRETREATMENT N OTHER: SUMMARY OF FINDINGS No violations were noted at the time of the inspection. Samples were collected and analyzed for various water quality parameters at Outfall 002 and Outfall 004. No permit violations were noted. Please view attached Tables 1-4 for further reference. GENERAL COMMENTS Brent Walker, District 3 Water Inspector, and Jason Bolenbaugh, Inspection Branch Manager, also participated in this inspection. The facility should remember to record instantaneous flow for grab samples. This flow measurement is used to calculate the mass loading of the sample. Totalizers should be used to record flow for the majority of the day the composite sample was collected. INSPECTOR S SIGNATURE: Sarah Frasher DATE: 4/21/2016 SUPERVISOR S SIGNATURE: Jason Bolenbaugh DATE: 4/25/2016 Inspection Report Page 2 of 32
3 SECTION A: PERMIT VERIFICATION PERMIT SATISFACTORILY ADDRESSES OBSERVATIONS S M U NA NE DETAILS: 1. CORRECT NAME AND MAILING ADDRESS OF PERMITTEE: Y N NA NE 2. NOTIFICATION GIVEN TO EPA/STATE OF NEW DIFFERENT OR INCREASED DISCHARGES: Y N NA NE 3. NUMBER AND LOCATION OF DISCHARGE POINTS AS DESCRIBED IN PERMIT: Y N NA NE 4. ALL DISCHARGES ARE PERMITTED: Y N NA NE SECTION B: RECORDKEEPING AND REPORTING EVALUATION RECORDS AND REPORTS MAINTAINED AS REQUIRED BY PERMIT S M U NA NE DETAILS: 1. ANALYTICAL RESULTS CONSISTENT WITH DATA REPORTED ON DMRS: Y N NA NE 2. SAMPLING AND ANALYSES DATA ADEQUATE AND INCLUDE: S M U NA NE a. DATES AND TIME(S) OF SAMPLING: Y N NA NE b. EXACT LOCATION(S) OF SAMPLING: Y N NA NE c. NAME OF INDIVIDUAL PERFORMING SAMPLING: Y N NA NE d. ANALYTICAL METHODS AND TECHNIQUES: Y N NA NE e. RESULTS OF CALIBRATIONS: Y N NA NE f. RESULTS OF ANALYSES: Y N NA NE g. DATES AND TIMES OF ANALYSES: Y N NA NE h. NAME OF PERSON(S) PERFORMING ANALYSES: Y N NA NE 3. LABORATORY EQUIPMENT CALIBRATION AND MAINTENANCE RECORDS ADEQUATE: S M U NA NE 4. PLANT RECORDS INCLUDE SCHEDULES, DATES OF EQUIPMENT MAINTENANCE AND REPAIR: S M U NA NE 5. EFFLUENT LOADINGS CALCULATED USING DAILY EFFLUENT FLOW AND DAILY ANALYTICAL DATA: Y N NA NE SECTION C: OPERATIONS AND MAINTENANCE TREATMENT FACILITY PROPERLY OPERATED AND MAINTAINED S M U NA NE DETAILS: 1. TREATMENT UNITS PROPERLY OPERATED: S M U NA NE 2. TREATMENT UNITS PROPERLY MAINTAINED: S M U NA NE 3. STANDBY POWER OR OTHER EQUIVALENT PROVIDED: S M U NA NE 4. ADEQUATE ALARM SYSTEM FOR POWER OR EQUIPMENT FAILURES AVAILABLE: Radio alarm notifies employees S M U NA NE 5. ALL NEEDED TREATMENT UNITS IN SERVICE: S M U NA NE 6. ADEQUATE NUMBER OF QUALIFIED OPERATORS PROVIDED: S M U NA NE 7. SPARE PARTS AND SUPPLIES INVENTORY MAINTAINED: S M U NA NE 8. OPERATION AND MAINTENANCE MANUAL AVAILABLE: Y N NA NE 9. STANDARD OPERATING PROCEDURES AND SCHEDULES ESTABLISHED: Y N NA NE 10. PROCEDURES FOR EMERGENCY TREATMENT CONTROL ESTABLISHED: Y N NA NE 11. HAVE BYPASSES/OVERFLOWS OCCURRED AT THE PLANT OR IN THE COLLECTION SYSTEM IN THE LAST YEAR: Y N NA NE 12. IF SO, HAS THE REGULATORY AGENCY BEEN NOTIFIED: Y N NA NE 13. HAS CORRECTIVE ACTION BEEN TAKEN TO PREVENT ADDITIONAL BYPASSES/OVERFLOWS: Y N NA NE 14. HAVE ANY HYDRAULIC OVERLOADS OCCURRED AT THE TREATMENT PLANT: Y N NA NE 15. IF SO, DID PERMIT VIOLATIONS OCCUR AS A RESULT: Y N NA NE Inspection Report Page 3 of 32
4 SECTION D: SAMPLING PERMITTEE SAMPLING MEETS PERMIT REQUIREMENTS S M U NA NE DETAILS: 1. SAMPLES TAKEN AT SITE(S) SPECIFIED IN PERMIT: Outfall 004 and Outfall 002 Y N NA NE 2. LOCATIONS ADEQUATE FOR REPRESENTATIVE SAMPLES: Y N NA NE 3. FLOW PROPORTIONED SAMPLES OBTAINED WHEN REQUIRED BY PERMIT: Y N NA NE 4. SAMPLING AND ANALYSES COMPLETED ON PARAMETERS SPECIFIED IN PERMIT: Y N NA NE 5. SAMPLING AND ANALYSES PERFORMED AT FREQUENCY SPECIFIED IN PERMIT: Y N NA NE 6. SAMPLE COLLECTION PROCEDURES ADEQUATE: Y N NA NE a. SAMPLES REFRIGERATED DURING COMPOSITING: Y N NA NE b. PROPER PRESERVATION TECHNIQUES USED: Y N NA NE c. CONTAINERS AND SAMPLE HOLDING TIMES CONFORM TO 40 CFR 136: Y N NA NE 7. IF MONITORING IS PERFORMED MORE OFTEN THAN REQUIRED ARE RESULTS REPORTED ON THE DMR: Y N NA NE SECTION E: FLOW MEASUREMENT PERMITTEE FLOW MEASUREMENT MEETS PERMIT REQUIREMENTS DETAILS: 1. PRIMARY FLOW MEASUREMENT DEVICE PROPERLY INSTALLED AND MAINTAINED: Yes TYPE OF DEVICE: For Outfall 004: Rosemount Flow Meter. For Outfall 002: 60 v-notch weir S M U NA NE Y N NA NE 2. FLOW MEASURED AT EACH OUTFALL AS REQUIRED: Y N NA NE 3. SECONDARY INSTRUMENTS (TOTALIZERS, RECORDERS, ETC.) PROPERLY OPERATED AND MAINTAINED: For Outfall 002: ISCO 4280 Bubbler Flow Meter Y N NA NE 4. CALIBRATION FREQUENCY ADEQUATE: Once a year Y N NA NE 5. RECORDS MAINTAINED OF CALIBRATION PROCEDURES: Y N NA NE 6. CALIBRATION CHECKS DONE TO ASSURE CONTINUED COMPLIANCE: Y N NA NE 7. FLOW ENTERING DEVICE WELL DISTRIBUTED ACROSS THE CHANNEL AND FREE OF TURBULENCE: Y N NA NE 8. FLOW MEASUREMENT EQUIPMENT ADEQUATE TO HANDLE EXPECTED RANGE OF FLOW RATES: Y N NA NE 9. HEAD MEASURED AT PROPER LOCATION: Y N NA NE SECTION F: LABORATORY PERMITTEE LABORATORY PROCEDURES MEET PERMIT REQUIREMENTS DETAILS: S M U NA NE 1. EPA APPROVED ANALYTICAL PROCEDURES USED (40 CFR FOR LIQUIDS, 503.8(B) FOR SLUDGES) : Y N NA NE 2. IF ALTERNATIVE ANALYTICAL PROCEDURES ARE USED, PROPER APPROVAL HAS BEEN OBTAINED: Y N NA NE 3. SATISFACTORY CALIBRATION AND MAINTENANCE OF INSTRUMENTS AND EQUIPMENT: Y N NA NE 4. QUALITY CONTROL PROCEDURES ADEQUATE: Y N NA NE 5. DUPLICATE SAMPLES ARE ANALYZED >10% OF THE TIME: Y N NA NE 6. SPIKED SAMPLES ARE ANALYZED >10% OF THE TIME: Y N NA NE 7. COMMERCIAL LABORATORY USED: Y N NA NE a. LAB NAME: American Interplex b. LAB ADDRESS: Little Rock, AR c. PARAMETERS PERFORMED: CBOD5, TSS, NH3-N, FCB, O & G, Lead total recoverable, Zinc total recoverable, Nickel total recoverable, Chromium total recoverable, and Acute WET Testing 8. BIOMONITORING PROCEDURES ADEQUATE: Y N NA NE a. PROPER ORGANISMS USED: Y N NA NE b. PROPER DILUTION SERIES FOLLOWED: Y N NA NE c. PROPER TEST METHODS AND DURATION: Y N NA NE d. RETESTS AND/OR TRE PERFORMED AS REQUIRED: Y N NA NE Inspection Report Page 4 of 32
5 SECTION G: EFFLUENT/RECEIVING WATERS OBSERVATIONS BASED ON VISUAL OBSERVATIONS ONLY S M U NA NE DETAILS: OUTFALL #: OIL SHEEN GREASE TURBIDITY VISIBLE FOAM FLOATING SOLIDS COLOR OTHER 004 None None Low None None clear None None Low None None clear SECTION H: SLUDGE DISPOSAL SLUDGE DISPOSAL MEETS PERMIT REQUIREMENTS S M U NA NE DETAILS: Disposed at the Mississippi County Landfill 1. SLUDGE MANAGEMENT ADEQUATE TO MAINTAIN EFFLUENT QUALITY: S M U NA NE 2. SLUDGE RECORDS MAINTAINED AS REQUIRED BY 40 CFR 503: S M U NA NE 3. FOR LAND APPLIED SLUDGE, TYPE OF LAND APPLIED TO: (E.G., FOREST, AGRICULTURAL, PUBLIC CONTACT SITE): SECTION I: SAMPLING INSPECTION PROCEDURES SAMPLE RESULTS WITHIN PERMIT REQUIREMENTS S M U NA NE DETAILS: 1. SAMPLES OBTAINED THIS INSPECTION: Y N NA NE 2. TYPE OF SAMPLE: GRAB: COMPOSITE: METHOD: Composite Sampler FREQUENCY: 24-hours 3. SAMPLES PRESERVED: Y N NA NE 4. FLOW PROPORTIONED SAMPLES OBTAINED: Y N NA NE 5. SAMPLE OBTAINED FROM FACILITY'S SAMPLING DEVICE: Y N NA NE 6. SAMPLE REPRESENTATIVE OF VOLUME AND NATURE OF DISCHARGE: Y N NA NE 7. SAMPLE SPLIT WITH PERMITTEE: Y N NA NE 8. CHAIN-OF-CUSTODY PROCEDURES EMPLOYED: Y N NA NE 9. SAMPLES COLLECTED IN ACCORDANCE WITH PERMIT: Y N NA NE SECTION J: STORM WATER POLLUTION PREVENTION PLAN STORM WATER MANAGEMENT MEETS PERMIT REQUIREMENTS S M U NA NE DETAILS: 1. SWPPP UPDATED AS NEEDED: DATE OF LAST UPDATE: Y N NA NE 2. SITE MAP INCLUDING ALL DISCHARGES AND SURFACE WATERS: Y N NA NE 3. POLLUTION PREVENTION TEAM IDENTIFIED: Y N NA NE 4. POLLUTION PREVENTION TEAM PROPERLY TRAINED: Y N NA NE 5. LIST OF POTENTIAL POLLUTANT SOURCES: Y N NA NE 6. LIST OF POTENTIAL SOURCES AND PAST SPILLS AND LEAKS: Y N NA NE 7. ALL NON-STORM WATER DISCHARGES ARE AUTHORIZED: Y N NA NE 8. LIST OF STRUCTURAL BMPS: Y N NA NE 9. LIST OF NON-STRUCTURAL BMPS: Y N NA NE 10. BMPS PROPERLY OPERATED AND MAINTAINED: Y N NA NE 11. INSPECTIONS CONDUCTED AS REQUIRED: Y N NA NE Inspection Report Page 5 of 32
6 FLOW CALCULATION SHEET Outfall 002 Date: 3/30/2016 Time: 11:36 Head in Inches: 2.4 Feet: 0.2 Type & Size of Primary Flow Measurement Device: 60 v-notch weir Name & Model of Secondary Flow Measurement Device: ISCO 4280 Bubbler Flow Meter Date of last Calibration of Secondary Flow Device: 2/3/2016 Recorded Flow at Date & Time Listed Above: 11.2 (Facility Flow Meter) Calculated Flow at Date & Time Listed Above: (Flow is calculated using flow charts in: ISCO Open Channel Flow Measurement Handbook-5 th Edition) % Error = % Error = Recorded Value - Calculated Value Calculated Value X 100 X 100 % Error = X 100 % Error = X 100 % Error = % Comments: Within ±10% as required by the permit Inspection Report Page 6 of 32
7 Outfall 004: DMR Calculation Check Reporting Period: From To Year Month Day Year Month Day Parameter Checked: TSS Loading Concentration Mass Monthly Mo. Avg. - lbs/day Mo. Avg. - mg/l Daily Max - mg/l Reported Value: Calculated Value: Permit Value: 452 Report Report If calculated value does not equal reported value, explain: Equal Inspection Report Page 7 of 32
8 Outfall 004: DMR Calculation Check Reporting Period: From To Year Month Day Year Month Day Parameter Checked: O & G Loading Concentration Mass Monthly Mo. Avg. - lbs/day Mo. Avg. - mg/l Daily Max - mg/l Reported Value: Calculated Value: Permit Value: 154 Report Report If calculated value does not equal reported value, explain: Equal Inspection Report Page 8 of 32
9 Outfall 002: DMR Calculation Check Reporting Period: From To Year Month Day Year Month Day Parameter Checked: NH3-N Loading Concentration Mass Monthly Mo. Avg. - lbs/day Mo. Avg. - mg/l 7-day Avg. - mg/l Reported Value: <0 <0.2 <0.2 Calculated Value: <0 <0.2 <0.2 Permit Value: If calculated value does not equal reported value, explain: Equal Inspection Report Page 9 of 32
10 Outfall 002: DMR Calculation Check Reporting Period: From To Year Month Day Year Month Day Parameter Checked: TSS Loading Concentration Mass Monthly Mo. Avg. - lbs/day Mo. Avg. - mg/l Daily Max - mg/l Reported Value: Calculated Value: Permit Value: If calculated value does not equal reported value, explain: Equal Inspection Report Page 10 of 32
11 Table 1. ADEQ laboratory and permittee split sample collection water quality parameter measurements for Outfall 002 at Nucor Steel. The discharge limitations are displayed from the permit. Water Quality Parameters Concentration Permit Limits ADEQ Lab Permittee Split Units Monthly Avg. Daily Max Composite Flow MGD Report (MGD) Report (MGD) Instantaneous Flow MGD N/A N/A Carbonaceous Biochemical Oxygen Demand (CBOD5) 1.5 <2 mg/l 20 mg/l 20 mg/l Total Suspended Solids (TSS) mg/l 20 mg/l 30 mg/l Ammonia Nitrogen (NH3-N) < mg/l 10 mg/l 14.7 mg/l Dissolved Oxygen (DO) mg/l 2.0 mg/l (Inst. Min.) Fecal Coliform Bacteria (FCB) <4 N/E cfu/100 ml 1,000 cfu/100 ml 2,000 cfu/100ml Oil and Grease (O & G) <2.5 <5 mg/l 10 mg/l 15 mg/l ph s.u. Minimum 6.0 s.u. Maximum 9.0 s.u. Table 2. ADEQ laboratory and permittee split sample collection mass loading results for Outfall 002 at Nucor Steel. The discharge limitations are displayed from the permit. Water Quality Parameters Mass Loading (lbs/day) Permit Limits (lbs/day) ADEQ Lab Permittee Split Monthly Avg. Daily Max Flow N/A N/A N/A N/A Carbonaceous Biochemical Oxygen Demand (CBOD5) 0.1 < Total Suspended Solids (TSS) Ammonia Nitrogen (NH3-N) < Dissolved Oxygen (DO) N/A N/A Fecal Coliform Bacteria (FCB) N/A N/A N/A N/A Oil and Grease (O & G) <0.2 < ph N/A N/A N/A N/A Inspection Report Page 11 of 32
12 Table 3. ADEQ laboratory and permittee split sample collection water quality parameter measurements for Outfall 004 at Nucor Steel. The discharge limitations are displayed from the permit. Water Quality Parameters Concentration Permit Limits ADEQ Lab Permittee Split Units Monthly Avg. Daily Max Flow MGD Report (MGD) Report (MGD) Total Suspended Solids (TSS) mg/l Report Report Oil and Grease (O & G) <2.5 <5 mg/l 10 mg/l 15 mg/l Lead, Total recoverable <1 <0.5 µg/l Report Report Zinc, Total recoverable µg/l Report Report Nickel, Total recoverable µg/l Report Report Chromium, Total recoverable 1.09 <10 µg/l Report Report ph s.u. Minimum 6.0 s.u. Maximum 9.0 s.u. Table 4. ADEQ laboratory and permittee split sample collection mass loading results for Outfall 004 at Nucor Steel. The discharge limitations are displayed from the permit. Water Quality Parameters Mass Loading (lbs/day) Permit Limits (lbs/day) ADEQ Lab Permittee Split Monthly Avg. Daily Max Flow N/A N/A N/A N/A Total Suspended Solids (TSS) ,171 Oil and Grease (O & G) <16.50 < Lead, Total recoverable <0.007 < Zinc, Total recoverable Nickel, Total recoverable Chromium, Total recoverable < ph N/A N/A N/A N/A Inspection Report Page 12 of 32
13 5301 Northshore Drive North Little Rock, AR Telephone: Client Report For: Nucor Steel-Hickman Mill AR Attention: Client Address:, Report Date: April 18, 2016 LAB ID: AR16MAR30-04 Comment: Approved By: Date: April 18, 2016 Inspection Report Page 13 of 32
14 Client: CSI Client Sample ID: Outfall 002 Lab ID: Collection Date: 3/30/ :28:00 AM Matrix: Water Analyses Fecal Coliforms SM 9222 D Batch: Run: 1 Result Reporting Limit MDL Qual Unit Fecal Coliforms <4 4 4 cfu/100ml Melanie Treat Analysis Date/Time 3/30/ :12 Inspection Report Page 14 of 32
15 Client: CSI Client Sample ID: Outfall 004 Lab ID: Collection Date: 3/30/ :00:00 AM Matrix: Water Analyses Total Metals by EPA EPA Batch: Run: 1 Result Reporting Limit MDL Qual Unit Aluminum ug/l Antimony ug/l Arsenic ug/l Barium ug/l Beryllium < ug/l Boron ug/l Cadmium < ug/l Chromium ug/l Cobalt < ug/l Copper ug/l Iron ug/l Lead < ug/l Magnesium mg/l Manganese ug/l Nickel ug/l Potassium mg/l Selenium < ug/l Silver < ug/l Sodium mg/l Thallium < ug/l Vanadium < ug/l Zinc ug/l Robert Graddy Analysis Date/Time Apr :32AM Prep By Prep Date/Time Total Metals by EPA EPA Batch: Run: 2 Result Reporting Limit MDL Qual Unit Calcium mg/l 0 Robert Graddy Analysis Date/Time Apr :25AM Prep By Prep Date/Time Inspection Report Page 15 of 32
16 Client: CSI Client Sample ID: Outfall 002 Lab ID: Collection Date: 3/30/ :28:00 AM Matrix: Water Analyses Ammonia as Nitrogen SM 4500-NH3 H (20th) Batch: Run: 1 Result Reporting Limit MDL Qual Unit Ammonia as N < mg/l Chad Carrington Analysis Date/Time 3/30/2016 4:13:11 PM Carb. Biochemical Oxygen Demand (CBOD) 5 Day SM 5210-B Batch: Run: 1 Result Reporting Limit MDL Qual Unit Carbonaceous BOD mg/l Robert Graddy Analysis Date/Time 3/30/ :40 Total Suspended Solids EPA Batch: Run: 1 Result Reporting Limit MDL Qual Unit Total Suspended Solids mg/l Analysis Date/Time 3/24/2016 7:30 Inspection Report Page 16 of 32
17 Client: CSI Client Sample ID: Outfall 004 Lab ID: Collection Date: 3/30/ :00:00 AM Matrix: Water Analyses Total Suspended Solids EPA Batch: Run: 1 Result Reporting Limit MDL Qual Unit Total Suspended Solids mg/l Analysis Date/Time 3/24/2016 7:30 Inspection Report Page 17 of 32
18 Client: CSI Client Sample ID: Outfall 002 Lab ID: Collection Date: 3/30/ :28:00 AM Matrix: Water Analyses Oil and Grease EPA1664 Batch: Run: 1 Result Reporting Limit MDL Qual Unit Oil and Grease < mg/l Robert Graddy Analysis Date/Time Inspection Report Page 18 of 32
19 Client: CSI Client Sample ID: Outfall 004 Lab ID: Collection Date: 3/30/ :00:00 AM Matrix: Water Analyses Oil and Grease EPA1664 Batch: Run: 1 Result Reporting Limit MDL Qual Unit Oil and Grease < mg/l Robert Graddy Analysis Date/Time Inspection Report Page 19 of 32
20 Analytical Quality Control Results Report Batch: Fecal Coliforms - water Outfall 002 LIMS ID: Fecal Coliforms DUP Run: 1 Fecal Coliforms <4 cfu/100ml 4 4 Fecal Coliforms (RPD) 0 % 0-20 Analysis Date/Time 3/30/ :12 Melanie Treat Inspection Report Page 20 of 32
21 Analytical Quality Control Results Report Batch: Oil and Grease - water Outfall 002 LIMS ID: Oil and Grease - water DUP Run: 1 Oil and Grease <2.5 mg/l Oil and Grease (RPD) 0 % 0-20 Robert Graddy Analysis Date/Time Outfall 002 LIMS ID: Oil and Grease - water MS Run: 1 Oil and Grease (% Recovery) 97.0 % Robert Graddy Analysis Date/Time Outfall 002 LIMS ID: Oil and Grease - water MSD Run: 1 Oil and Grease (% Recovery) 102 % Oil and Grease (RPD) 5.5 % 0-20 Robert Graddy Analysis Date/Time MB LIMS ID: MB-01 Oil and Grease - water MB Run: 1 Oil and Grease <2.5 mg/l Robert Graddy Analysis Date/Time LCS LIMS ID: LCS-01 Oil and Grease - water LCS Run: 1 Inspection Report Page 21 of 32
22 Oil and Grease (% Recovery) 87.2 % Robert Graddy Analysis Date/Time Inspection Report Page 22 of 32
23 Analytical Quality Control Results Report Batch: ICP Metals - water (total) Outfall 004 LIMS ID: ICP Metals - water (Total) DUP Run: 1 Aluminum (RPD) 3.2 % 0-20 Aluminum 44.4 ug/l Antimony 43.1 ug/l 5 10 Antimony (RPD) 1.2 % 0-20 Arsenic (RPD) 3.1 % 0-20 Arsenic 5.72 ug/l Barium 52.0 ug/l 2 10 Barium (RPD) 0.1 % 0-20 Beryllium (RPD) 0 % 0-20 Beryllium <0.5 ug/l Boron 82.8 ug/l 5 25 Boron (RPD) 0.9 % 0-20 Cadmium (RPD) 17.0 % 0-20 Cadmium <1 ug/l Chromium 1.10 ug/l Chromium (RPD) 0.5 % 0-20 Cobalt (RPD) 13.5 % 0-20 Cobalt <1 ug/l Copper 4.43 ug/l Copper (RPD) 1.3 % 0-20 Iron (RPD) 5.1 % 0-20 Iron 248 ug/l Lead <1 ug/l Lead (RPD) 12.0 % 0-20 Magnesium (RPD) 0.2 % 0-20 Magnesium 3.69 mg/l Manganese 50 ug/l Manganese (RPD) 0.4 % 0-20 Nickel (RPD) 0.3 % 0-20 Nickel 5.8 ug/l Potassium 12.4 mg/l Potassium (RPD) 0.5 % 0-20 Selenium (RPD) 7.5 % 0-20 Selenium <2 ug/l Silver <5 ug/l 1 5 Silver (RPD) 88.0 % 0-20 Sodium (RPD) 0.2 % 0-20 Sodium 68.5 mg/l Thallium <2.5 ug/l Inspection Report Page 23 of 32
24 Thallium (RPD) 42.9 % 0-20 Vanadium (RPD) 2.3 % 0-20 Vanadium <2.5 ug/l Zinc 23.1 ug/l 2 3 Zinc (RPD) 0.3 % 0-20 Robert Graddy Analysis Date/Time Apr :40AM Outfall 004 LIMS ID: ICP Metals - water (Total) DUP Run: 2 Calcium (RPD) 5.1 % 0-20 Calcium 175 mg/l Robert Graddy Analysis Date/Time Apr :32AM MB LIMS ID: MB-01 ICP Metals - water (Total) MB Run: 1 Aluminum <20 ug/l Antimony <10 ug/l 5 10 Arsenic <1 ug/l Barium <10 ug/l 2 10 Beryllium <0.5 ug/l Boron <25 ug/l 5 25 Cadmium <1 ug/l Calcium <0.04 mg/l Chromium <1 ug/l Cobalt <1 ug/l Copper <1 ug/l Iron <20 ug/l Lead <1 ug/l Magnesium <0.1 mg/l Manganese <1 ug/l Nickel <2.5 ug/l Potassium <1 mg/l Selenium <2 ug/l Silver <5 ug/l 1 5 Sodium <0.04 mg/l Thallium <2.5 ug/l Inspection Report Page 24 of 32
25 Vanadium <2.5 ug/l Zinc <3 ug/l 2 3 Robert Graddy Analysis Date/Time Apr :40AM LCS LIMS ID: LCS-01 ICP Metals - water (Total) LCS Run: 1 Aluminum (% Recovery) 117 % Antimony (% Recovery) 102 % Arsenic (% Recovery) 107 % Barium (% Recovery) 99.1 % Beryllium (% Recovery) 106 % Boron (% Recovery) 106 % Cadmium (% Recovery) 104 % Calcium (% Recovery) 104 % Chromium (% Recovery) 98.3 % Cobalt (% Recovery) 98.6 % Copper (% Recovery) 100 % Iron (% Recovery) 99.9 % Lead (% Recovery) 98.3 % Magnesium (% Recovery) 100 % Manganese (% Recovery) 100 % Nickel (% Recovery) 100 % Potassium (% Recovery) 103 % Selenium (% Recovery) 115 % Silver (% Recovery) 99.0 % Sodium (% Recovery) 99.6 % Thallium (% Recovery) 97.6 % Vanadium (% Recovery) 98.0 % Zinc (% Recovery) 110 % Robert Graddy Analysis Date/Time Apr :10AM Inspection Report Page 25 of 32
26 Analytical Quality Control Results Report Batch: CBOD5 - water Outfall 002 LIMS ID: CBOD - water DUP Run: 1 Carbonaceous BOD 3.75 mg/l Carbonaceous BOD (RPD) >20 % 0-20 Robert Graddy Analysis Date/Time 3/30/ :40 MB LIMS ID: MB-01 CBOD - water MB Run: 1 Carbonaceous BOD <0.2 mg/l Robert Graddy Analysis Date/Time 3/30/ :40 LCS LIMS ID: LCS-01 CBOD - water LCS Run: 1 Carbonaceous BOD (% Recovery) 109 % Robert Graddy Analysis Date/Time 3/30/ :40 LCS LIMS ID: LCS-02 CBOD - water LCS Run: 1 Carbonaceous BOD (% Recovery) 102 % Robert Graddy Analysis Date/Time 3/30/ :40 Inspection Report Page 26 of 32
27 Analytical Quality Control Results Report Batch: TSS - water Outfall 002 LIMS ID: Solids, Total Suspended - water DUP Run: 1 Total Suspended Solids 5.0 mg/l 1 1 Total Suspended Solids (RPD) 13.1 % 0-20 Analysis Date/Time 3/24/2016 7:30 MB LIMS ID: MB-01 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 3/24/2016 7:30 LCS LIMS ID: LCS-01 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 104 % Analysis Date/Time 3/24/2016 7:30 MB LIMS ID: MB-02 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 3/24/2016 7:30 LCS LIMS ID: LCS-02 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 105 % Analysis Date/Time 3/24/2016 7:30 MB LIMS ID: MB-03 Inspection Report Page 27 of 32
28 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 3/24/2016 7:30 LCS LIMS ID: LCS-03 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 91.0 % Analysis Date/Time 3/24/2016 7:30 MB LIMS ID: MB-04 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 3/24/2016 7:30 LCS LIMS ID: LCS-04 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 97.2 % Analysis Date/Time 3/24/2016 7:30 MB LIMS ID: MB-05 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 4/6/2016 7:30 LCS LIMS ID: LCS-05 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 94.0 % Inspection Report Page 28 of 32
29 Analysis Date/Time 4/6/2016 7:30 MB LIMS ID: MB-06 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 4/6/2016 7:30 LCS LIMS ID: LCS-06 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 98.5 % Analysis Date/Time 4/6/2016 7:30 MB LIMS ID: MB-07 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 4/6/2016 7:30 LCS LIMS ID: LCS-07 Solids, Total Suspended - water LCS Run: 1 Total Suspended Solids (% Recovery) 96.2 % Analysis Date/Time 4/6/2016 7:30 MB LIMS ID: MB-08 Solids, Total Suspended - water MB Run: 1 Total Suspended Solids <1 mg/l 1 1 Analysis Date/Time 4/6/2016 7:30 LCS LIMS ID: LCS-08 Solids, Total Suspended - water LCS Run: 1 Inspection Report Page 29 of 32
30 Total Suspended Solids (% Recovery) 96.8 % Analysis Date/Time 4/6/2016 7:30 Inspection Report Page 30 of 32
31 Analytical Quality Control Results Report Batch: Lachat - Ammonia (water) Outfall 002 LIMS ID: Ammonia as N - water DUP Run: 1 Ammonia as N <0.03 mg/l Ammonia as N (RPD) 29.6 % 0-20 Chad Carrington Analysis Date/Time 3/30/2016 4:14:14 PM MB LIMS ID: MB-01 Ammonia as N - water MB Run: 1 Ammonia as N <0.03 mg/l Chad Carrington Analysis Date/Time 3/30/2016 1:40:05 PM LCS LIMS ID: LCS-01 Ammonia as N - water LCS Run: 1 Ammonia as N (% Recovery) 96.7 % Chad Carrington Analysis Date/Time 3/30/2016 1:41:07 PM MB LIMS ID: MB-02 Ammonia as N - water MB Run: 1 Ammonia as N <0.03 mg/l Chad Carrington Analysis Date/Time 3/30/2016 2:11:18 PM LCS LIMS ID: LCS-02 Ammonia as N - water LCS Run: 1 Inspection Report Page 31 of 32
32 Ammonia as N (% Recovery) 98.0 % Chad Carrington Analysis Date/Time 3/30/2016 2:12:20 PM MB LIMS ID: MB-03 Ammonia as N - water MB Run: 1 Ammonia as N <0.03 mg/l Chad Carrington Analysis Date/Time 3/30/2016 3:07:33 PM LCS LIMS ID: LCS-03 Ammonia as N - water LCS Run: 1 Ammonia as N (% Recovery) 97.5 % Chad Carrington Analysis Date/Time 3/30/2016 3:08:35 PM MB LIMS ID: MB-04 Ammonia as N - water MB Run: 1 Ammonia as N <0.03 mg/l Chad Carrington Analysis Date/Time 3/30/2016 3:39:50 PM LCS LIMS ID: LCS-04 Ammonia as N - water LCS Run: 1 Ammonia as N (% Recovery) 100 % Chad Carrington Analysis Date/Time 3/30/2016 3:40:54 PM Inspection Report Page 32 of 32
April 14, Tim Nyander, Utilities Director City of Fayetteville 113 W. Mountain St. Fayetteville, AR Paul R. Noland Wastewater Inspection
April 14, 2016 Tim Nyander, Utilities Director City of Fayetteville 113 W. Mountain St. Fayetteville, AR 72701 RE: Paul R. Noland Wastewater Inspection AFIN: 72-00781 Permit No.: AR0020010 Dear Mr. Nyander:
Routine Compliance Inspection AFIN: , NPDES Permit No s: AR and ARR00A251
November 30, 2012 Mr. Sammy Bates, Environmental Coordinator, R.E.M. Remington Arms Company, Inc P.O. Box 400 Lonoke, AR 72086 RE: Routine Compliance Inspection AFIN: 43-00024, NPDES Permit No s: AR0001163
If I can be of any assistance, please contact me at or (479) extension 16.
July 6, 2015 Michael Tedder, Complex Manager Tyson's Foods, Inc. - Dardanelle Processing Facility P.O. Box 638 Dardanelle, AR 72834 RE: Tyson Foods, Inc. Inspections (Yell Co) AFIN: 75-00017 NPDES Permit
April 20, Justin Sims, Superintendant Alotian Club, LLC 101 Alotian Drive Little Rock, AR Alotian Club Inspection. Dear Mr.
April 20, 2015 Justin Sims, Superintendant Alotian Club, LLC 101 Alotian Drive Little Rock, AR 72135 RE: Alotian Club Inspection AFIN: 60-02347 Permit No.: AR0050245 Dear Mr. Sims On March 19, 2015, I
March 27, Rob McDaniel, Timber Ridge Ranch Neuro Rehabilitation Center, Inc Timber Ridge Lane Benton, AR 72019
March 27, 2015 Rob McDaniel, Timber Ridge Ranch Neuro Rehabilitation Center, Inc. 15000 Timber Ridge Lane Benton, AR 72019 RE: Timber Ridge Neuro Rahab Inspection AFIN: 63-00090 Permit No.: AR0041416 Dear
January 30, Harry Makridakis, Plant Manager Viskase Companies, Inc East State Highway 198 Osceola, AR 72370
January 30, 2014 Harry Makridakis, Plant Manager Viskase Companies, Inc. 2221 East State Highway 198 Osceola, AR 72370 RE: Viskase Companies, Inc. Inspection AFIN: 47-00115 Permit No.: AR0036544 & ARR000876
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: Domtar Industries Inc. LOCATION: 1 mile south of Ashdown on Hwy 71 S CITY: Ashdown RESPONSIBLE OFFICIAL NAME: / TITLE Robert C. Grygotis / V.P. General Manager COMPANY: Domtar
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
October 6, 2015 Honorable Beth Calhoun, Mayor City of Bald Knob P.O. Box 1119 Bald Knob, AR 72010 RE: City of Bald Knob Inspection AFIN: 73-00077 Permit No.: AR0035807 Dear Mayor Calhoun: On September
Inspection Report: Blytheville - West WWTP, AFIN: , Permit #: AR FACILITY TYPE: 1 - Municipal FACILITY EVALUATION RATING:
WATER DIVISION INSPECTION REPORT AFIN: 47-00544 PERMIT #: AR0022560 DATE: 8/26/2015 COUNTY: 47 Mississippi PDS #: 087290 MEDIA: WN GPS LAT: 35.934850 LONG: -89.942647 LOCATION: Entrance FACILITY INFORMATION
May 9, Honorable Jean Pace, Mayor City of Mammoth Springs P.O. Box 185 Mammoth Spring, AR Mammoth Springs WWTP (Fulton Co)
May 9, 2014 Honorable Jean Pace, Mayor City of Mammoth Springs P.O. Box 185 Mammoth Spring, AR 72554 RE: Mammoth Springs WWTP (Fulton Co) AFIN: 25-00013 NPDES Permit No.: AR0023850 Dear Honorable Jean
ARR No violations were noted at the time of the inspections. Please refer to the attached inspection reports for any comments.
January 15, 2014 Robert J. Packman, President of Operations Victory Lumber, LLC 111 Ouachita 301 Camden, AR 71701 RE: Compliance Inspections (Ouachita Co) AFIN: 52-00247 Permit No.: AR0050482 ARR001246
September 23, Mr. Tony Bass Tri-City Utilities Wastewater Treatment Plant P.O. Box 84 Peach Orchard, AR RE: Compliance Inspection
September 23, 2008 Mr. Tony Bass Tri-City Utilities Wastewater Treatment Plant P.O. Box 84 Peach Orchard, AR 72453 RE: Compliance Inspection AFIN: 61-00072 NPDES Permit No.: AR0043486 Dear Mr. Bass: On
June 12, Honorable Marion Gill, Mayor City of Dumas P.O. Box 157 Dumas, Arkansas RE: Waste Water Treatment Facility.
June 12, 2009 Honorable Marion Gill, Mayor City of Dumas P.O. Box 157 Dumas, Arkansas 71639 RE: Waste Water Treatment Facility AFIN: 21-00045 NPDES Permit No.: AR0033987 Dear Mayor Gill: On June 9, 2009,
January 29, Jim Morse, Environmental, Health and Safety Ciba Specialty Chemicals Corporation 100 Bridgeport Rd. West Memphis, AR
January 29, 2008 Jim Morse, Environmental, Health and Safety Ciba Specialty Chemicals Corporation 100 Bridgeport Rd. West Memphis, AR 72301-6413 RE: Ciba Waste Water Inspection AFIN: 18-00081 NPDES Permit
July 18, Thomas Northern, Owner Northern Mobile Home Park 4078 Hwy. 349 Jonesboro, AR Northern Mobile Home Park Wastewater Inspection
July 18, 2013 Thomas Northern, Owner Northern Mobile Home Park 4078 Hwy. 349 Jonesboro, AR 72404 RE: Northern Mobile Home Park Wastewater Inspection AFIN: 16-00185 NPDES Permit No.: AR0042188 Dear Mr.
September 26, RE: Waste Water Treatment System. Dear Mr. Starks:
September 26, 2008 Leon Starks, Director of Maintenance Arkansas Department of Correction East Arkansas Regional Unit 7800 Correction Circle Pine Bluff, Arkansas 71603 RE: Waste Water Treatment System
October 6, Mr. Donny Roberts, Mayor City of Hoxie 400 S.W. Hartigan Hoxie, AR RE: Compliance Inspection. Dear Mr.
October 6, 2010 Mr. Donny Roberts, Mayor City of Hoxie 400 S.W. Hartigan Hoxie, AR 72433 RE: Compliance Inspection AFIN: 38-00035 NPDES Permit No.: AR0020141 Dear Mr. Roberts: On September 15, 2010, Brent
June 11, Ms. Kata Savic Mill Pond Village #1 Preakness Drive Hot Springs, AR Mill Pond Village Inspection (Garland Co) Dear Ms.
June 11, 2015 Ms. Kata Savic Mill Pond Village #1 Preakness Drive Hot Springs, AR 71913 RE: Mill Pond Village Inspection (Garland Co) AFIN: 26-00208 NPDES Permit No.: AR0041319 Dear Ms. Savick: On May
1. The facility had several thermometers which had not been calibrated in over a year.
May 25, 2010 Mr. Larry Waldrop El Dorado Water-South Plant P.O. Box 1587 El Dorado, AR 71731 RE: Compliance Inspection AFIN: 70-00341 NPDES Permit No.: AR0033723 Dear Mr. Waldrop: On 5/12/2010, I performed
RE: NPDES Compliance Evaluation Inspection, West Memphis WWTP
March 22, 2012 John Rimmer, General Manager City of West Memphis WWTP P.O. Box 1868 West Memphis, AR 72303 RE: NPDES Compliance Evaluation Inspection, West Memphis WWTP AFIN: 18-00879 NPDES Permit No.:
If I can be any assistance, please contact me at or
November 4, 2008 Levon Brown, Manager South Sheridan-Little Creek Water 1664 Hwy 167 South Sheridan, AR 72150 AFIN: 27-00066 NPDES Permit No: ARG640121 27-00234 State Permit 4817-WG-WR Re: Routine Compliance
1. The sludge pump in the pump building was leaking sludge into the pump building.
December 21, 2009 Mr. David Richardson, Manager City of Camden, Water Utilities P.O. Drawer J Camden, AR 71711 RE: Compliance Inspection AFIN: 52-00073 NPDES Permit No.: AR0022365 Dear Mr. Richardson:
NPDES Permit No: AR , Routine Compliance Inspection
May 26, 2009 Dallas Ray Goad, Superintendent City Of Bradford 308 B, W. Walnut St Bradford, AR 72020 AFIN: 73-00072 NPDES Permit No: AR0050911, Routine Compliance Inspection Dear Mr. Goad: On May 20, 2009,
For additional information you may contact the Enforcement Branch by telephone at or by fax at
November 23, 2011 Anthony Sherrill, Manager Chemistry Entergy- Arkansas Nuclear One 1448 SR 333 Russellville, AR 72802 AFIN: 58-00002 NPDES Permit No.: AR0001392 Dear Mr. Sherrill: On October 24, 2011,
RE: Union School Inspection (Union Co) AFIN: NPDES Permit No.: AR
December 10, 2014 Jim Tucker, Superintendent El Dorado Public Schools - Old Union 200 West Oak El Dorado, AR 71730 RE: Union School Inspection (Union Co) AFIN: 70-00820 NPDES Permit No.: AR0051811 Dear
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: Premium Pipe and Supply, L.P. LOCATION: 2703 N. Cedar ST. CITY: Morrilton NAME: / TITLE / COMPANY: MAILING ADDRESS: CITY, STATE, ZIP: PHONE & EXT: / FAX: EMAIL: / RESPONSIBLE
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
January 29, 2014 Homer Reeves, Water Superintendent City of McCrory WWTP P.O. Box 897 McCrory, AR 72101 RE: Compliance Inspection, City of McCrory Wastewater Treatment Plant AFIN: 74-00050, Permit No.:
NPDES Permit Tracking No.: AR
May 3, 2010 Honorable Bill Montgomery City of Decatur P.O. Box 247 Decatur, Arkansas 72722 RE: NPDES Permit Compliance Evaluation Inspection AFIN: 04-00052 NPDES Permit Tracking No.: AR0022292 Dear Mayor
2. According to Jerry Spillers, Operator, and Donnie Tedford, Operator, the plant overflows and plant flooding are due to the following conditions:
June 14, 2010 Honorable Jan Throgmorton City of West Fork P.O. Box 339 West Fork, Arkansas 72774 RE: West Fork Wastewater Treatment Plant Inspections AFIN: 72-00137 NPDES Permit No.: AR0022373 Dear Mayor
April 5, Susan McClendon, Chief Financial Officer Drew Foam Co., Inc Highway 278 East Monticello, AR 71655
April 5, 2017 Susan McClendon, Chief Financial Officer Drew Foam Co., Inc. 1093 Highway 278 East Monticello, AR 71655 RE: Drew Foam Co., Inc. Inspection (Drew Co) AFIN: 22-00057 NPDES Permit No.: ARR000817
November 13, Ron Alexander Hackney Ladish, Inc. 708 S. Elmira Ave. Russellville, AR Industrial Stormwater Inspection (Pope Co)
November 13, 2014 Ron Alexander Hackney Ladish, Inc. 708 S. Elmira Ave. Russellville, AR 72802 RE: Industrial Stormwater Inspection (Pope Co) AFIN: 58-00042 NPDES Permit No.: ARR00A378 Dear Mr. Alexander:
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
September 11, 2015 Lawrence Davis, Contact Shannon Hills WWT Facility 10401 High Road East Shannon Hills, AR 72103 RE: City of Shannon Hills WWTP Inspection AFIN: 63-00856 Permit No.: AR0050636 Dear Mr.
No violations were noted at the time of the inspections. Please refer to each of the attached inspection reports for any comments.
September 9, 2015 Steve Parke, Director of Utilities City of Fort Smith 3900 Kelley Hwy Fort Smith, AR 72904 RE: City of Fort Smith - "P" Street WWTP Inspections (Sebastian Co) AFIN: 66-01653 Permit No.:
August 2, P.O. Box 7069 AFIN: ARR00A WR-5. Dear Mr. Lichty: Sincerely, Water Division. Page 1 of 7
August 2, 2016 Craig Lichty, Plant Manager Evergreen Packaging Pine Bluff P.O. Box 7069 Pine Bluff, AR 71611-7069 RE: Evergreen Packaging Pine Bluff Inspections (Jefferson Co) AFIN: 35-00016 Permit No.:
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: City of Marion STP LOCATION: 5054 Hardin Rd. CITY: Marion NAME: / TITLE Frank Fogleman / Mayor COMPANY: City of Marion MAILING ADDRESS: 14 Military Rd. CITY, STATE, ZIP: Marion
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
May 5, 2014 The Honorable Jackie Crabtree Mayor, City of Pea Ridge P.O. Box 29 Pea Ridge, AR72751 RE: Reconnaissance Inspection AFIN: 04-00152 Permit No.: AR0020672 Dear Ms. Stahman: On April 14, 2014,
NEILSON RESEARCH CORPORATION
NEILSON RESEARCH CORPORATION Environmental Testing Laboratory 5/23/2016 Russell Deen Southern Oregon University TEL: (541) 552-6798 FAX (541) 552-6415 RE: Dear Russell Deen: Order No.: 1605610 received
Custom Wood Recycling, Inc. Inspection (Yell Co) Permit No.: AR and ARR000421
November 22, 2013 Tony Childers, President Custom Wood Recycling, Inc. P.O. Box 9 Centerville, AR 72833 RE: Custom Wood Recycling, Inc. Inspection (Yell Co) AFIN: 75-00315 Permit No.: AR0051195 and ARR000421
If I can be of any assistance, please contact me at or (501)
January 19, 2016 James Travis, Mill Manager West Fraser, Inc. PO Box 39 Mansfield, AR 72944 RE: Mansfield, a Division of West Fraser, Inc. Inspection (Scott Co) AFIN: 64-00049 NPDES Permit No.: AR0048232
February 22, Randy Coats, Director of Operations PJ'S Tank Wash 2201 Hwy 82 West Crossett, AR PJ'S Tank Wash Inspection (Ashley Co)
February 22, 2016 Randy Coats, Director of Operations PJ'S Tank Wash 2201 Hwy 82 West Crossett, AR 71635 RE: PJ'S Tank Wash Inspection (Ashley Co) AFIN: 02-00086 NPDES Permit No.: ARR000693 Dear Mr. Coats:
September 15, Phillip Foot, Water Utilities Manager City of Hazen P.O. Box 564 Hazen, Arkansas RE: Waste Water Treatment Facility
eptember 15, 2008 Phillip Foot, Water Utilities Manager City of Hazen P.O. Box 564 Hazen, Arkansas 72064 RE: Waste Water Treatment Facility AFIN: 59-00029 NPDE Permit No.: AR0022411 Dear Mr. Foot: On August
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: West Memphis WWTP LOCATION: 502 South Loop Rd. CITY: West Memphis RESPONSIBLE OFFICIAL NAME: / TITLE John Rimmer / General Manager COMPANY: West Memphis Utilities MAILING ADDRESS:
Tyson Poultry, Inc. - Berryville Industrial User Inspection (Carroll Co)
June 7, 2016 Kirby Murray, Public Works Director City of Berryville PO Box 227 Berryville, AR 72616 RE: Tyson Poultry, Inc. - Berryville Industrial User Inspection (Carroll Co) AFIN: 08-00034 NPDES Permit
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
January 13, 2014 Mr. Joe Stewart, General Manager Valley View Golf Course, L.L.C. Washington County Property Improvements District #5 11520 Clubhouse Parkway Farmington, Arkansas 72730 RE: Reconnaissance
If I can be of any assistance, please contact me at or (501)
January 12, 2015 Shaun Browning, Owner/operator Browning Redi-Mix PO Box 5035 Cabot, AR 72023 RE: Browning Redi-Mix Inspection AFIN: 73-01185 Permit No.: ARR000923 Dear Mr. Browning: On October 16, 2014
Please refer to the Summary of Findings section of the attached inspection report and provide a written response for each violation that was noted.
August 8, 2016 Marty Renfrow, Plant Manager Husqvarna Plastics Nashville 139 Old Airport Road Nashville, AR 71852 RE: Husqvarna Plastics Nashville Inspection AFIN: 31-00000 Permit No.: ARR000000 Dear Mr.
Inadequate certification and calibration of laboratory thermometers. The last certification documentation available was dated April 25, 2006.
December 28, 2007 Ken Johnson, Manager Pine Bluff Wastewater Utility 1520 outh Ohio treet Pine Bluff, Arkansas 71601-6055 RE: Wastewater Treatment ystem AFIN: 35-00149 NPDE Permit No.: AR0033316 Dear Mr.
OFFICE AFIN: PDS #: MEDIA: WN LOCATION: Roberts Blvd. CITY: Fort Smith 11:30 2/1/2015 LE OFFICIAL RESPONSIBL 1/31/2020
NAME: Mars Petcare US, Inc. LOCATION: 10000 Roberts Blvd. CITY: Fort Smith NAME: / TITLE COMPANY: Fort Smith, City of MAILING ADDRESS: P.O. Box 1908 CITY, STATE, ZIP: Fort Smith AR 72902 PHONE & EXT: /
July 7, Jason Barnes, Facilities and ESH Manager Facilities and ESH manager Baxter Healthcare Corporation Mountain Home, AR 72653
July 7, 2015 Jason Barnes, Facilities and ESH Manager Facilities and ESH manager Baxter Healthcare Corporation Mountain Home, AR 72653 RE: Baxter Healthcare-Mt. Home Inspection (Baxter Co) AFIN: 03-00002
Monday, May 04, :19:46PM
Monday, May 04, 2009 6:19:46PM John Naginis Chatsworth, CA 91311 RE: Runkle Canyon Work Order: Enclosed are the results of analyses for samples received by the laboratory on 04/02/09 10:30. If you have
Final Report DMR-QA 36. NPDES Permit: IL DMR-QA Study. Open Date: 03/18/16. Close Date: 07/01/16. Report Issued Date: 07/29/16
Keith Richard Decatur Sanitary District Decatur, IL 62522-1842 USA DMR-QA 36 Final Report NPDES Permit: IL0028321 DMR-QA Study Open Date: 03/18/16 Close Date: 07/01/16 Report Issued Date: 07/29/16 Study
Inspection Report: QualServ Corporation, AFIN: , Permit #: AR FACILITY TYPE: 2 - Industrial. 3 - Satisfactory
OFFICE OF WATER INSPECTION REPORT AFIN: 66-01652 PERMIT #: AR0021750 DATE: 6/7/2017 COUNTY: 66 Sebastian PDS #: 097834 MEDIA: WN GPS LAT: 35.313206 LONG: -94.405142 LOCATION: Entrance FACILITY INFORMATION
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: West Memphis WWTP LOCATION: 502 South Loop Rd. CITY: West Memphis NAME: / TITLE William Johnson / Mayor COMPANY: West Memphis Utilities MAILING ADDRESS: 205 South Redding CITY,
August 20, Jeff Horn, Plant Manager - NAES Plum Point Energy Station P.O. Box 567 Osceola, AR Plum Point Energy Station Inspection
August 20, 2013 Jeff Horn, Plant Manager - NAES Plum Point Energy Station P.O. Box 567 Osceola, AR 72370 RE: Plum Point Energy Station Inspection AFIN: 47-00461 NPDES Permit No.: AR0049557 Dear Mr. Horn:
WATER DIVISION INSPECTION REPORT
FACILITY INFORMATION NAME: Mena Wastewater Plant LOCATION: 323 Polk 53 CITY: Mena, AR RESPONSIBLE OFFICIAL NAME: / TITLE Larry Gross / Maintenance Supervisor COMPANY: City of Mena MAILING ADDRESS: 323
Please refer to the Summary of Findings section of the attached report and provide a written response for each violation that was noted.
March 20, 2015 Honorable William A. Cypert, Mayor City of Cabot No. 1 City Plaza, Suite A Cabot, AR 72023 RE: Municipal Separate Storm Sewer System (MS4) Audit AFIN: 88-00832 NPDES Permit No.: ARR040013
FACILITY TYPE: 2 - Industrial FACILITY EVALUATION RATING: N
FACILITY INFORMATION NAME: Del-Tin Fiber, LLC LOCATION: 757 Del-Tin Highway CITY: El Dorado, AR RESPONSIBLE OFFICIAL NAME: / TITLE Darrin Cannon / Plant Manager COMPANY: Del-Tin Fiber MAILING ADDRESS:
As a reminder, continued participation in the Ecology Lab Accreditation Program requires the lab to:
April 11, 2017 Mr. Brad Barfuss 350 Hills Street Suite 107 Richland, WA 99354 Dear Mr. Barfuss: Thank you for your application for renewal in the Environmental Laboratory Accreditation Program. Enclosed
As a reminder, continued participation in the Ecology Lab Accreditation Program requires the lab to:
April 9, 2015 Ms. Elisa Nguyen Energy Northwest Environmental Services Lab 350 Hills Street Suite 107 Richland,WA 99354 Dear Ms. Nguyen: Thank you for your application for renewal in the Environmental
If you have any questions please contact Richard Healey, Enforcement Branch Manager, at or
CERTIFIED MAIL: 9489 0090 0027 6022 2427 07 October 25, 2017 Pat Sanders, Property Owner Route 1 Box 238 Western Grove, AR 72685 RE: Reconnaissance Inspection (Newton County) AFIN: 51-00000 NPDES Permit
Appendix C: Water Quality Data
Appendix C: Water Quality Data Your Project #: 111257005 Site: TIM HORTONS SYLVIA LAKE NSD # 16300R Attention: DAVID WHETTER STANTEC CONSULTING LTD 603-386 BROADWAY AVENUE WINNIPEG, MB CANADA R3C
1. The IU site visit to Quala Wash (Previously PSC Container) revealed:
March 22, 2012 John Rimmer, General Manager City of West Memphis WWTP P.O. Box 1868 West Memphis, AR 72303 RE: Pretreatment Compliance Inspection RE: AFIN: 18-00879 NPDES Permit No.: AR0022039 Dear Mr.
February 17, Jon Myhre Enerco Operating Corporation 6237 Tulip Lane Dallas, TX Fouke # D-3 SWD System Inspection (Miller Co)
February 17, 2015 Jon Myhre Enerco Operating Corporation 6237 Tulip Lane Dallas, TX 75230 RE: Fouke # D-3 SWD System Inspection (Miller Co) AFIN: 46-00279 State Permit No.: 0572-WG-SW-2 Dear Mr. Myhre:
Water Quality Permitting Program Monitoring Matrix 1,2,3
State of Oregon Department of Environmental Quality Water Quality Permitting Program Monitoring Matrix 1,2,3 ITEM OR PARAMETER Total Flow (influent and/or effluent) 4 Flow Meter Calibration 5 (influent
RE: Split Ash Sample Results October 2017 Charah Brickhaven Facility
November 7, 2017 Mr. Brian Burkhart, P.E. Environmental Quality Director Chatham County 720 Renaissance Drive Pittsboro, North Carolina RE: Split Ash Sample s October 2017 Charah Brickhaven Facility Dear
SPECIFICATION NO.1197S Addendum No.4 Attachment D. Appendix L- Ground Water Quality Data and Revised Construction Groundwater Discharge Plan
SPECIFICATION NO.1197S Addendum No.4 Attachment D Appendix L- Ground Water Quality Data and Revised Construction Groundwater Discharge Plan Page 1 of 2 Specification No. 1197S Addendum No. 4 ATTACHMENT
CERTIFICATE OF ANALYSIS REVISED REPORT
Your C.O.C. #: A122303 Attention: STEPHEN LEGAREE EDMONTON 9331 9331-48 Street EDMONTON, AB CANADA T6B 2R4 Report #: R1787645 Version: 2R CERTIFICATE OF ANALYSIS REVISED REPORT MAXXAM JOB #: B4B4991 Received:
Inspection Report: El Dorado Chemical Company, AFIN: , Permit #: ARR FACILITY TYPE: 2 - Industrial
Inspection Report: El Dorado Chemical Company, AFIN: 70-00040, Permit #: ARR154223 FACILITY INFORMATION NAME: El Dorado Chemical Company LOCATION: 4500 North West Ave CITY: El Dorado, AR 71730 RESPONSIBLE
CERTIFICATE OF ANALYSIS
BAY 3, 4500 5TH STREET NE CALGARY, AB CANADA T2L 7C3 MAXXAM JOB #: A814851 Received: 2008/04/02, 13:15 Matrix: Water # s Received: 1 This report supersedes all previous reports with the same Maxxam job
No documentation that a Storm Water Pollution Prevention Plan (SWPPP) has been developed for this facility.
February 17, 2009 Bobby Vincent, Owner 5084 Hwy. 38 West Des Arc, Arkansas 72040 RE: Industrial Storm Water Compliance Inspection AFIN: 59-00213 NPDES Permit No.: ARR000052 Dear Mr. Vincent: On February
NPDES Permit No.: AR , ARR00A412
July 7, 2011 Donnie Pretty Acme Brick Company- Perla Facility 3024 Acme Brick Plaza Fort Worth, Texas 76109 AFIN: 30-00008 NPDES Permit No.: AR0043354, ARR00A412 Dear Mr. Pretty: On June 16, 2011, I performed
RE: Split Ash Sample Results May 2016 Charah Brickhaven Facility
July 21, 2016 Mr. Brian Burkhart, P.E. Environmental Quality Director Chatham County 720 Renaissance Drive Pittsboro, North Carolina RE: Split Ash Sample s May 2016 Charah Brickhaven Facility Dear Mr.
ANALYTES available for testing
ANALYTES available for testing codes WS = water supply, drinking water, potable water WP = wastewater, general water quality, ODA OK = Oklahoma DEQ ODA = Oklahoma Department of Agriculture KS = Kansas
CERTIFICATE OF ANALYSIS
Your C.O.C. #: 32531001 Attention: Scott Churko Engineering and Operations Dpt PO Box 1390 Parksville, BC Canada V9P 2H3 CERTIFICATE OF ANALYSIS MAXXAM JOB #: B279455 Received: 2012/09/06, 09:15 Sample
EPA Methods Update. What s new and what s coming in EPA ICP-MS methods?
EPA Methods Update What s new and what s coming in EPA ICP-MS methods? Important US Environmental Legislation Pertaining to Environmental Monitoring 1963 Clean Air Act reduce smog and air pollution 1970
A & R Laboratories. Formerly Microbac Southern California 1650 S. GROVE AVE., SUITE C ONTARIO, CA
Page of 4 CASE NRATIVE Authorized Signature Name / Title (print) Ken Zheng, President Signature / Date Ken Zheng, President 2/3/206 9:53:22 Laboratory Job No. (Certificate of Analysis No.) Project Name
NPDES Permit No. IL Notice No. BDF: bah. Public Notice Beginning Date: February 17, Public Notice Ending Date: March 19, 2012
Notice No. BDF:11041503.bah Public Notice/Fact Sheet Issued By: Public Notice Beginning Date: February 17, 2012 Public Notice Ending Date: March 19, 2012 National Pollutant Discharge Elimination System
Central San Overflow Response. Maintenance Supervisor
Central San Overflow Response Dante Marchetti Maintenance Supervisor April 23, 2009 The cities we serve Alamo Clyde Parts of Concord Danville Lafayette Parts of Martinez Moraga Orinda Pacheco Pleasant
July 10, Richard Murders, Plant Manager Weyerhaeuser NR Company PO Box 38 Dierks, AR Dierks Mill Expansion Project Inspection (Howard Co)
July 10, 2015 Richard Murders, Plant Manager Weyerhaeuser NR Company PO Box 38 Dierks, AR 71833 RE: Dierks Mill Expansion Project Inspection (Howard Co) AFIN: 31-00016 NPDES Permit No.: ARR154738 Dear
5/31/12, the telemetry device fails to provide consistent notifications in an emergency. This is a violation of Part III.B.1.of the permit.
June 6, 2012 Ms. Michele Baker, CFO Josie Company, LLC 12913 I-30W Benton, AR 72015 AFIN: 63-00500 NPDES Permit No.: AR0050181 Dear Ms. Baker: On May 31, 2012; Dennis Benson and I performed a reconnaissance
Participate in proficiency testing studies semi-annually, with the following exception
July 02, 2015 Mr. Dave Wunderlich Eurofins Frontier Global Sciences 11720 North Creek Parkway North, Suite 400 Bothell,WA 98011 Dear Mr. Wunderlich: Thank you for your application for renewal in the Environmental
RE: AFIN: NPDES Permit No.: AR
June 30, 2008 Barrett E. Harrison, Mayor City of Blytheville P.O. Box 1784 Blytheville, AR 72315 RE: Pretreatment Compliance Inspection RE: AFIN: 47-00544 NPDES Permit No.: AR0022560 Dear Mr. Harrison:
STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENTAL QUALITY DIVISION OF WATER RESOURCES PERMIT TO DISCHARGE WASTEWATER UNDER THE
STATE OF NORTH CAROLINA DEPARTMENT OF ENVIRONMENTAL QUALITY DIVISION OF WATER RESOURCES PERMIT TO DISCHARGE WASTEWATER UNDER THE NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM In compliance with the provision
Please refer to the Summary of Findings section of the attached inspection reports and provide a written response for each violation that was noted.
March 6, 2018 Lenore E. Trammell, Chief Compliance Officer Big River Steel, LLC P.O. Box 707 Osceola, AR 72370 RE: Big River Steel Inspections AFIN: 47-00991 Permit No.: AR0052582 & ARR001578 Dear Ms.
September 22, Lexi Grisham, President Grisham Farm Products 7364 Newkirk Rd. Mountain Grove, MO RE: Grisham Farm Products Hoxie, AR
September 22, 2008 Lexi Grisham, President 7364 Newkirk Rd. Mountain Grove, MO 65711 RE: Hoxie, AR AFIN: 38-XXXXX NPDES Permit No.: No-Permit Dear Mr. Grisham: On September 17, 2008, I performed a compliance
AFIN: PDS #: LABORATORY
NAME: Van Buren, City of WWTP - Main LOCATION: 1401 Port Road CITY: Van Buren NAME: / TITLE Steve Dufresne / COMPANY: Van Buren Municipal Utilities MAILING ADDRESS: PO Drawer 1269 CITY, STATE, ZIP: Van
2018 Annual Groundwater Monitoring and Corrective Action Report
2018 Annual Groundwater Monitoring and Corrective Action Report Prairie Creek Generating Station Cedar Rapids, Iowa Prepared for: Alliant Energy 25216074.18 January 31, 2019 2830 Dairy Drive Madison, WI
October 6, Jerry Qualls, Mayor City of Monette Wastewater Treatment Plant P.O. Box 382 Monette, AR 72447
October 6, 2011 Jerry Qualls, Mayor City of Monette Wastewater Treatment Plant P.O. Box 382 Monette, AR 72447 RE: City of Monette WWTP NPDES Compliance Inspection AFIN: 16-00149 NPDES Permit No.: AR0033651
2018 Schedule of Rates Fees and Charges City of Glens Falls, NY Water & Sewer Department Water Rates: $37.28 per Non-meter rate
2018 Schedule of Rates Fees and Charges City of Glens Falls, NY Water & Sewer Department Water Rates: $37.28 per Non-meter rate billing Meter Rate: $1.381 per 100 cubic feet Minimum Meter Rates Meter Size
CALA Directory of Laboratories
CALA Directory of Laboratories Membership Number: 2635 Laboratory Name: Taiga Environmental Laboratory Parent Institution: Government of Northwest Territories (GNWT) Address: P.O. Box 1320 4601-52nd Avenue
City of Sturgis WWTP 2101 Treatment Plant Rd. Sturgis, Michigan (269) FAX (269) NPDES Permit Number: MI
City of Sturgis WWTP 2101 Treatment Plant Rd. Sturgis, Michigan 9091-8730 269 659-7250 FAX 269 659-2500 NPDES Permit Number: MI 002051 Industrial Pretreatment Program ANNUAL REPORT For Reporting Period
Wastewater Pretreatment Plant Special Waste Generator Application
New Renewal (Permit # ) EIN number All generators of Special Waste are required to apply for and receive a Special Waste Generator Permit from Lehigh County Authority (LCA) prior to discharging waste at
State of Nevada Department of Conservation and Natural Resources Division of Environmental Protection Laboratory Scope of Accreditation
Matrix: CWA (Non Potable Water) Discipline: Chemistry ASTM D516-07 ASTM D6888-09 ASTM D7511-09e2 EPA 160.4 EPA 1631E EPA 1664A EPA 1664A (SGT-HEM) EPA 180.1 Sulfate 8/1/2018 Cyanide, Amenable 8/1/2018
CERTIFICATE OF ANALYSIS
Your Project #: 001\DRINKABLE WATER Your C.O.C. #: na Attention: Michael Bourgon 7111 Syntex Dr Suite 354 Mississauga, ON CANADA L5B 4P5 CERTIFICATE OF ANALYSIS MAXXAM JOB #: B2H1428 Received: 2012/11/01,
CALIFORNIA STATE ENVIRONMENTAL LABORATORY ACCREDITATION PROGRAM Accredited Fields of Testing
CALIFORNIA STATE ENVIRONMENTAL LABORATORY ACCREDITATION PROGRAM Accredited Fields of Testing Basic Laboratory, Inc. 2218 Railroad Avenue Redding, CA 96001 Phone: (530) 243-7234 Field of Testing: 101 -
Combined Sewer Overflows July 2012-December 2013
CSO Facilities Summary Report 213 Combined Sewer Overflows July 212-December 213 Overview MWRA monitored four CSO facilities in the North System during the period covered in this report (July 212 December
Public Notice. Issuance of Industrial Waste Discharge Permit
Public Notice Issuance of Industrial Waste Discharge Permit LASA s regulations [ 60-16 (I)(1)] require public notification of the issuance of Industrial Waste Discharge Permits. LASA publishes this notice
Sample ID: NTF (Byproduct - Water) Sampled: 06/24/10 10:00 General Chemistry Parameters
ANALYTICAL REPORT Result Flag Units Dilution Analysis MRL Factor Date/Time Method Batch Sample ID: NTF2370-01 (Byproduct - Water) Sampled: 06/24/10 10:00 General Chemistry Parameters Acidity 1530 H mg/l
Appendix C1: Batch Kinetics Tests
Appendix C1: Batch Kinetics Tests This appendix contains the entire data set for the batch kinetics tests for the potential biofilter components. These tests were performed to provide estimates of optimal
March 9, Ken Fratesi, Manager West Helena Water Utilities 92 Plaza Street West Helena, Arkansas RE: Sanitary Sewer Collection System
March 9, 2012 Ken Fratesi, Manager West Helena Water Utilities 92 Plaza Street West Helena, Arkansas 72390 RE: Sanitary Sewer Collection System AFIN: 54-00086 NPDES Permit No.: AR0022021 Dear Mr. Fratesi: