CHARLEVILLE. Dawn Meats Charleville AER IE Licence Reg No. P Ardnageehy Charleville Co. Cork

Transcription

1 CHARLEVILLE Dawn Meats Charleville AER 2016 IE Licence Reg No. P Ardnageehy Charleville Co. Cork

2 Contents 1 Introduction Licence Details Summary Data Table Company Profile Schedule of Objectives and Targets 2016 and 2017 Plans Review of Objectives and Targets Schedule of Objectives and Targets Management Programme and objectives and targets Summary Emissions to Water Summary Details of Non-Compliance s Surface Water Monitoring Summary Details of Non-Compliance s Ground Water Monitoring Waste Management Organic Waste Management Resource Consumption Summary Energy Consumption Water Usage Complaints Summary Reported Incidents Summary Pollution Emissions Register Environmental Liabilities Risk Assessment... 32

3 Appendix 1 Electronic AER Submission Sheets Tables: 1. Schedule of objectives and Targets Schedule of objectives and targets Treated Effluent Emissions (ELV s) 4. Summary Mass Emission Data EW-1 5. Surface water analytical results SW -2, 3 and 4 6. Groundwater Monitoring Results 2016 GW 7. Hazardous/non-Hazardous Waste 8. Hazardous sent off site 9. Non-Hazardous sent off site 10. Hazardous/Non-Hazardous Waste sent off site for Recovery/Disposal 11. Organic Waste Arising Jan - Dec Summary Energy Consumption Data 13. Plant water consumption

4 Figures: 1. Light Oil consumption 2015 and Tallow consumption 2015 and Electricity Usage 2015 and Water usage 2015 and Comparison of Non Hazardous Waste Arising 15 & Comparison of non-animal tissue waste 7. Comparison of SRM waste 8. Comparison of Non Hazardous Waste Arising 15 & Comparison of Organic waste generated in 15 & Energy consumption in both oil and tallow for 2015 and Water usage in 2015 and 2016.

5 1 Introduction This document is the twelfth Annual Environmental Report (AER) covering environmental performance at Dawn Meats Charleville. This report updates the information contained in the last AER to the end of December 2016 and summarises all data for the 2016 monitoring period and makes comparisons with year 2015 results. This document updates the following sections of the monitoring period 2015/2016 AER: Section 2.0 Schedule of Objectives & Targets & EMP Section 3.0 Emissions to Water Summary Section 4.0 Surface Water Monitoring Summary Section 5.0 Groundwater Monitoring Summary Section 6.0 Waste Management Summary Section 7.0 Resource Consumption Summary Section 8.0 Complaints Summary Section 9.0 Reported Incidents Summary Section 10.0 Pollutions Emission register. Section 11.0 Environmental Liabilities Risk Assessment. Details of the achievements of the Environmental Management Plan are included as Sections 2.0.to Licence Details Licensee: Location of Activity: IE Licence Register No.: Dawn Charleville Ardnageehy, Charleville, Co. Cork P

6 1.2 Summary Data Table Current IE Licence annual reporting requires the submission of summary monitoring, resource use, complaints and waste management information in the form of a spreadsheet, which is transmitted to the Agency electronically. A print out of this summary data spreadsheet is included as Attachment A to this AER. The spreadsheet has been submitted electronically to the EPA at Company Profile Dawn Charleville is a subsidiary of the Dawn Meats Food Group and was acquired in January 2004 from the Dairygold Co-Operative Society Ltd. The company was founded in the 1930s by the Ryan family and has undergone major investment particularly in recent years. This has included the addition of a new Boning Hall complex, Slaughter line and product chills. The company now has the capacity to slaughter and process 2000 cattle per week in one of the most modern and progressive beef plants in the country. This places Dawn Charleville in a commanding position to be able to service customer requirements with top quality Irish beef sourced from farmers in the surrounding hinterland. With a strong export orientated customer base in the UK, Europe, Scandinavia and the Middle East, Charleville Foods is well placed to meet future market demands. Other facilities include beef plants, which are located at, Ballyhaunis, Rathdowney, Grannagh, Carroll s Cross. We also have beef processing facilities in the UK and on the Continent The primary environmental emissions at the plant relate to the discharge of treated wastewater and the generation of organic waste as sludge, which is land spread. The environmental performance of the facility is regulated under an IE licence (Reg. No. P ). Environmental management at the site, including compliance with the IE licence, is achieved through a structured Environmental Management System (EMS). 2

7 Dawn Charleville CEO Niall Browne Group IT Manager Shane Slattery Group Technical Manager Brian Hyland Operations Manager Noel Donworth Group Environmental Managers Donal Coughlan/Jack Fahey Group Health & Safety Manager John Kearney Production Manger Derek Daly Financial Controller John Biggs Technical/Environmental Manager Michael Betts Dispatch Manager John O Neill Slaughter Hall Manager Willie Shanahan Maintenance Manager David O Brien Procurement Manager Paul Mullaney Sales Department Ed Fitzgerald Tadgh Lane Health & Safety Martin Lane Environmental Co-ordinator Johnathan Reddin Loading Bay Supervisor Peter O Toole Slaughter Hall Supervisor Paul Stafford Boning Hall Manager Joe Corbett Environmental Technician Vasili Barysau Plant Operatives 3

8 2. Schedule of Objectives and Targets 2016 and 2017 Plans. This section includes (2.1) progress achieved in meeting deadlines set for the 14 Objectives and targets from the 2015 Schedule. Section 2.2 contains the objectives and targets for While section 2.3 details the Environmental Management Programme and Objectives and Targets as outlined in section 2.2. Table 1: Schedule of objectives and Targets Projects Target Summary Deadline Responsibility Indicators Status EMP 01 Pipeline Testing EMP 02 Bund Integrity Testing EMP 03 Boiler Testing Underground pipelines Tallow, Diesel, Generator and central heating Bund Boiler testing Programme of testing Underground Pipelines. Programme of testing bunds. Ensure boiler is operating efficiently and safely. Every 3 years Every 3 years June Maintenance Manager Maintenance Manager Maintenance Manager Reports Reports Reports, Records To be completed 2017 To be completed 2017 Completed EMP 04 Effluent discharge EMP 5 Efficient Process Control Evaluate effect on land Process control Carryout evaluation of repeated application of treated effluent to land. By completing test monitoring of wells. Identify and maintain a programme to ensure adequate control of processes Dec 2016 December Environmental Manager Environmental Manager Report Report Completed. Will be included in 2017 EMP s Completed. Will be included in 2017 EMP s 4

9 Objective 2 - Waste Management (Reduction, recycling, reuse, & safe disposal) Projects Target Summary Deadline Responsibility Indicators Status EMP 6 Treatment of Organic Waste Organic Waste Investigate on and off site treatment for organic waste streams such as anaerobic digestion and composting. December Group Environmental Manager Group tracking and investigation of options to stabilise waste streams Reviewed at group level. Will be included in

10 Objective 3 Risk Control / Legislative Compliance compliance with relevant environmental legislation Projects Target Summary Deadline Responsibility Indicators Status EMP 7 Waste Contractor Review Waste Contractors and Transport Companies Ongoing review of waste contractor s licenses and register of licenses held on file. December Environmental Manager Records Complete. Will be included in 2017 EMP s EMP 8 Suppliers EMP 9 Legislation Supplier Awareness Legislation file. Issue copy of supplier questionnaire, contractor s rules and environmental policy to all suppliers Review of current legislation and an assessment of its relevance to site activity and legislation file December December Environmental Manager Environmental Manager Correspondence File Register of Legislation Complete. Will be included in 2017 EMP s Complete. Will be included in 2017 EMP s 6

11 Objective 4 Energy Efficiency / Reduction in Carbon Footprint Projects Target Summary Deadline Responsibility Indicators Status EMP 10 Reduce-Energy Usage. Install VSD drive in the compressor to reduce energy usage. Reduce electricity usage Reduce electricity usage in the plant. December Maintenance Manager Reduced electricity usage. Complete. Will be included in 2017 EMP s 7

12 Objective 5 Conservation of Natural Resources Projects Target Summary Deadline Responsibility Indicators Status EMP 11 Maintenance Water Usage December Manager Reduce Water Usage Target water usage is 1.25m³/head Ongoing monitoring of water usage throughout plant and comparison at group level to industry usage levels Water usage under 1.25m³/head Complete. Will be included in 2017 EMP s 8

13 Objective 6 Promotion of Environmental Awareness Projects Target Summary Deadline Responsibility Indicators Status EMP 12 Staff Training EMP 13 Internal Audits Staff Induction Training Verify that the site environmental performance and compliance on a regular basis through scheduled, structured and objective internal audits. All new employees to receive environmental induction training. All employees to receive refresher training at least every 3 years. Scheduled Audit of Environmental Management System. Dec Technical Manager Records Complete. Will be included in 2017 EMP s June Group Environmental Manager. Audit Reports Complete. Will be included in 2017 EMP s EMP 14 Aspects Register. Aspects Register. Review aspects register and update. June Environmental Manager Aspects Register Complete. Will be included in 2017 EMP s 9

14 2.1 Review of Objectives and Targets 2016 EMP 01: Pipeline Testing This project has been completed in 2014, due again in EMP 02: Bund Integrity Testing This project has been completed in 2014, due again in EMP 03: Boiler Testing This project has been completed for 2016, due again in EMP 04: Effluent Discharge This project has is complete and will continue into EMP 06: Treatment of organic waste. This project is still in discussions with organisations in relation to this project EMP 07: Waste Contractor Review This project has been completed in 2016, due again in EMP 08: Suppliers All suppliers to Dawn Charleville has been issued with a copy of the company s supplier questionnaire, contractor s rules and environmental policy. EMP 09: Legislation New legislation is reviewed on-going and any relevant legislation is added to our complete file. Environmental team receives updates from peagus system on any changes to legislation. EMP 10: Reduce Energy Usage Various projects have been completed to help us reduce our carbon footprint and reduce our energy usage. Light oil consumption has significantly reduced from 2015 to 2016 (see graph below). 10

15 Litres (L) Litres (L) Dawn Meats Charleville January 2017 Tallow consumption has increased from 2015 to This accounts somewhat for the decrease in oil usage (fossil fuel). Electricity usage has increased slightly; this can be attributed to the increased in production for Figure 1: Light Oil consumption 2015 and Light Oil Consumption (L) Year 2015 Year 2016 Year Figure 2: Tallow consumption 2015 and Tallow Consumption (L) Year 2015 Year 2016 Year 11

16 Meters Cubed (m3) kwh Dawn Meats Charleville January 2017 Figure 3: Electricity Usage 2015 and Electricity Consumption (kwh) Year 2015 Year 2016 EMP 11: Reduce Water Usage This project is ongoing and will be included in the 2017 programme. Figure 4: Water usage 2015 and Water Usage (m3) Year 2015 Year

17 EMP 12: Staff Training All staff have received environmental training at induction; this training has been documented on a detailed training matrix. EMP 13: Internal Audits. Environmental audits are scheduled on an annual basis to cover all aspects of the environmental management system. This audit for 2016 has been completed and closed out. EMP 14: Aspects Register The Aspects register was reviewed and updated and completed for

18 2.2 Schedule of Objectives and Targets Objectives & Targets* 2017 Table 2: Schedule of objectives and targets 2017 Dawn Meats Charleville January 2017 Projects Target Responsibility Status EMP 01 Pipeline Testing EMP 02 Bund Integrity Testing EMP 03 Underground pipelines Maintenance Manager Due in Tallow, Diesel, Generator and central heating Bund Maintenance Manager Due in Boiler testing Maintenance Manager Ongoing Boiler Testing EMP 04 Effluent discharge Evaluate effect of application of treated effluent to land Group/Site Environmental Manager Ongoing EMP 5 Process control Environmental Manager Ongoing Efficient Process Control 14

19 EMP 6 Treatment of organic Waste EMP 7 Waste Contractor Review EMP 8 Increase waste segregation and in turn increase site recycling EMP 9 Suppliers EMP 10 Legislation Organic Waste Group Environmental Manager Ongoing Waste Contractors and Transport Companies Environmental Manager Ongoing. Implement waste management plan on site. Investigate opportunities to capture recyclable waste Environmental Co-ordinator Ongoing Supplier Awareness Environmental Manager Ongoing. Legislation file. Environmental Manager Ongoing EMP 11 Reduce-Energy Usage. Identify energy saving projects Reduce electricity usage. Insulation of pipework, environmental/energy audits. Identify energy savings projects Environmental Co-ordinator Ongoing EMP 12 Reduce Carbon Footprint EMP 13 Water Usage EMP 14 Staff Training Meet Dawn Meats 2020 sustainability targets. Determine KPI s. Analyse monthly data. Investigate energy efficiency on site. Reduce Water Usage Target water usage is 1.31m³/head. Projects on water metering, flow reduction, and recycling. Environmental Co-ordinator Maintenance Manager/Environmental Co-ordinator Ongoing Ongoing Staff Induction Training. Technical Manager Ongoing 15

20 EMP 15 Internal Audits Verify that the site environmental performance and compliance on a regular basis through scheduled, structured and objective internal audits. Group Environmental Manager/Environmental Co-ordinator Ongoing. EMP 16 Aspects Register. Aspects Register. Environmental Manager/coordinator Ongoing. 16

21 2.3 Management Programme and objectives and targets Summary Dawn Charleville Environmental Management Programme and Objectives and Targets are committed to ensuring a significant effort and more attention is paid to improvements in efficiency at the plant, in terms of energy consumption, water use and waste generation. The focus of the 2017 EMP will be largely in these areas, using the EMP as a management tool for planning and tracking the implementation of projects on site which lead to the overall achievement of the Dawn Group Environmental Policy, while ensuring compliance with the IE license remains a high priority. A number of long-term on-going programmes initiated at the site will continue on an ongoing basis to ensure compliance with the conditions of the IE licence and the site environmental management system. 17

22 3.0 Emissions to Water Summary Environmental monitoring data for the period January to December 31, 2016 is summarised in the following sections. Treated process wastewater is discharged into the Shruhaveballiv stream. Emissions to water are regulated under Condition 6 and Schedule 1 of the IE as follows: Table 3: Treated Effluent Emissions (ELV s) Emission Point Reference No.: Name of Receiving Waters: Location: SW-1 Shruhaveballiv Charleville, Co. Cork Volume to be emitted: Maximum in any one day: Maximum rate per hour: Parameter 800 m 3 40 m 3 Emission Limit Value ph 6-9 BOD (mg/l) 10 Suspended Solids (mg/l) 15 Total Nitrogen (as N) (mg/l) 15 Total Ammonia (as N) mg/l 8 Total Phosphorus (as P) (mg/l) 2 Note1: Emission Limit value for Total Ammonia (as N) mg/l will be 0.65 from December Note2: Emission Limit value for Total Phosphorus (as P) (mg/l) will be 0.35 from December Table 4: Summary Mass Emission Data EW-1 Parameter Mass Emission 2015 (kgs) Mass Emission 2016 (kgs) Permitted Mass Emission (kgs) * Flow (m 3 ) ,000 BOD ,920 Suspended Solids ,380 Total Nitrogen ,760 Total Ammonia (as N) ,336 Total Phosphorus (as P) Permitted mass emissions based on discharges at ELV and maximum daily flow 18

23 3.1 Details of Non-Compliance s There were no non-compliant samples recorded during the 2016 monitoring period, giving an overall percentage compliance rate of 100%. 4.0 Surface Water Monitoring Summary Surface water runoff collected from clean yard and roof area discharges by gravity to the stream at Emission Point Ref s SW- 2 and SW-3. This stream discharges to the Shruhaveballiv stream, at a point downstream from Dawn Charleville. Analysis is carried out on a monthly basis for ph, Total Ammonia, BOD, Total Nitrogen and conductivity. Also a visual inspection is carried out three times per day. Table 5: Surface water analytical results SW -2, 3 and 4 Parameter Emission Ref. Conductivity Total N ph BOD (mg/l) NH3 (mg/l) Results based on average monitoring results over the 12-month monitoring period. The 2016 analysis results were compared with the results from There was no significant difference in the results. In addition, a visual examination at the surface water discharge point is carried out three times daily and an inspection log is maintained under the EMS documentation system. 4.1 Details of Non-Compliance s There were no non-compliant samples recorded during the 2016 monitoring period, giving an overall percentage compliance rate of 100% 19

24 5.0 Ground Water Monitoring Groundwater monitoring results: The results indicated that there was no evidence of contamination. These results proved to be within specified limits in all cases. Table 6: Groundwater Monitoring Results 2016 GW Parameter Concentration 24/03/ /07/ /02/ /08/2016 GW1 GW2 GW1 GW2 ph BOD <2mg/l <2mg/l <2mg/l <2 Nitrate <0.2 mg/l <0.2 mg/l <0.5 mg/l <0.5 Total Ammonia 0.06 mg/l 0.05 mg/l <0.05 mg/l 0.07 Total Nitrogen <0.02 mg/l <0.05 mg/l <1.0mg/l <1 Conductivity 700 us/cm 698 us/cm 707 us/cm Waste Management Management of solid non-hazardous and hazardous wastes are recorded in accordance with Condition 7 of the IE Licence. Summary data from the waste management register are tabulated on Table 7. Totalled annual data is set out below: 20

25 Table 7: Hazardous/non-Hazardous Waste Waste Type Total quantity of waste produced in calendar year (Tonnes) Total quantity of waste disposed of onsite Total quantity of waste disposed of off-site Total quantity of waste recovered onsite Total quantity of waste recovered offsite Non-Hazardous Quantity of non-hazardous waste produced in calendar year (T) Quantity of non-hazardous waste disposed of on-site 0 0 Quantity of non-hazardous waste disposed of off-site Quantity of non-hazardous waste recovered on-site 0 0 Quantity of non-hazardous waste recovered off-site Hazardous Quantity of hazardous waste produced in calendar year (Tonnes)

26 Quantity of hazardous waste disposed of on-site Quantity of hazardous waste disposed of off-site Quantity of hazardous waste recovered on-site 0 0 Quantity of hazardous waste recovered off-site (The above data includes organic waste arising at the site.) Organic waste management is carried out in accordance with a Nutrient Management Plan (copy of which has been submitted to the EPA under separate cover). The following materials are considered to be by-products of the slaughtering process, and accordingly, were not included in the waste tables: Pet Food (lungs, liver, trachea, tripe, greaves and head & heart) Hides Effluent sludge and paunch A comparison of summary information on non-hazardous and hazardous wastes between 15 and 16 is presented graphically on Figures 5, 6, 7 and 8 below, while a detailed breakdown is presented in tables 8, 9, and 10. The information tabulated below has been transmitted to the Agency via 22

27 Table 8: Hazardous sent off site Hazardous Waste sent off site for Recovery/Disposal 2015 Reporting Period Jan 16 to Dec 16 Waste Material EWC Code T/LT Description and Nature of Waste Haulage Contractors Recovery Contractor Disposal Contractor Hydraulic Oil Waste Oil Enva Ireland Ltd. Enva Ireland Ltd. Enva Ireland Ltd. Sludge Oil Tank Cleanings Enva Ireland Ltd. Enva Ireland Ltd. Enva Ireland Ltd. Fluorescent Tubes Fluorescent Tubes Irish Lamp Recycling Co. Ltd Irish Lamp Recycling Co. Ltd Irish Lamp Recycling Co. Ltd IE Licence Reg. P

28 Table 9: Non-Hazardous sent off site Non-Hazardous Waste Sent Off-Site for Recovery/Disposal 2016 Reporting Period Jan 15 to Dec 15 Waste Material EWC Code T/LT Description & Nature of Waste ETP Primary weir contents Haulage Contractor ETP Primary weir contents Agrilife Ltd Lyre, Lismore, Co Waterford Bovine Slurry WWTP Bovine Slurry Agrilife Ltd Recovery Contractor Farmers as listed in the Organic Waste Registers Disposal Contractor Agrilife Ltd Lyre, Lismore, Co Waterford Truck Wash Solid Waste De-watered Sludge/Paunch DAF Sludge & brush screen solids WWTP Truck Wash Solid Waste Straw De-watered Sludge from belt press and Paunch Included with Bovine Slurry DAF Sludge & brush screen solids Agrilife Ltd Agrilife Ltd Agrilife Ltd Offal/Fat Offal/ Fat Ward Transport Western Proteins Western Proteins, Ballyhaunis, Co Mayo Bone Bone Ward Transport Western Proteins Western Proteins, Ballyhaunis, Co Mayo Blood for rendering Blood for rendering Brian Kehoe APC Technologies APC Technologies, Lurgan Blood for rendering NA Blood for rendering Ward Transport Waterford Proteins Waterford Proteins, Waterford Specified Risk Material Bovine Animal Slaughtered Wards Transport Dublin By-Products. Dublin By-Products, Dunlavin, Co Wicklow IE Licence Reg. P

29 Reporting Period Jan 15 to Dec 15 Waste Material EWC Code T Description & Nature of Waste Non-soiled Cardboard Non-soiled cardboard Starrus Eco Holdings Ltd (Greenstar),NWCPO Haulage Contractor Recovery Contractor Disposal Contractor Starrus Eco Holdings Ltd (Greenstar),NWCPO Starrus Eco Holdings Ltd (Greenstar),NWCPO Scrap Metal Scrap Metal Hennessy Environmental Domestic Waste Canteen & yard Starrus Eco Holdings Ltd (Greenstar),NWCPO Steel Drums NA Empty steel drums Hennessy Environmental Meat Rope NA Boning Halls Starrus Eco Holdings Ltd (Greenstar),NWCPO Mixed Packaging NA Canteen Starrus Eco Holdings Ltd (Greenstar),NWCPO Clean Plastic Clean Plastic Starrus Eco Holdings Ltd (Greenstar),NWCPO Hennessy Environmental Starrus Eco Holdings Ltd (Greenstar),NWCPO Hennessy Environmental Starrus Eco Holdings Ltd (Greenstar),NWCPO Starrus Eco Holdings Ltd (Greenstar),NWCPO Starrus Eco Holdings Ltd (Greenstar),NWCPO Hennessy Environmental Starrus Eco Holdings Ltd (Greenstar),NWCPO Hennessy Environmental Starrus Eco Holdings Ltd (Greenstar),NWCPO Starrus Eco Holdings Ltd (Greenstar),NWCPO Starrus Eco Holdings Ltd (Greenstar),NWCPO IE Licence Reg. P

30 Tonnes (t) Tonnes (T) Dawn Meats Charleville January 2017 Figure 5: Comparison of Non Hazardous Waste Arising 15 & & 2016 Waste Bone Fat/offal Blood Totals 2015 Totals 2016 Figure 6: Comparison of non-animal tissue waste 140 Non-Animal Waste 2015 vs Domestic Waste Cardboard Plastic Totals 2015 Totals 2016 IE Licence Reg. P

31 Tonnes (T) Tonnes (t) Dawn Meats Charleville January 2017 Figure 7: Comparison of SRM waste & 2016 SRM Waste Totals 2015 Totals 2016 Totals 2015 Totals 2016 The increase in waste produced above can be attributed to the increase in numbers of animals slaughtered in 2016 in comparison to Domestic waste has reduced which can be attributed to increase in the level of plastic and cardboard recycled. Figure 8: Comparison of Non Hazardous Waste Arising 15 & Non Hazardous Waste 2015 & Totals 2015 Totals 2016 Totals 2015 Totals 2016 IE Licence Reg. P

32 Table 10: Hazardous/Non-Hazardous Waste sent off site for Recovery/Disposal Waste Material T/LT T/LT Reason for Variance Hydraulic Oil/Waste drums NA Sludge Oil NA Fluorescent Tubes NA N/A NA Waste Material T/LT T/LT Reason for Variance De-watered Sludge/Paunch Increase in kill Offal/Fat increase in animals slaughtered. Bone Blood for rendering Specified Risk Material increase in animals slaughtered. Non-soiled Cardboard Increased material captured or recycling Scrap Metal Domestic Waste Improved recycling Clean Plastic Reduction in excess packaging and material IE Licence Reg. P

33 Tonnes (T) Dawn Meats Charleville January Organic Waste Management Organic waste at the facility arises from the treatment of process wastewater and from the storage of paunch material of slaughtered animals. Liquid effluents from the processing and washing operations drain to an on-site wastewater treatment plant. The plant is a biological treatment (activated sludge) system. Settled solids from the treatment plant are dewatered on a belt press, with the excess water returned to the treatment plant. Paunch contents are stored in an on-site paunch holding area. The material is spread on approved land banks during the year. This Organic waste is land spread in accordance with a Nutrient Management Plan (NMP). The quantity of organic waste arising for the calendar year 2015 and 2016 is tabulated on Table 11. Year Table 11: Organic Waste Arising Jan - Dec 2016 Total (T) *Increase from 2015 to 2016 (increase in kill). Figure 9: Comparison of Organic waste generated in 15 & Organic Waste 2015 and Year 2015 Year 2016 Year 2015 Year 2016 IE Licence Reg. P

34 kwh Dawn Meats Charleville January Resource Consumption Data relating to energy consumption (electricity and fuel) and water for the 2016 period. 7.1 Summary Energy Consumption Table 12: Summary Energy Consumption Data Year Fuel Consumption (kwh) Electricity Consumption (kwh) Analysis of the data indicates that there was a slight increase in energy used; this can be attributed to the increased production volume. Figures 10: indicates the energy consumption in both oil and tallow for 2015 and Energy Usage 2015 & Fuel Electricity IE Licence Reg. P

35 Meters Cubed (m3) Dawn Meats Charleville January Water Usage Water consumption for the site for the 2015 and 2016 reporting period is summarised on Table 13. Plant water demand is met from the company s own well supply, while the town s public water supply is used for the canteen. Table 13: Plant water consumption Year Water Consumption Figure 11: Water usage in 2015 and Water Usage (m3) Year 2015 Year Complaints Summary There were 3 complaints received during Reported Incidents Summary No incidents occurred during IE Licence Reg. P

36 10.0 Pollution Emissions Register A PER report is not generated as agreed with the Agency as the site does not use substances which would require a PER Environmental Liabilities Risk Assessment A Closure Plan and Environmental Liabilities Risk Assessment are currently being prepared for Dawn Charleville. Dawn Charleville will ensure there is adequate financial provision and insurance cover to address any potential environmental liabilities, and decommission the site in the event of an unforeseen closure. The facility has an Environmental Management Programme (EMP) in place. The EMP serves as a guidance document for facility staff and describes operational control and management practices that are applied at the facility. The EMP is also the core element of the Environmental Management System (EMS) for the facility and is designed to ensure that management of site activities complies with regulatory requirements and best practice. The EMS includes a detailed Emergency Response Procedure which sets out the steps to be taken in the event of an incident at the facility with the potential to cause environmental damage. In addition to the above mentioned Dawn Charleville implements a comprehensive monitoring programme which will highlight any potential environmental incidents with the potential to cause environmental damage. A full copy of the report will be issued to the Environmental Protection Agency under a separate report. IE Licence Reg. P

37 PRTR# : P0173 Facility Name : Daw n Meats Ireland t/a Daw n Charleville Filename : P0173_ xlsx Return Year : 2016 REFERENCE YEAR 2016 Guidance to completing the PRTR workbook PRTR Returns Workbook 1. FACILITY IDENTIFICATION Parent Company Name Dawn Meats Ireland Facility Name Dawn Meats Ireland t/a Dawn Charleville PRTR Identification Number P0173 Licence Number P Classes of Activity No. class_name - Refer to PRTR class activities below Version Address 1 Ardnageehy Address 2 Charleville Address 3 Address 4 Cork Country Ireland Coordinates of Location River Basin District IESW NACE Code 1011 Main Economic Activity Processing and preserving of meat AER Returns Contact Name Michael Betts AER Returns Contact Address michael.betts@dawnmeats.com AER Returns Contact Position AER Returns Contact Telephone Number AER Returns Contact Mobile Phone Number AER Returns Contact Fax Number Production Volume 0.0 Production Volume Units Number of Installations 0 Number of Operating Hours in Year 0 Number of Employees 310 User Feedback/Comments Two new waste streams were added to treatment & transfer of wastes" file. Paper and metal waste have now been added. Web Address 2. PRTR CLASS ACTIVITIES Activity Number 8(a) Activity Name Slaughterhouses 3. SOLVENTS REGULATIONS (S.I. No. 543 of 2002) Is it applicable? Have you been granted an exemption? If applicable which activity class applies (as per Schedule 2 of the regulations)? Is the reduction scheme compliance route being used? 4. WASTE IMPORTED/ACCEPTED ONTO SITE Guidance on waste imported/accepted onto site Do you import/accept waste onto your site for onsite treatment (either recovery or disposal IE Licence Reg. P activities)? This question is only applicable if you are an IPPC or Quarry site 33

38 SECTION A : SECTOR SPECIFIC PRTR POLLUTANTS Data on ambient monitoring of storm/surface water or groundwater, conducted as part of your licence requirements, should NOT be submitted under AER / PRTR RELEASES TO WATERS Please enter all quantities in this section in KGs POLLUTANT ADD EMISSION POINT QUANTITY Method Used No. Annex II Name M/C/E Method Code Designation or Description Emission Point 1 T (Total) KG/Year A (Accidental) KG/Year F (Fugitive) KG/Year 12 Total nitrogen M PER Total phosphorus M PER ADD NEW ROW DELETE ROW * * Select a row by double-clicking on the Pollutant Name (Column B) then click the delete button SECTION B : REMAINING PRTR POLLUTANTS RELEASES TO WATERS Please enter all quantities in this section in KGs POLLUTANT ADD EMISSION POINT QUANTITY Method Used No. Annex II Name M/C/E Method Code Designation or Description Emission Point 1 T (Total) KG/Year A (Accidental) KG/Year F (Fugitive) KG/Year ADD NEW ROW DELETE ROW * * Select a row by double-clicking on the Pollutant Name (Column B) then click the delete button SECTION C : REMAINING POLLUTANT EMISSIONS (as required in your Licence) RELEASES TO WATERS POLLUTANT Please enter all quantities in this section in KGs ADD EMISSION POINT QUANTITY Method Used Pollutant No. Name M/C/E Method Code Designation or Description Emission Point 1 T (Total) KG/Year A (Accidental) KG/Year F (Fugitive) KG/Year 238 Ammonia (as N) M PER Suspended Solids M PER BOD M PER COD M PER Fats, Oils and Greases M PER IE Licence Reg. P

39 5 17 Please enter all quantities on this sheet in Tonnes 17 Haz Waste : Name and Licence/Permit No of Next Quantity Destination Facility Haz Waste : Address of Next Name and License / Permit No. Actual Address of Final Non Haz Waste: Name and Destination Facility and Address of Final Recoverer / Destination i.e. Final Recovery / (Tonnes per Year) Method Used Licence/Permit No of Recover/Disposer Non Haz Waste: Address of Recover/Disposer Disposer (HAZARDOUS WASTE ONLY) Disposal Site (HAZARDOUS WASTE ONLY) Transfer Destination European Waste Code Hazardous Description of Waste Waste Treatment Operation M/C/E Method Used Location of Treatment animal faeces, urine and manure (including Within the Country No spoiled straw), effluent, collected separately and treated off-site R10 M Weighed Offsite in Ireland Lyre,Lismore,waterford,Co Waterford,Ireland Western Protiens,P Ballyhaunis,.,.,Co Within the Country No animal-tissue waste R3 M Weighed Offsite in Ireland R918 Mayo,Ireland Western Protiens,P Ballyhaunis,.,.,Co Within the Country No animal-tissue waste R3 M Weighed Offsite in Ireland R918 Mayo,Ireland Within the Country No animal-tissue waste R3 M Weighed Offsite in Ireland Apc Technologies,XAP/25/22/IP CO/CBC/102/99 Lurgan,.,.,Co Armagh,Ireland Within the Country No animal-tissue waste R3 M Weighed Offsite in Ireland Diublin By products,r910 Dunlavin,.,.,Co Wicklow,Ireland Within the Country No sludges from on-site effluent treatment R10 M Weighed Offsite in Ireland Agrilife Ltd,CK WMC43/01 Lyre,Lismore,waterford,Co Waterford,Ireland Clonmainin,Indusrial Enva Ireland,W0184-1,Clonmainin Ind Clonmainin Ind estate,portloaise,loais,irelan Estate,Portlaoise,Laoise,.,Ir Estate,Portlaoise,Laoise,.,Ir Within the Country Yes other engine, gear and lubricating oils R1 M Weighed Offsite in Ireland Enva Ireland Ltd,WO184-1 d eland eland Within the Country No 31.2 paper and cardboard packaging R3 M Weighed Offsite in Ireland Starrus Eco Holdings Ltd (Greenstar),NWCPO Unit 6,Ballyogan Business Park,Ballyogan Road,Dublin 18,Ireland Within the Country No 12.8 plastic packaging R3 M Weighed Offsite in Ireland Starrus Eco Holdings Ltd (Greenstar),NWCPO Unit 6,Ballyogan Business Park,Ballyogan Road,Dublin 18,Ireland To Other Countries No 92.0 mixed municipal waste D10 M Weighed Abroad Starrus Eco Holdings Ltd (Greenstar),NWCPO Unit 6,Ballyogan Business Park,Ballyogan Road,Dublin 18,Ireland Within the Country No 0.9 paper and cardboard R3 M Weighed Offsite in Ireland Great White Destruction Ltd,NWCPO Southern Truck Recycling Company Ltd (STR),WFP- Within the Country No 3.25 metals R4 M Weighed Offsite in Ireland CK Duggan Industrial Estate,Athboy Road,Trim,Co. Meath,Ireland Cloughleafin,.,Mitchelstown, Co. Cork,Ireland IE Licence Reg. P