KANTI BIJLEE UTPADAN NIGAM LIMITED (KBUNL) (A Joint Venture of NTPC Ltd. And BSEB ) SCHEDULE (BILL) OF QUANTITIES (Percentage Rate Contract)

Transcription

1 KANTI BIJLEE UTPADAN NIGAM LIMITED (KBUNL) (A Joint Venture of NTPC Ltd. And BSEB ) TENDER NO. 39/OT/R/KBUNL-MTPP/Formation /PKG- II/2013 Dated Tender and Contract document for earthwork in railway formation including blanketing materials, construction of Minor Bridges, drains etc in connection with Project Management & Construction of Coal transportation system for Muzaffarpur Thermal Power Project, Stage-II (2x195MW) of Kanti Bijlee Utpadan Nigam Limited(KBUNL) at Muzaffarpur, Bihar. PART- 2 FINANCIAL BID CONTENTS SCHEDULE (BILL) OF QUANTITIES (Percentage Rate Contract) Issued to (Name of Tenderer): Address of tenderer: Signature of officer issuing the documents Designation Date of Issue RITES Ltd. (A Govt. of India Enterprise) Regional Project Office Metro Railway Service Building, 2 nd Floor 56 C. R. Avenue, Kolkata Under seal of the firm Page 1

2 ABSTRACT OF SCHEDULE (BILL) OF QUANTITIES (PERCENTAGE RATE CONTRACT) Name of the work: Earthwork in railway formation including blanketing materials, construction of Minor Bridges, drains etc in connection with Project Management & Construction of Coal transportation system for Muzaffarpur Thermal Power Project, Stage-II (2x195MW). Of Kanti Bijlee Utpadan Nigam Limited(KBUNL) (PERCENTAGE TO BE QUOTED BY THE BIDDER) SCHEDULE DESCRIPTION TOTAL ESTIMATED COST (IN RUPEES) (A) Railway Formation and blanketing works. Rs.7,34,29, (Rupees seven crore thirty four lakh twenty nine thousand one hundred fifty one & paise eighty two) (B) Bridge & Drain works. Rs. 4,14,06, (Rupees four crore fourteen lakh six thousand eight hundred twenty and paise fifteen) TOTAL ESTIMATED COST OF SCHEDULES (A) TO (B) (RUPEES) PERCENTAGE ABOVE (+) OR BELOW (-) OF TOTAL ESTIMATED COST OF SCHEDULES (A) TO (B) AS QUOTED Rs.11,48,35, (Rupees eleven crores forty eight lakhs thirty five thousand nine hundred seventy two only) PERCENTAGE IN FIGURES PERCENTAGE IN WORDS * (+) or (-) * (PLUS) or (MINUS) TOTAL QUOTED COST OF SCHEDULS (A) TO (B) BASED ON PERCENTAGE QUOTED (+) or (-) (RUPEES) AMOUNT IN FIGURES (RUPEES) AMOUNT IN WORDS (RUPEES) LESS REBATE ( (IN WORDS) %), IF ANY Rs. NET QUOTED COST OF SCHEDULES (A) TO (B) (RUPEES) * strike out which is not applicable i. SIGNATURE OF AUTHORISED SIGNATORY OF TENDERER ii. NAME OF SIGNATORY iii. NAME AND SEAL OF TENDERER iv. DATE v. PLACE Under seal of the firm Page 2

3 SCHEDULE (BILL) OF QUANTITIES Open Tender Notice 39/OT/R/KBUNL-MTPP/Formation /PKG-II/2013 Dated Name of the work: Earthwork in railway formation including blanketing materials, construction of Minor Bridges, drains etc in connection with Project Management & Construction of Coal transportation system for Muzaffarpur Thermal Power Project, Stage-II (2x195MW). of Kanti Bijlee Utpadan Nigam Limited(KBUNL) at Muzaffarpur, Bihar. SCHEDULE A (Railway Formation and Blanketing Works) SL 1 Site clearance including removal of 10 sqm grass/vegetation, shrubs and trees up to 30cm girth as per specification and disposal (Rupees ninety four) only with all lead as directed by the Engineer in Charge 2. Felling of trees of girth ( measured at a height of 1m above ground level) including lead and stacking of material within 100m. Note: 1. When girth over 60 cm and upto 1.5m 3 Earthwork in cutting (classified) in formation, trolley refuges, side drains, level crossing approaches, platforms, catch water drains, diversion of nallah & finishing to required dimension and slopes to obtain a neat appearance to standard profile inclusive of all labour, machine & materials and removing & leading all cut spoils either to make spoil dumps beyond 10m from cutting edge or for filling in embankment with all leads within the section limit, lifts, ascent, descent, loading, unloading, all taxes/royalty, clearance of site and all incidental charges, bailing & pumping out water, if required, etc. complete as per directions of the Engineer-in-Charge. The work is to be executed as per latest / updated edition of "Guidelines for Earthwork in Railway Projects" issued by RDSO, Lucknow. Cut trees shall be property of KBUNL and to be deposited in the KBUNL godown unless specified otherwise in the Special Conditions of Contract Note - (i) All usable earth arising from cut spoils shall be led into bank formation and Unusable spoils shall be dumped / stacked (ii) All hard rock /and boulders not fit for filling will be stacked by the contractor and will be property of the KBUNL In all conditions and classifications of soil except rock Each (Rupees two ninety eight and paise forty) cum hundred sixty three & paise eighty one) Under seal of the firm Page 3

4 4 Removal of excavated / slip earth / debris / malba from the site of works to any other cum (Rupees one hundred place outside KBUNL Land/premises, thirty seven & including all excavations, handling, rehandling, paise thirty five) loading, unloading & leading etc. all labour and material as a complete job. Removal of Earth (all kinds of soils)/rocks, Boulders including mud/slush, slipped earth in catch water drains, side drains, over berms in cutting, water way of bridges, over coping of toe/breast/retaining walls, etc. including crossing of nallah, railway tracks, making/repairing approach roads, if required, all lead, lift, ascent, descent, or any other obstruction. Earth spoils to be dumped out side the cutting or railway embankments as per direction of Engineerin-charge. 5. Earthwork in filling in embankment, guide bunds, around buried type abutments, bridge gaps, trolley refuges, rain bunds, if cum (Rupees two hundred forty two & paise provided, platforms etc. with earth zero five) excavated from outside MTPS boundary entirely arranged by the contractor at his own cost as per RDSO's latest guidelines and specifications and special condition of contract including all leads, royalty, lifts, ascents, descents, crossing of nallahs or any other obstructions. The rates shall include all dressing of bank to final profile, demarcation and setting out of profile, site clearance, removing of shrubs, roots of vegetation growth, heavy grass, benching of existing slope of old bank, all handling/re-handling, taxes, octroi and royalty etc. as a complete job, but excluding of compaction which shall be paid separately. Cut trees shall be property of KBUNL and to be deposited in the KBUNL godown unless specified otherwise in the Special Conditions of Contract. Under seal of the firm Page 4

5 6. Supplying, laying & spreading Blanketing cum material as per RDSO specification over the embankment / cutting in layer of 30 cm in loose state to make the embankment of designed profile as per approved drawing and specification. The rate shall include cost thousand five hundred seventy four and paise fifty one) of material, all lead, lift ascent,descent, testing, supply of labour, royalty/taxes, initial site clearance, cutting of shrubs, removal of roots of vegetation growth & heavy grass, surfacing & leveling to give required slope, benching, if required on existing bank slope, dressing and finishing of bank, final dressing of slopes and top surface as per specified camber using contractor s own machinery, equipment, T&P, labour etc. as a complete job. note: (i)compaction of blanketing will be paid by item no -07 (ii) Measurement shall be recorded for the compacted layer of blanketing material. on pre & post work level. 7. Extra for mechanical compaction of Cum (Rupees earth/blanketing material filled in fourteen & Paise embankment with contractor s rollers of eighty) suitable capacity, type and size to achieve specified density as per specification, testing as per IS codes including cost of water, T&P, consumable material and all labour as a complete job. The work is to be executed as per Latest edition of "Guidelines for Earthwork in Railway Projects" issued by RDSO, Lucknow. 8. Dismantling steel work and trusses upto 10m span and 5m height in built up sections in angles, tees,flats, and channels including all gusset plates, bolts, nuts, cutting rivets, welding etc including dismembering and stacking within 50m lead. 9. Turfing / planting, including all lead & lift and watering as required until properly rooted with. Note - Initially payment of only 40% will be made. Balance 60% will be paid only after 3 months of maintenance period, if the turfing is properly rooted.turfing with sods, 10cm thick and 20cm square closely laid Total of Schedule A Kg (Rupee one and paise fifteen) 100 Sqm (Rupees five thousand one hundred sixty and paise thirty eight) Rs.7,34,29, Under seal of the firm Page 5

6 Schedule-B (Bridge and Drain Works) 1 Earthwork in excavation for foundations and floors of the bridges, retaining walls etc. including setting out, dressing of sides, ramming of bottom, getting out the excavated material, back filling in layers with approved material and consolidation of the layers by ramming and watering etc. including all lift, disposal of surplus soil upto a lead of 300m, all types of shoring and strutting with all labour and material complete as per drawing and technical specification as directed by Engineer in charge. All kinds of soils 2 Demolishing plain cement concrete including disposal of material within 50m lead a 1:2:4 or richer mix with max. 20 mm coarse aggregate b Mix leaner than 1:2:4 with coarse aggregate larger than 20mm cum (Rupees two hundred ninety two & paise ninety three) only Cum (Rupees four hundred eighty nine & paise sixty one) only cum (Rupees two hundred ninety seven & paise twenty four) only 3 Demolishing brick work including stacking of serviceable material and disposal of unserviceable material within 50m lead In cement mortar cum (Four hundred & pause sixty three only) 4 Supplying, spreading and filling coarse sand (non cohesive materials to be used) of approved quality including watering and ramming in foundation, plinth, behind the abutment, wing wall, retaining wall in layers not exceeding 150mm thick including its compaction as per direction of Engineer-incharge. The rate includes all lead, lift, ascent, descent, crossing of Railway line etc. complete with contractor s labour, materials, tools and plant. Cum thousand three hundred eighteen & paise forty four) only 20,97, Under seal of the firm Page 6

7 5. Providing and laying in position machine mixed, machine vibrated and machine batched Design Mix Cement Concrete M35 grade (Cast in-situ) in bottom/top slab, side walls, toe wall and sumps haunch filling head walls or any other component using 20mm graded crushed stone aggregate and coarse sand of approved quality of cast insitu RCC box of size upto 5m (bigger inside dimension) including finishing. Admixtures Cum (Rupees seven thousand eight hundred twenty nine and paise ten) 1,14,69, in recommended proportions (as per IS:9103), if approved in Mix design, to accelerate, retard setting of concrete, improve workability without impairing strength and durability, complete as per drawings and technical specifications as directed by Engineer in charge. Payment for reinforcement and shuttering shall be paid extra. 6. Providing and laying in position machine mixed, machine vibrated and machine batched Design Mix Mass Cement Concrete M-25 grade (cast in-situ) using 20mm graded crushed stone aggregate and coarse sand of approved quality in Drop and curtain wall and alike structures below bed level, excluding the cost of centring, shuttering and finishing complete as per drawings and technical specifications as cum (Rupees seven thousand six hundred forty nine and paise eighty) 91,10, directed by Engineer. Payment for reinforcement and shuttering shall be paid extra. 7 Plain Cement concrete 1:2:4 (1 cement, 2 coarse sand and 4 stone agreegate) nominal mix with Contractor's cement, broken hard graded stone aggregate 20mm down and sand of approved quality in foundation, etc., including all labour and materials required for curing, tools & plants for work, dewatering, if required during progress of work, with all lead, lift, descent, loading, unloading, royalty, filler materials etc., complete in all respect excluding shuttering works. cum (Rupeessix thousand six hundred fifty six and paise seventy nine) 6,65, Under seal of the firm Page 7

8 8 Supplying reinforcement for R.C.C. work including straightening, cutting, bending, placing in position and binding all complete - Thermo Mechanically Treated bars Kg (Rupees 1,22,60, conforming to IS-1786, Fe-500 sixty four & (SAIL,TISCON,SRMB,RINL & JSPL) paise forty six) 9 Providing and applying two coats of coal tar or bitumen confirming to IS: on the top and sides of RCC 1.70 kg/sqm after cleaning the surface with all labour and materials complete job as directed by the Engineer 10 Centering and shuttering including strutting, propping etc. and removal of form for : a Foundations, footings, bases of columns, raft foundation of washable aprons, Pile caps, Footings of FOB etc. b 11 Walls (any thickness) including attached plasters, buttresses, plinth and string courses etc. Hand Packed dry boulder filling on the back side of abutment, return wall, wing wall, drop wall, bridges floor at flow area etc. including supply, carriage of stone. Cost of all material & labour with all lead & Lift with boulder size 200mm to 250 mm. 12 Providing weep holes by making suitable openings in plain/rcc concrete abutment,wing wall/return wall with 100mm dia AC pipe,extending through the full width of the structural complete mm thick (average) Dry Stone flooring with boulders of not less than 35kg each in weight, hand packed with surface levelled off to the correct section with hammer dressing as necessary on the ground including filling the gaps with quarry spalls and ordinary sand complete including cost of supply of all materials, labour, lead, lift, tools, plants, crossing of tracks and the like as per drawing and technical specification as directed by Engineer in charge sqm hundred four & paise ninety eight) sqm hundred thirty eight & paise thirty) sqm (Rupees two hundred twenty seven & paise forty) cum thousand eighty seven & paise sixty five) metre (Rupees three hundred seventy three & paise ninety three) cum thousand eighty seven & paise sixty five) only 2,97, ,68, ,00, ,49, ,11, ,92, Under seal of the firm Page 8

9 14 Providing and laying of filter media cum ,67, consisting of granular material of (Rupees nine GW,GP,SW groups as per IS: in required profile behind boulder filling of abutment, wing wall /return wall etc. above hundred forty three & paise forty two) only bed level with all labour and material complete job as per drawing and technical specification of RDSO Guide line. 15. Any other unforeseen item which may arise LS LS LS 10,00, during the execution of the work, not covered under the items of work ( 1 to 9 of Schedule- A and 1 to 14 of Schedule- B above) shall be operated from E.C.Railway unified standard schedule of rates Basic cost Rs.10,00,000/- Total of Schedule- B 4,14,06, Grand total ( Sch-A+B) 11,48,35, (Say Rs. 11,48,35,972.00) Under seal of the firm Page 9