AHERA/NESHAP ASBESTOS INSPECTION REPORT

Transcription

1 AHERA/NESHAP ASBESTOS INSPECTION REPORT CLIENT: Julie M. Wilkie City of Greenwood Assistant City Manager 520 Monument St., PO Box 40 Greenwood, SC (864) LOCATION: 118 Singleton Ct Greenwood, SC DATE OF INSPECTION: September 13, 2017 DATE OF REPORT: September 30, 2017 PREPARED BY: Michael D. Zavislak, NRCC-EAC, CHMM, CIH, PE (NC) & Robert Smith SUMMIT Engineering, Laboratory & Testing, P.C. (SUMMIT) 3575 Centre Circle Fort Mill, SC SUMMIT Job No

2 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 AHERA/NESHAP ASBESTOS INSPECTION REPORT 118 Singleton Ct Greenwood, SC TABLE OF CONTENTS SECTION PAGE TABLE OF CONTENTS... i LIST OF APPENDICES... i 1.0 REPORT CERTIFICATION EXECUTIVE SUMMARY SUSPECT MATERIALS Sheet Flooring Associated Sheet Flooring Mastic Floor Tile Associated Floor Tile Mastic Wall Board and Joint Compound Roofing CONCLUSIONS AND RECOMMENDATIONS... 4 FIGURES 1.0 Site Location Map LIST OF APPENDICES A Analytical Results B Asbestos Inspector s License C SUMMIT Documentation i

3 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, REPORT CERTIFICATION SUMMIT is pleased to provide environmental consulting services for City of Greenwood. Please contact this office at with any questions or comments regarding the findings submitted in this report. This document, entitled AHERA/NESHAP Asbestos Inspection Report, was prepared for City of Greenwood and the South Carolina Department of Health and Environmental Control (SCDHEC) with sound practices and procedures and in accordance with Asbestos Hazard Emergency Response Act (AHERA), Title II of the Toxic Substance Control Act (TSCA), SCDHEC Regulation , 40 CFR 61, and 40 CFR 763 for Asbestos Containing Materials (ACM) guidance. The results obtained by the work documented in this report fulfill the requirements of federal, state, and local regulations regarding Asbestos Containing Materials Michael D. Zavislak, NRCC-EAC, CHMM, PE (NC) Date SC DHEC AHERA Asbestos Inspector No. BI Expiration Date: November 4, 2017 SC DHEC AHERA Asbestos Management Planner No. MP SC DHEC AHERA Asbestos Project Designer No. PD SC DHEC AHERA Asbestos Air Sampler No. AS SC DHEC AHERA Asbestos Supervisor No. SA C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Asbestos Inspection.doc 1

4 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, EXECUTIVE SUMMARY On September 13, 2017, SUMMIT Engineering, Laboratory & Testing, P.C. (SUMMIT) performed an AHERA/NESHAP Asbestos Inspection for City of Greenwood located at 118 Singleton Ct, Greenwood, SC. The purpose of this inspection was to investigate available records for the specification of asbestos containing material (ACM), inspect for suspect materials, sample and analyze suspect materials to test for asbestos, and assess the condition and location of the ACM and other characteristics of the structure. A homogeneous material is a material that appears to be uniform when properties such as age, color, and texture are compared. Six (6) homogeneous areas were sampled. The homogeneous areas are described in detail in section 3.0 of this report. The wallboard and joint compound appears to be in damaged condition with a low potential for damage. The material is friable and is classified as a surfacing material. The material was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The wallboard and joint compound contains 2% Chrysotile asbestos and there is approximately 1200 square feet of this material. C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Asbestos Inspection.doc 2

5 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, SUSPECT MATERIALS 3.1 Sheet Flooring The sheet flooring appears to be in damaged condition with a low potential for damage. The material is non-friable and is classified as a miscellaneous material. The material was sampled and the results indicated that the material is classified as Non-Asbestos Containing Materials (ACM). The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. 3.2 Associated Flooring Mastic The associated flooring mastic appears to be in damaged condition with a low potential for damage. The material is non-friable and is classified as a miscellaneous material. The material was sampled and the results indicated that the material is classified as Non-Asbestos Containing Materials (ACM). The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. 3.3 Floor Tile The floor tile appears to be in damaged condition with a low potential for damage. The material is non-friable and is classified as a miscellaneous material. The material was sampled and the results indicated that the material is classified as Non-Asbestos Containing Materials (ACM). The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. 3.4 Associated Floor Tile Mastic The associated flooring mastic appears to be in damaged condition with a low potential for damage. The material is non-friable and is classified as a miscellaneous material. The material was sampled and the results indicated that the material is classified as Non-Asbestos Containing Materials (ACM). The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. 3.5 Wallboard and Joint Compound The wallboard and joint compound appears to be in damaged condition with a low potential for damage. The material is friable and is classified as a surfacing material. The material was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The wallboard and joint compound contains 2% Chrysotile asbestos and there is approximately 1,200 square feet of this material. The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Asbestos Inspection.doc 3

6 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, Roofing The roofing appears to be in damaged condition with a low potential for damage. The material is non-friable and is classified as a miscellaneous material. The material was sampled and the results indicated that the material is not classified as Asbestos Containing Materials (ACM). The sample analysis of the material is enclosed in Appendix A. A detailed map showing the locations of the sampling locations can be found in the SUMMIT Documentation. 4.0 CONCLUSIONS AND RECOMMENDATIONS On September 13, 2017, SUMMIT Engineering, Laboratory & Testing, P.C. (SUMMIT) performed a AHERA/NESHAP Asbestos Inspection for 118 Singleton Ct, Greenwood, SC. SUSPECT MATERIAL ACM (Y/N) FRIABLE (Y/N) AMOUNT (Square feet) Floor Tile N N 25 Associated Floor Tile N N 25 Mastic Wallboard and Joint Y Y 1200 Compound Sheet Flooring N N 160 Associated Flooring N N 160 Mastic Roofing N N 1,000 The wallboard and joint compound appears to be in damaged condition with a low potential for damage. The material is friable and is classified as a surfacing material. The material was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The wallboard and joint compound contains 2% Chrysotile asbestos and there is approximately 1,200 square feet of this material. If the structure is to be renovated or demolished, a copy of this report and a notification of demolition or renovation forms must be submitted to The South Carolina Department of Health and Environmental Control (SCDHEC) at least ten working days prior to these activities taking place. Bidders are responsible for their own calculations and estimates of quantities. Actual quantities may be more or less than indicated. Though every effort was made to examine wall cavities and other areas for pipe insulation, spray-applied or trowel applied miscellaneous material or other miscellaneous materials and other Presumed Asbestos Containing Material (PACM), this survey and report only deals with accessible areas of the building. There may be additional inaccessible areas above ceiling, behind walls and below floors that become evident during demolition or renovation activities. If suspect materials are found, additional asbestos testing may be required. C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Asbestos Inspection.doc 4

7 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 FIGURES C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Asbestos Inspection.doc

8 Figure 1 Site Location Map 118 Singleton Ct Greenwood, SC SUMMIT ELT, PC Project: C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R - Figure 1 Site Map.doc

9 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 APPENDIX A ANALYTICAL RESULTS C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\Appendix A.rtf

10 Asbestos Laboratory Report Prepared for SUMMIT Engineering, Laboratory & Testing, P.C. Project: 118 Singleton Ct. Summit #: Date Analyzed: 9/14/2017 Date Reported: 9/25/2017 Total Samples Analyzed: 20 # Samples >1% Asbestos: 1 Method of Analysis: EPA 600 / R93 / 116 Page 1 of 4

11 Summit Laboratories 3575 Centre Circle, Fort Mill, SC Phone: (704) Summit Order: SUMMIT Engineering, Laboratory & Testing, P.C Centre Circle Drive Fort Mill, SC Date Received: 9/14/2017 Date Analyzed: 9/24/2017 Date Reported: 9/25/2017 Project : 118 Singleton Ct. Test Report: Asbestos Analysis of Bulk Material via EPA 600/R-93/116 Method using Polarized Light Microscopy Asbestos Sample ID Description Appearance % Fibrous % Non-Fibrous % Asbestos SF 1-1-Flooring SF 1-1-Mastic A SF 1-2-Flooring SF 1-2-Mastic A SF 2-1-Flooring SF 2-1-Mastic A SF 2-2-Flooring SF 2-2-Mastic A FT-1-Floor Tile FT-1-Mastic A FT-2-Floor Tile FT-2-Mastic A DW-1-Drywall DW-1-Joint Compound A Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Floor Tile Floor Tile Floor Tile Floor Tile Drywall and Joint Compound Drywall and Joint Compound Tan,Brown Fibrous Gray Non-fibrous Tan,Brown Fibrous Gray Non-fibrous Blue,Gray Fibrous Gray Non-fibrous Blue,Gray Fibrous Gray Non-fibrous Gray,Beige Fibrous Tan Non-fibrous Gray,Beige Fibrous Tan Non-fibrous Gray,Brown Fibrous Tan Non-fibrous 15% Cellulose 1% Glass 84% Non-fibrous <1% Cellulose 100% Non-fibrous 15% Cellulose 1% Glass 84% Non-fibrous <1% Cellulose 100% Non-fibrous 15% Cellulose 1% Glass 15% Cellulose 1% Glass Non-Asbestos 84% Non-fibrous 100% Non-fibrous 84% Non-fibrous 100% Non-fibrous 2% Glass 98% Non-fibrous 100% Non-fibrous 2% Glass 98% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 98% Non-fibrous 2% Chrysotile Analyst(s): Chris Estes Page 2 of 4

12 Summit Laboratories 3575 Centre Circle, Fort Mill, SC Phone: (704) Summit Order: SUMMIT Engineering, Laboratory & Testing, P.C Centre Circle Drive Fort Mill, SC Date Received: 9/14/2017 Date Analyzed: 9/24/2017 Date Reported: 9/25/2017 Project : 118 Singleton Ct. Test Report: Asbestos Analysis of Bulk Material via EPA 600/R-93/116 Method using Polarized Light Microscopy Non-Asbestos Asbestos Sample ID Description Appearance % Fibrous % Non-Fibrous % Asbestos DW-2-Drywall DW-2-Joint Compound A DW-3-Drywall DW-3-Joint Compound A DW-4-Drywall DW-4-Joint Compound A DW-5-Drywall DW-5-Joint Compound A Roof Roof Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Asphalt Shingle Asphalt Shingle Gray,Brown Fibrous Gray,Brown Fibrous Gray,Brown Fibrous Gray,Brown Fibrous Black,Green Fibrous Black,Green Fibrous 10% Cellulose 90% Non-fibrous 10% Cellulose 90% Non-fibrous 10% Cellulose 90% Non-fibrous 10% Cellulose 90% Non-fibrous 20% Cellulose 80% Non-fibrous 20% Cellulose 80% Non-fibrous Positive Stop (not analyzed) Positive Stop (not analyzed) Positive Stop (not analyzed) Positive Stop (not analyzed) Analyst(s): Chris Estes Page 3 of 4

13 METHOD: EPA 600 / R93 / 116 For samples easily separated into homogeneous layers, each component will be analyzed separately. The sample may not be representative of the larger material in question. Interpretation and use of test results are the responsibility of the client. Due to the limitations of the EPA 600 Method, nonfriable organically bound materials (NOBs) such as vinyl floor tiles, mastic and roofing can be difficult to analyze by PLM. Reanalysis by Transmission Electron Microscopy (TEM) to verify results of <1% or None Detect for these materials is recommended. This sheet may not be reproduced except with permission from Summit Laboratories. This report must not be used by the client to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. Analyst(s): Chris Estes Approved By: Michael Zavislak, Approved Signatory NVLAP Lab Code Summit Laboratories, 3575 Centre Circle, Fort Mill, SC 29715, Phone: (704) Page 4 of 4 This is the last page of the report

14

15

16 September 25, 2017 SUMMIT Engineering, Laboratory & Testing, Inc Centre Circle Fort Mill, SC CLIENT PROJECT: 118 Singleton St.; CEI LAB CODE: T Dear Customer: Enclosed are asbestos analysis results for TEM bulk samples received at our laboratory on September 18, The samples were analyzed for asbestos using transmission electron microscopy (TEM) per Chatfield Method. Sample results containing > 1% asbestos are considered asbestos-containing materials (ACMs) per the EPA regulatory requirements. The detection limit for the TEM Chatfield method is <1% depending on the processed weight and constituents of the sample. Thank you for your business and we look forward to continuing good relations. If you have any questions, please feel free to call our office at Kind Regards, Tianbao Bai, Ph.D., CIH Laboratory Director 730 SE Maynard Road Cary, NC

17 ASBESTOS ANALYTICAL REPORT By: Transmission Electron Microscopy Prepared for SUMMIT Engineering, Laboratory & Testing, Inc. CLIENT PROJECT: 118 Singleton St.; CEI LAB CODE: T TEST METHOD: Bulk Chatfield EPA 600 / R93 / 116 REPORT DATE: 09/25/17 TEL:

18 ASBESTOS BULK ANALYSIS By: TRANSMISSION ELECTRON MICROSCOPY Client: SUMMIT Engineering, Laboratory & Testing, Inc Centre Circle Fort Mill, SC Project: 118 Singleton St.; TEM BULK CHATFIELD / EPA 600 / R93 / 116 Client ID Lab ID Material Description Sample Weight (g) Organic Material % Acid Soluble Material % Acid Insoluble Material % Asbestos % SF 1-3 Sheet Flooring None T68179 Detected SF 1-3 Tan Mastic None T68180 Detected SF 2-3 Floor Tile None T68181 Detected FT-3 Floor Tile None T68182 Detected FT-3 Clear Mastic None T68194 Detected Roof -3 Asphalt Shingle None T68195 Detected Page 1 of 2

19 LEGEND: None METHOD: CHATFIELD & EPA/600/R-93/116 LIMIT OF DETECTION: Varies with the weight and constituents of the sample (<1%) REGULATORY LIMIT: >1% by weight This report relates only to the samples tested or analyzed and may not be reproduced, except in full, without written approval by CEI Labs, Inc. CEI Labs makes no warranty representation regarding the accuracy of client submitted information in preparing and presenting analytical results. Interpretation of the analytical results is the sole responsibility of the client. Estimated measurement of uncertainty is available on request. Samples were received in acceptable condition unless otherwise noted. ANALYST: Jennifer Turner APPROVED BY: Tianbao Bai, Ph.D., CIH Laboratory Director Page 2 of 2

20

21

22 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 APPENDIX B INSPECTOR S LICENSES C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\Appendix B.rtf

23 SGDHEltrTSSUED Asbestos ld Card Michael Zavislak CONSULTPD PD.OOO92 AIRSAMPLER AS.O0296 SUPERAHERA SA-OI5'I5 GONSULTIIP MP.OO.I04 consultbt Bl E\piration Date,l,llo4l,l7 11t03t17 1,uou,t7,l,llo2l,l7 1,,1o2r,7

24 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 APPENDIX C SUMMIT DOCUMENTATION C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\Appendix C.rtf

25 AHERA/NESHAP Asbestos Inspection SUMMIT Project No Singleton Ct, Greenwood, South Carolina September 30, 2017 SITE PHOTOGRAPHS Front of structure. C:\Users\rsmith\Desktop\Greenwood\118 Singleton Ct\R-Ph I - Site Photographs.doc 1

26