DVPTC. Multi-Position, Variable-Speed, ECM-Based Air Handler with Internal TXV ComfortNet Compatible 2 to 5 Tons

Transcription

1 DVPTC Multi-Position, Variable-Speed, ECM-Based Air Handler with Internal TXV ComfortNet Compatible 2 to 5 Tons Contents Air Handler Nomenclature...2 Heater Kit Nomenclature...2 Product Specifications...3 Dimensions...4 Airflow Data...6 Heat Kit Data...8 Wiring Diagram...10 Accessories...11 Product Features Internal factory-installed thermal expansion valves for cooling and heat pump applications Variable-speed ECM blower motor ComfortNet Communicating System compatible Auto configuration of the airflow and tonnage in communicating mode All-aluminum evaporator coil Provides constant CFM over a wide range of static pressure conditions independent of duct system CFM indicator Fault recall of six most recent faults Provides adjustable low CFM for efficient fan-only operation Improved humidity and comfort control Built-in compatibility with multi-stage heat pump and cooling applications AHRI certified; ETL listed Cabinet air leakage less than 2.0% at 1.0 inch H2O when tested in accordance with ASHRAE standard 193 Cabinet air leakage less than 1.4% at 0.5 inch H2O when tested in accordance with ASHRAE standard kw 25 kw electric heater kits Horizontal or vertical configuration capabilities 21 depth for easier attic access DecaBDE-free thermoplastic drain pan with secondary drain connections Screw-less sides and back helps to reduce condensation when installed in humid locations Foil-faced insulation covers the internal casing to reduce cabinet condensation Galvanized, leather grain-embossed finish Glue-less cabinet insulation retention Tool-less filter access * Complete warranty details available from your local dealer or at To receive the 6-Year Unit Replacement Limited Warranty and 12-Year Parts Limited Warranty, online registration must be completed within 60 days of installation. Additional requirements for annual maintenance are required for the Unit Replacement Limited Warranty. Online registration and some of the additional requirements are not required in California or Quebec. SS-DVPTC 5/16 Supersedes 11/15

2 Nomenclature D V 25 P T C B 1 4 AA 1 2 3, ,12 Brand Engineering * D - Daikin Single- Piece Major/ Minor Revisions Air Handler *Not used for inventory management Unit Application Refrigerant Compatability V - Multi- Position 4 = R- 410A Variable- Speed Motor Electrical Nominal Capacity Range 1-208/240 V, 1 Phase, 60 Hz 24 = 2 Tons 42 = 3½ Tons 25 = 2 Tons 48 = 4 Tons Cabinet Width 29 = 2 Tons 49 =3-3½ Tons B = 17½" C = 21" 30 = 2½ Tons 59 = 4-5 Tons D = 24½" 31 = 2½ Tons 60 = 5 Tons 36 = 3 Tons 61 = 4-5 Tons Communications 37 = 2½- 3½ Tons C - ComfortNet Compatible Cabinet Finish P - Painted Expansion Device E - Electronic Expansion Valve T - Expansion Valve V - Inverter- Tuned Expansion Valve HKS X 03 X A AA ,7 Unit Type Revisions HKS Heat Kit for Engineering Revisions Air Handlers Phase Circuit Breaker A Single Phase 208 V E Three Phase 240 V X No circuit breaker B Single Phase 240 V F Three Phase 208/240 V C Circuit Breaker C Single Phase 208/240 V G Three Phase 460 V D Three Phase 208 V Heating 240 Volts kw kw Cabinet Size (MAX) kw kw wth 150F limit C C Cabinet kw kw with 170F limit D D Cabinet kw kw X All Cabinet Sizes kw 2 SS-DVPTC

3 Product Specifications DV24 PTCB14** DV25 PTCB14A* DV29 PTCB14A* DV30 PTCC14** DV31 PTCC14A* DV36 PTCC14** DV37 PTCB14A* DV37 PTCC14A* DV37 PTCD14A* Nominal Ratings Cooling (BTU/h) 24,000 24,000 30,000 30,000 30,000 36,000 36,000 36,000 36,000 CFM (High range) 1100/ / / / / / / / /865 Blower Diameter 9½" 9½" 9½" 10⅝" 10⅝" 10⅝" 9½" 10⅝" 10⅝" Width 6" 6" 6" 8" 8" 10⅝" 6" 8" 10⅝" Coil Drain Connection FPT ¾" ¾" ¾" ¾" ¾" ¾" ¾" ¾" ¾" Service Valve Liquid ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" Suction ¾" ¾" ⅞" ⅞" ⅞" ⅞" ⅞" ⅞" ⅞" Electrical Data Voltage 208/ / / / / / / / /240 Electric Heat Capacity (kw) 3, 5, 6, 8, 10 3, 5, 6, 8, 10, 15 3, 5, 6, 8, 10, 15 3, 5, 6, 8, 10 5, 6, 8, 10, 15, 19 5, 6, 8, 10, 15, 19, 20F 3, 5, 6, 8, 10, 15 5, 6, 8, 10, 15, 19 5, 6, 8, 10, 15, 20 Min Circuit Ampacity 4.9/ / / / / / / / /6.5 Max. Overcurrent Device (amps) 15/15 15/15 15/15 15/15 15/15 15/15 15/15 15/15 15/15 Minimum VAC Maximum VAC Blower Motor FLA HP ½ ½ ¾ ½ ¾ ¾ ¾ ¾ ¾ Ship Weight (lbs) Note: Minimum Circuit Ampacity (MCA) and Maximum Overcurrent Protection (MOP) for blower without supplemental heat installed. Refer to unit nameplate and/or Heat Kit Data for specification with approved accessory heaters installed DV42 PTCD14** DV48 PTCC14** DV48 PTCD14** DV49 PTCD14A* DV59 PTCC14A* DV59 PTCD14A* DV60 PTCD14** DV61 PTCD14A* Nominal Ratings Cooling (BTU/h) 42,000 42,000 48,000 42,000 48,000 48,000 60,000 60,000 CFM (High range) 1700/ / / / / / / /1630 Blower Diameter 10⅝" 10⅝" 10⅝" 10⅝" 10⅝" 11¹⁵ ₁₆" 11⅝" 11¹⁵ ₁₆" Width 10⅝" 10⅝" 10⅝" 10⅝" 8" 10⅝" 10⅝" 10⅝" Coil Drain Connection FPT ¾" ¾" ¾" ¾" ¾" ¾" ¾" ¾" Service Valve Liquid ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" ⅜" Suction ⅞" ⅞" ⅞" ⅞" ⅞" ⅞" ⅞" ⅞" Electrical Data Voltage 208/ / / / / / / /240 Electric Heat Capacity (kw) 5, 6, 8, 10, 15, 20 5, 6, 8, 10, 15, 19, 20F 5, 6, 8, 10, 15, 20, 25 5, 6, 8, 10, 15 5,6,8,10,15,19 5, 6, 8, 10, 15, 20 5, 6, 8, 10, 15, 20, 25 5, 6, 8, 10, 15, 20,25 Min Circuit Ampacity 6.5/ / / / / / / /8.6 Max. Overcurrent Device (amps) 15/15 15/15 15/15 15/15 15/15 15/15 15/15 15/15 Minimum VAC Maximum VAC Blower Motor FLA HP ¾ ¾ ¾ ¾ Ship Weight (lbs) Note: Minimum Circuit Ampacity (MCA) and Maximum Overcurrent Protection (MOP) for blower without supplemental heat installed. Refer to unit nameplate and/or Heat Kit Data for specification with approved accessory heaters installed SS-DVPTC 3

4 Dimensions 24/ 30/ 36/ 42/ 48/ 60 Models 1.63" (4.13 cm) 1.45" (3.68 cm) 3.08" (7.82 cm) 21" 4.50" (11.43 cm) 2.91" (7.39 cm) 2.93" (7.44 cm) 7.5" (19.1 cm) 5.2" (13.3 cm) 9.21" DRAIN PORT DETAIL.55" (1.40 cm) C B.55" (1.40 cm) 3.1" (7.9 cm) 1.4" (3.6 cm) 11.3" (28.70 cm).55" (1.40 cm) PLASTIC BREAKER COVER 1.8" (4.6 cm) LOGO LOCATION 2.17" (5.51cm) SUCTION TUBE LIQUID LINE A G INLET TUBE SEE DRAIN PORT DETAIL H E D 1.73" (4.39 cm) F INLET (FRONT VIEW) 1.73" (4.39 cm) 1" (2.54 cm) 19.5" (49.5 cm) INLET (RIGHT SIDE VIEW).55" (1.40 cm) Model A B C D E F G H DV24PTCB ⅜ 17½ ³ ₁₆ 8¹³ ₁₆ 11¹⁵ ₁₆ DV30PTCC ¹⁵ ₁₆ ¹¹ ₁₆ 10½ 12⅜ DV36PTCC ¹⁵ ₁₆ ¹¹ ₁₆ 10½ 12⅜ DV42PTCD ⁵ ₁₆ 24½ 28³ ₁₆ 25³ ₁₆ 21³ ₁₆ 12⁵ ₁₆ 12⅜ DV48PTCC ¹⁵ ₁₆ ¹¹ ₁₆ 10½ 12⅜ DV48PTCD ⁵ ₁₆ 24½ 28³ ₁₆ 25³ ₁₆ 21³ ₁₆ 12⁵ ₁₆ 12⅜ DV60PTCD ⁵ ₁₆ 24½ 28³ ₁₆ 25³ ₁₆ 21³ ₁₆ 12⁵ ₁₆ 12⅜ 4 SS-DVPTC

5 Dimensions 25 / 29/ 31 /37/ 49/ 59 /61 Models 6.1" (15.5 cm) 7.2" (18.3 cm) 4.3" (10.9 cm) 9.21" 21" K J 2.1" (5.3 cm) 7.5" (19.1 cm) 5.1" (13.0 cm).62" (1.57 cm) C B.62" (1.57 cm) 3.0" (7.6 cm) 1.4" (3.6 cm) 11.3" (28.70 cm).52" (1.30 cm) 1.8" (4.6 cm) 2.67" (6.78 cm) 1.74" (4.42 cm) SUCTION TUBE LIQUID LINE A G INLET TUBE SEE HORIZONTAL DRAIN PORT DETAIL 10.17" (25.83 cm) E D SEE VERTICAL DRAIN PORT DETAIL H 1.73" (4.39 cm) F 1.73" (4.39 cm) INLET (FRONT VIEW) 1" (2.54 cm) 19.5" (49.5 cm).54" (1.37 cm) INLET (RIGHT SIDE VIEW) Model A B C D E F G H DV25PTCB14* 45 16⅜ 17½ 15¼ 12 14⅟₆ 9⅛ 12⅝ DV29PTCB14* 53⁷ ₁₆ 16⅜ 17½ 23¹¹ ₁₆ 20½ 14¹ ₆ 9⅛ 7⅝ DV31PTCC14* 53⁷ ₁₆ 19⅞ 21 21¹³ ₁₆ 18⅝ 17¹¹ ₁₆ 10¹³ ₁₆ 6¹³ ₁₆ DV37PTCB14* 53⁷ ₁₆ 16⅜ 17½ 23¹¹ ₁₆ 20½ 14¹ ₆ 9⅛ 7⅝ DV37PTCC14* 53⁷ ₁₆ 19⅞ 21 21¹³ ₁₆ 18⅝ 17¹¹ ₁₆ 10¹³ ₁₆ 6¹³ ₁₆ DV37PTCD14* 53⁷ ₁₆ 23⁵ ₁₆ 24½ 21½ 18⁵ ₁₆ 21³ ₁₆ 12⅝ 6⅞ DV49PTCD14* 58 23⁵ ₁₆ 24½ 26⅛ 22⅞ 21³ ₁₆ 12⅝ 25⅛ DV59PTCC14* 53⁷ ₁₆ 19⅞ 21 21¹³ ₁₆ 18⅝ 17¹¹ ₁₆ 10¹³ ₁₆ 6¹³ ₁₆ DV59PTCD14* 53⁷ ₁₆ 23⁵ ₁₆ 24½ 21½ 18⁵ ₁₆ 21³ ₁₆ 12⅝ 6⅞ DV61PTCD14* 58 23⁵ ₁₆ 24½ 26⅛ 22⅞ 21³ ₁₆ 12⅝ 25⅛ SS-DVPTC 5

6 Airflow Data Model Speed Tap DV24PTCB14 DV25PTCB14AA DV29PTCB14AA DV37PTCB14AA DV30PTCC14 DV31PTCC14AA DV37PTCC14AA DV36PTCC14 A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High Note: When applying a humidistat (normally closed), refer to the installation and operating instructions. The humidistat can adjust the cooling airflow to 85%. 6 SS-DVPTC

7 Airflow Data Model Speed Tap DV59PTCC14AA DV49PTCD14AA DV48PTCD14 DV48PTCC14 DV42PTCD14 DV37PTCD14AA A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High Note: When applying a humidistat (normally closed), refer to the installation and operating instructions. The humidistat can adjust the cooling airflow to 85%. SS-DVPTC 7

8 Airflow Data Model Speed Tap DV61PTCD14AA DV60PTCD14 DV59PTCD14AA A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High A Low B Low C Low D Low A High B High C High D High Note: When applying a humidistat (normally closed), refer to the installation and operating instructions. The humidistat can adjust the cooling airflow to 85%. 8 SS-DVPTC

9 Dipswitch Settings & Electric Heat Airflow HTR KW S9 S10 S11 DV24 PTCB14 DV25 PTCB14 DV29 PTCB14 DV30 PTCC14 DV31PTCC14 DV37PTCC14 DV37 PTCB14 DV37 PTCD14 DV42 PTCD14 3 ON ON ON ** 5 ON ON OFF ON OFF ON ON OFF OFF OFF ON ON OFF ON OFF * OFF OFF ON OFF OFF ON OFF OFF OFF * OFF OFF OFF Note: Airflow data shown applies to the electric heat only in either legacy mode or communicating mode operation * Within thermostat user menu CTK0* communicating thermostat will display 20KW for OFF- OFF- ON dip switch selection, 21kW for OFF-OFF-OFF dip swith selection. NR - Not rated For match-up with a 2-ton outdoor unit; heater kit application shall not exceed 10 kw. Airflow for 5 kw up to 10 kw heater kits shall be set to 850 CFM speed tap of ON-ON-ON. For match-up with a 3-ton outdoor unit; heater kit application shall not exceed 15 kw. Airflow for 5 kw up to 15 kw heater kits shall be set to 1400 CFM speed tap of ON-ON-OFF. For match-up with a 3.5-ton outdoor unit; heater kit application shall not exceed 20 kw. Airflow for 5 kw up to 20 kw heater kits shall be set to 1620 CFM speed tap of ON-ON- OFF. ** 3 kw heater kit is not applicable for this indoor application. HTR KW S9 S10 S11 DV48 PTCC14 DV48 PTCD14 DV49PTC D14 ƚƚ DV59PTC C14 DV59PTC D14 DV60 PTCD14 DV61PTC D14 ƚƚƚ 3 ON ON ON NR ON ON OFF ON OFF ON ON OFF OFF OFF ON ON OFF ON OFF * OFF OFF ON OFF OFF ON OFF OFF OFF * OFF OFF OFF Note: Airflow data shown applies to the electric heat only in either legacy mode or communicating mode operation * Within thermostat user menu CTK0* communicating thermostat will display 20KW for OFF- OFF- ON dip switch selection, 21kW for OFF-OFF-OFF dip swith selection. NR - Not rated For match-up with a 2-ton outdoor unit; heater kit application shall not exceed 10 kw. Airflow for 5 kw up to 10 kw heater kits shall be set to 850 CFM speed tap of ON-ON-ON. For match-up with a 3-ton outdoor unit; heater kit application shall not exceed 15 kw. Airflow for 5 kw up to 15 kw heater kits shall be set to 1400 CFM speed tap of ON-ON-OFF. For match-up with a 3.5-ton outdoor unit; heater kit application shall not exceed 20 kw. Airflow for 5 kw up to 20 kw heater kits shall be set to 1620 CFM speed tap of ON-ON- OFF. ** 3 kw heater kit is not applicable for this indoor application. SS-DVPTC 9

10 Heat Kit Data Models Circuit 1 Circuit 2 Single-Point Kit Amps MCA¹ MOP² Amps MCA¹ MOP² MCA¹ MOP² DV24PTCB14AA 0.0/ /4.9 15/ HKS*03XC* 10.8/ /21 20/ HKS*05XC* 17.3/ /30 30/ HKS*06XC* 21.7/ /36 35/ HKS*08XC* 28.9/ /47 45/ HKS*10XC* 34.7/ /55 50/ DV25PTCB14AA 0/0 4.9/4.9 15/ HKS*03XC* 10.8/ /21 20/ HKS*05XC* 17.3/20 27/ / HKS*06XC* 21.7/25 32/ / HKS*08XC* 28.9/ / / HKS*10XC* 34.7/40 48/ / HKS*15*#* 34.7/40 48/ / / /25 25/ / /80 DV29PTCB14AA 0/0 6.5/6.5 15/ HKS*03XC* 10.8/ / / HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 DV30PTCC14AA 0.0/ /4.9 15/ HKS*03XC* 10.8/ /21 20/ HKS*05XC* 17.3/ /30 30/ HKS*06XC* 21.7/ /36 35/ HKS*08XC* 28.9/ /47 45/ HKS*10XC* 34.7/ /55 50/ DV31PTCC14AA 0/0 6.5/6.5 15/ HKS*03XC* HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 HKSC19C*#* 34.7/ /57 50/ / /50 45/ / /110 HKS*15XF* 0/0 6.5/6.5 15/15 30/ /43 40/ DV36PTCC14AA 0.0/ /6.5 15/ HKS*03XC* 10.8/ /22 20/ HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKSC15*#* 34.7/ /57 50/ / /25 25/25 72/82 80/90 HKSC19C#* 34.7/ /57 50/ /40 43/50 45/50 93/ /110 HKSC15XF* 0.0/ /6.5 15/ / /43 40/ HKSC20XF* 0.0/ /6.5 15/ / /54 50/ DV37PTCB14AA 0/0 6.5/6.5 15/ HKS*03XC* 10.8/ / / HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 See Notes on Page SS-DVPTC

11 Heat Kit Data Models Circuit 1 Circuit 2 Single-Point Kit Amps MCA¹ MOP² Amps MCA¹ MOP² MCA¹ MOP² DV37PTCC14AA 0/0 6.5/6.5 15/ HKS*03XC* HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 HKSC19C*#* 34.7/ /57 50/ / /50 45/ / /110 HKS*15XF* 0/0 6.5/6.5 15/15 30/ /43 40/ DV37PTCD14AA 0/0 6.5/6.5 15/ HKS*03XC* HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 HKSC20D#C* 34.7/ /57 50/ / /50 45/ / /110 HKS*15XF* 0/0 6.5/6.5 15/15 30/ /43 40/ HKS*20XF* 0/0 6.5/6.5 15/ /43 47/54 50/ DV42PTCD14AB 0.0/ /6.5 15/ HKS*03XC* 10.8/ /22 20/ HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKSC15*#* 34.7/ /57 50/ / /25 25/25 72/82 80/90 HKSC20D#* 34.7/ /57 50/ /40 43/50 45/50 93/ /110 HKSC15XF* 0.0/ /6.5 15/ / /43 40/ HKSC20XF* 0.0/ /6.5 15/ / /54 50/ DV48PTCC14AA 0.0/ /6.5 15/ HKS*03XC* 10.8/ /22 20/ HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKSC15*#* 34.7/ /57 50/ / /25 25/25 72/82 80/90 HKSC19C#* 34.7/ /57 50/ /40 43/50 45/50 93/ /110 HKSC15XF* 0.0/ /6.5 15/ / /43 40/ HKSC20XF* 0.0/ /6.5 15/ / /54 50/ DV48PTCD14AB 0.0/ /6.5 15/ HKS*03XC* 10.8/ /22 20/ HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKSC15*#* 34.7/ /57 50/ / /25 25/25 72/82 80/90 HKSC20D#* 34.7/ /57 50/ /40 43/50 45/50 93/ /110 HKSC15XF* 0.0/ /6.5 15/ / /43 40/ HKSC20XF* 0.0/ /6.5 15/ / /54 50/ HKSC25DC* 52.0/ /84 80/ / /50 45/50 117/ /150 See Notes on following page. SS-DVPTC 11

12 Heat Kit Data Models Circuit 1 Circuit 2 Single-Point Kit Amps MCA¹ MOP² Amps MCA¹ MOP² MCA¹ MOP² DV49PTCD14AA 0/0 6.5/6.5 15/ HKS*03XC* HKS*05XC* 17.3/ /32 30/ HKS*06XC* 21.7/ /38 35/ HKS*08XC* 28.9/ /48 45/ HKS*10XC* 34.7/ /57 50/ HKS*15*#* 34.7/ /57 50/ / /25 25/ / /90 HKSC20D#C* HKS*15XF* HKS*20XF* HKSC25DC* DV59PTCC14AA 0/0 8.6/8.6 15/ HKS*03XC* HKS*05XC* 17.3/ /34 35/ HKS*06XC* 21.7/25 36/ / HKS*08XC* 28.9/ / / HKS*10XC* 34.7/40 52/ / HKSC15*#* 34.7/40 52/ / / /25 25/ / /90 HKSC19C#* 34.7/40 52/ / / /50 45/ / /110 HKSC15XF* 0/0 8.6/8.6 15/15 30/ /43 40/ HKSC20XF* DV59PTCD14AA 0/0 8.6/8.6 15/ HKS*03XC* HKS*05XC* 17.3/ /34 35/ HKS*06XC* 21.7/25 36/ / HKS*08XC* 28.9/ / / HKS*10XC* 34.7/40 52/ / HKS*15*#* 34.7/40 52/ / / /25 25/ / /90 HKSC20D#C* 34.7/40 52/ / / /50 45/ / /110 HKS*15XF* 0/0 8.6/8.6 15/15 30/ /43 40/ HKS*20XF* 0/0 8.6/8.6 15/ /43 47/54 50/ DV60PTCD14AC 0.0/ /8.6 15/ HKS*03XC* 10.8/ /24 25/ HKS*05XC* 17.3/ /34 35/ HKS*06XC* 21.7/ /40 40/ HKS*08XC* 28.9/ /50 45/ HKS*10XC* 34.7/ /59 60/ HKSC15*#* 34.7/ /59 60/ /20 22/25 25/25 74/84 80/90 HKSC20D#* 34.7/ /59 60/ / /50 45/50 95/ /110 HKSC15XF* 0.0/ /8.6 15/ / /43 40/ HKSC20XF* 0.0/ /8.6 15/ / /54 50/ HKSC25DC* 52.0/ /84 80/90 35/40 43/50 45/50 117/ /150 DV61PTCD14AA 0/0 8.6/8.6 15/ HKS*03XC* HKS*05XC* 17.3/ /34 35/ HKS*06XC* 21.7/25 36/ / HKS*08XC* 28.9/ / / HKS*10XC* 34.7/40 52/ / HKS*15*#* 34.7/40 52/ / / /25 25/ / /90 HKSC20D#C* 34.7/40 52/ / / /50 45/ / /110 HKS*15XF* 0/0 8.6/8.6 15/15 30/ /43 40/ HKS*20XF* 0/0 8.6/8.6 15/ /43 47/54 50/ HKSC25DC* 52/ /84 80/ / /50 45/50 117/ /150 ¹ Minimum Circuit Ampacity (Heater Amps + Motor Amps) X 1.25 ² Maximum Overcurrent Protection = 2.25 X Motor Amps + Heater Amps ^ Circuit 1: Single-phase for Air Handlers Circuit 2: Three-phase for HKR3 Heater Kits * Revision level that may or may not be designated C = Circuit Breaker Option --- indicates Not Required HKA meets the new UL1995 requirements for 15 and 20KW heaters 12 SS-DVPTC

13 Air Handler Wiring Diagram PL1 PL VA TRANSFORMER, SEE NOTE VAC 208 VAC VAC GRND GN L1 GRND L SEE NOTE 7 GY COM WH BR CIRCUIT HEATER CONNECTOR SEE NOTE 5 FAULT RECALL C 4 CIRCUIT MOTOR CONNECTOR 2 SEE NOTE 6 ECM MOTOR HARNESS 1 1 W2 W1 CFM LED AF SELECT STATUS LED TRIM % COOL AF PROFILE LEARN SEE NOTE 6 DIP SWITCHES CONT FAN COM CAS SEE NOTE 8 7 SEGMENT DIAGNOSTIC DEHUM DISPLAY DEHUM ENAE TRIM ENAE TWO-STAGE INTEGRATED CONTROL MODULE CIRCULATOR OWER TH 24 V 3 A FUSE SEE NOTE 6 RX LED HTR KIT(KW) S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S O Y2 Y1 W2 W1 GN G C R 2 1 TR 24 V THERMOSTAT CONNECTIONS GRND 24V THERMOSTAT CONNECTIONS R W1 W2 Y1 Y2 O DISCONNECT DEHUM C L1 FUSE 3 A TO MICRO INDOOR AIR CIRCULATOR WR GRND 208/230 VAC L2 40 VA TH TRANSFORMER 24 VAC W1 (1) HEAT 1 COIL/R1 W2 (2) HEAT 2 COIL/ R2 CAS (1) CONDENSATE SWITCH CAS (2) +VDC (1) RX (2) INDOOR AIR CIRCULATOR WR GRND (4) TR COM INTEGRATED CONTROL MODULE GRND INTEGRATED CONTROL NOTES: 1. PLACE RED WIRES ON TRANSFORMER TERMINAL 2 FOR 208 VAC OPERATION. 2. MANUFACTURER'S SPECIFIED REPLACEMENT PARTS MUST BE USED WHEN SERVICING. 3. IF ANY OF THE ORIGINAL WIRES AS SUPPLIED WITH THIS UNIT MUST BE REPLACED, IT MUST BE REPLACED WITH WIRING MATERIAL HAVING A TEMPERATURE RATING OF AT LEAST 105 C. USE COPPER CONDUCTORS ONLY. 4. UNIT MUST BE PERMANENTLY GROUNDED AND CONFORM TO N.E.C AND LOCAL CODES. 5. TO RECALL THE LAST 6 FAULTS, MOST RECENT TO LEAST RECENT, DEPRESS SWITCH FOR MORE THAN 2 SECONDS WHILE IN STANDBY (NO THERMOSTAT INPUTS) 6. RED STATUS LED PROVIDES NETWORK STATUS. GREEN RX LED INDICATES NETWORK TRAFFIC. USE LEARN BUTTON TO RESET NETWORK. 7. DISCA CONNECTOR PL1 WHEN INSTALLING OPTIONAL HEAT KIT. 8. THE CONDENSATE ALARM SWITCH (CAS) TERMINALS CAN ONLY BE UTILIZED WITH COMMUNICATING MODE SETUPS AND MUST BE ENAED WITH A COMMUNICATING THERMOSTAT. THIS FEATURE IS NOT OPERATIONAL WITH LEGACY SYSTEMS. USE N.E.C CLASS 2 WIRE. LOW VOLTAGE (24V) LOW VOLTAGE FIELD HI VOLTAGE (230V) HI VOLTAGE FIELD JUNCTION TERMINAL INTERNAL TO EQUIPMENT GRND FIELD GRND FIELD SPLICE RESISTOR OVERCURRENT PROT. DEVICE PLUG CONNECTION COLOR CODES: PK ---- PINK BR ---- BROWN WH ---- WHITE ---- UE GY ---- GRAY ---- RED YL ---- YELLOW OR ---- ORANGE PU ---- PURPLE GN ---- GREEN ---- ACK 0140A00244-B Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. Warning High Voltage: Disconnect all power before servicing or installing this unit. Multiple power sources may be present. Failure to do so may cause property damage, personal injury, or death. SS-DVPTC 13

14 Three-Phase Heater Kit Wiring Diagram NOTE: WHEN INSTALLING HEATER KIT, ENSURE SPEED TAP MUST EXCEED OR EQUAL THE MINIMUM OWER SPEED (MBS) SPECIFIED FOR THE AIRHANDLER/HEATER KIT COMBINATION ON THIS UNIT'S SERIAL PLATE. AFTER INSTALLING OPTIONAL HEAT KIT, MARK AN "X" IN THE PROVIDED BELOW. NO MARK INDICATES NO HEAT KIT INSTALLED. PC L1 TB L2 CIRCUIT 1 1 PH V FL HTR3 TL 1 2 L1 L2 TR FL HTR2 TL PU 3 PU L3 L2 L1 GND L1 L2 L3 CIRCUIT 2 3 PH V CC R T1 T2 T3 WH FL HTR1 TL M1 PU M2 PU WH RS M3 M4 BR WH WH WH WH WH BR GR PK EBTDR GR NO K1 XFMR-R XFMR-C COM K1 C NC SPEEDUP M1 SR RC BR BR EM PU L1 PU NOTE:- THIS LABEL MUST BE ATTACHED ON THE AIRHANDLER IN A PROMINENT LOCATION L1 PK RC AR POWER SUPPLY (CIRCUIT 1) TR EM VOLT 5 208/240 VOLTS LOW M1 HIGH C NC NO EBTDR COM GR GR EBTDR L2 PC BR W W2 W1 HKR POWER SUPPLY (CIRCUIT 2) L1 L2 L3 T1 T2 T3 FL HTR3 TL FL HTR2 TL FL M2 M 4 HTR1 M1 M 3 CC RS TL HEATER CONTROL COMPONENT CODE HTR HEAT ELEMENT EM EVAPORATOR MOTOR EBTDR ELEC. OWER TIME DELAY RELAY RS RELAY/SEQUENCER RC RUN CAPACITOR TL THERMAL LIMIT TR TRANSFORMER TB TERMINAL OCK CC CONTACTOR PC 9-PIN CONNECTOR SR STRAIN RELIEF FL FUSE LINK CB CIRCUIT BREAKER WIRING CODE HIGH VOLTAGE LOW VOLTAGE COLOR CODE ACK UE BR BROWN GR GREEN OR ORANGE PK PINK PU PURPLE RED WH WHITE YL YELLOW 0140M00273-A Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. Warning High Voltage: Disconnect all power before servicing or installing this unit. Multiple power sources may be present. Failure to do so may cause property damage, personal injury, or death SS-DVPTC

15 Accessories Downflow Kits DFK-B DFK-C DFK-D DV24PTCB14** DV30PTCC14** DV42PTCD14** DV25PTCB14** DV36PTCC14** DV48PTCD14** DV29PTCB14** DV48PTCC14** DV60PTCD14** DV37PTCB14** DV31PTCC14** DV37PTCD14** DV37PTCC14** DV59PTCC14** DV59PTCD14** DV49PTCD14** DV61PTCD14** Filters Chassis Part# Size B ALFH16201E 16.0" x 20.0" C ALFH E 19.5 x 20.0 D ALFH20231E 23.0 x 20.0 Single Point Kit ** Model HKR-15C HKR-20C HKR-21C SPW-01 X X X ** Must be installed along with any of the above compatible heat kits. This kit will fit any DVPTC air handler as long as a compatible heat kit is installed in the unit. SS-DVPTC 15

16 Notes Our continuing commitment to quality products may mean a change in specifications without notice Houston, Texas Printed in the USA SS-DVPTC